For residential use only. Do not use for commercial cooking. WARNING CALIFORNIA PROPOSITION 65 Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2 • 463247504...
(Please note that the warranty gives you specific legal rights and may also have integrity of the steel is not affected by the flame, only the other rights which vary from state to state. appearance.) 463247504 • 3...
PARTS DIAGRAM – Model No. 463247504 I I I NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. 463247504 • 5...
ASSEMBLY – Model No. 463247504 Place sideburner shelf over left cart legs. Lip of shelf should fit between grill bottom and leg brace. ( It may be necessary to slightly loosen the two screws from inside the grill bottom, and tighten them again once shelf is attached.
Page 7
Valve should be in center hole in burner tube. Insert valve clip into small hole in bottom of burner, then snap other end of clip over sideburner valve. Place brass top on sideburner, then place sideburner grate onto shelf. Valve clip 463247504 • 7...
Tool hook Towel Bar Hardware Place flametamers (4) over burners by inserting tabs into slots in front of firebox. Opposite ends of flametamers rest on pins in back of firebox. NOTE: SwingAway not shown for clarity. 8 • 463247504...
Page 9
Place cooking grates into grill bottom. NOTE: SwingAway not shown for clarity. Open cart doors to attach condiment baskets. Slide basket wires into brackets on doors. Cart door Condiment basket 463247504 • 9...
Page 10
Hang the match-lighting sticks and chains from the small hooks on the right and left side panels. Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor cap onto ignitor. – AA Battery 10 • 463247504...
On left side of grill, adjust position of collar to rest in bracket, then tighten collar thumbscrew. NOTE: SwingAway must be removed when using rotisserie. Left side of grill Right side of grill Rotisserie motor Spit Collar Bracket Motor bracket 463247504 • 11...
See Use & Care section for important safety instructions. Please read “Connecting Your Natural Grill to the Natural Gas Gas Hose Source”, “Leak Test”, and “Burner Flame Check” before using grill. 12 • 463247504...
, on the following page, shows properly Connection should be made by a certified plumber. Supply the connected hose and socket. plumber with a copy of these instructions. Incorrect connection can result in a gas leak with possibility of fire. 463247504 • 13...
Page 14
Order new parts by giving the serial, model number and name in. water column pressure drop. Only ANSI Z21.54 approved of items needed to the Grill Service Center at 1-800-241-7548. hoses should be used with this grill. Always close gas source after performing leak test. 14 • 463247504...
(3) foot (1 meter) clearance from walls or rails. Do not use on or under balconies. • NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous. 463247504 • 15...
Valves should turn smoothly. Be sure burner lights and stays lit. Hose Check • Before each use, check to see if hoses are cut or worn. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer. 16 • 463247504...
Grease tray CAUTION • Failure to install receptacle on tray will cause hot grease to drip from bottom of grill with risk of fire or property damage. Grease receptacle 463247504 • 17...
Page 18
VERY IMPORTANT: Burner tubes must reengage valve openings. See illustrations below. 8. Carefully replace burners. 9. Replace cotter pin beneath each burner. 10. Replace grease tray, grease receptacle, flametamers and cooking grates. 18 • 463247504...
Page 19
When reheating takeout foods or fully cooked meats like hot dogs, grill to 165° F, or until steaming hot. 2 Burner Cooking Great indirect cooking on low. Produces slow, even heating. Ideal for slow roasting and baking. 463247504 • 19...
Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan...
Separate raw meats and poultry from ready-to-eat foods to avoid cross contamination. Use a clean platter and utensils when removing cooked foods. Cook: Cook meat and poultry thoroughly to kill bacteria. Use a thermometer to ensure proper internal food temperatures. Chill: Refrigerate prepared foods and leftovers promptly. 463247504 • 21...