Product Features; High Elevations; Gas Pressures; Gas Specifications & Orifices - Monessen Hearth BDV300N/PV7 Installation And Operation Instructions Manual

PRoDuCt FeAtuReS and GAS SPeCIFICAtIoNS
PRoDuCt SPeCIFICAtIoNS
•
This appliance has been certified for use with either
natural or propane gas. Refer to appropriate data
plates.
•
This appliance is not for use with solid fuels.
•
The appliance is approved for bedroom or bedsitting
room installations.
•
The appliance must be installed in accordance with local
codes if any. If none exist use the current installation
code. ANSI Z223.1/NFPA 54 in the USA, CSA B149 in
Canada.
•
This appliance is mobile home approved.
•
The appliance must be properly connected to a venting
system.
•
The appliance is not approved for closet or recessed
installations.
Hi/Lo Knob
Off/Pilot/On Knob
On/Off/RS Switch
Ignitor
Blower Control
Figure 1 -
BDV300/400/500/600 Fireplace
(Millivolt Control Shown)

hIGh eleVAtIoNS

Input ratings are shown in BTU per hour and are certified
without deration for elevations up to 4,500 feet (1,370
m) above sea level.
FP2087
For elevations above 4,500 feet (1,370 m) in USA,
installation must be in accordance with the current
DVB features
ANSI Z223.1/NFPA 54 and/or local codes having juris-
diction.
In Canada, please consult provincial and/or local
authorities having jurisdiction for installation at eleva-
tions above 4,500 feet (1,370 m).

GAS PReSSuReS

Inlet Minimum
Inlet Maximum
Manifold Pressure
20301836
FP2087
Optional Remote
Receiver
Natural Propane (LP)
4.5" w.c. 11.0" w.c.
10.5" w.c. 13.0" w.c.
3.5" w.c. 10.0" w.c.
BDV7 Series Direct Vent Gas Fireplace
GAS SPeCIFICAtIoNS & oRIFICe SIZe
Model Fuel
BDV300NV7 Nat.
BDV300PV7 LP
BDV300NSC7 Nat.
BDV300NPC7 LP
BDV400NV7 Nat.
BDV400PV7 LP
BDV400NSC7 Nat.
BDV400NPC7 LP
BDV500NV7 Nat.
BDV500PV7 LP
BDV500NSC7 Nat.
BDV500PSC7 LP
BDV600NV7 Nat.
BDV600PV7 LP
BDV600NSC7 Nat.
BDV600PSC7 LP

BeFoRe you StARt

Read this homeowner manual thoroughly and follow all
instructions carefully. Inspect all contents for shipping
damage and immediately inform your dealer if any damage
is found. Do not install any unit with damaged, incomplete,
or substitute parts. Check your packing list to verify that
all listed parts have been received. You should have the
following:
•
Fireplace (Firebox and Burner System)
•
Rock Wool
•
Log Set
IteMS RequIReD FoR INStAllAtIoN
•
Phillips Screwdriver
•
Hammer
•
Saw and/or saber saw
•
Electric Drill and Bits
•
Pliers
•
Square
•
Caulking Material (Noncombustible)
•
Fireplace Surround Material (Noncombustible)
•
Piping Complying with Local Codes
•
Pipe Sealant Approved for use with Propane/LPG
(Resistant to Sulfur Compounds)
Max.Input Min. Input
BTU/h BTU/h
21,000 15,000
21,000 15,000
21,000 15,000
21,000 15,000
24,000 17,000
24,000 17,000
24,000 17,000
24,000 17,000
26,000 20,000
26,000 20,000 1.55 mm
26,000 20,000
26,000 20,000 1.55 mm
26,000 20,000
26,000 20,000 1.55 mm
26,000 20,000
26,000 20,000 1.55 mm
•
Framing Materials
•
Wall Finishing Materials
•
Level
•
Tee Joint
•
Measuring Tape
•
Pipe Wrench
Orifice
Size
#43
#54
#43
#54
#41
#53
#41
#53
#40
#40
#40
#40
5