& Operating Manual XXV Pellet Stove Owners Manual “Ce manuel est disponible en Français sur demande” SaFetY nOtice PleaSe read thiS entire Manual beFOre inStallatiOn and uSe OF thiS Pellet Fuel-burning rOOM heater. Failure tO FOllOw theSe inStructiOnS cOuld reSult in PrOPertY daMage, bOdilY injurY, Or eVen death.
Page 2
.125Always burn dry fuel. Burning fuel with high moisture content. content takes energy to dry and tends to cool the appliance thus, robbing heat from your home. Damp pellet fuel could turn back into sawdust which does not flow properly through the feed system. 3-90-00684R22_04/13 XXV Pellet Stove...
This label is located on the back of the unit. Please copy the Serial Number for future reference. Harman XXV Pellet Stove Label measures: 10.5" high X 5.5"wide Serial #: Model: XXV Residential Space Heating Appliance Fire by Wood Pellets...
A new concept for the XXV is the ability to use the top vent option. Using this method, the XXV can easily replace a wood stove by placing the top vent adapter over the rear vent.
Packaging & ShiPPing MaterialS The power cord is tucked inside the left rear cover panel. To remove MuSt be reMOVed FrOM the StOVe beFOre cord, Loosen the two 5/16" hex heads and slide the panel outward. OPerating. XXV Pellet Stove 3-90-00684R22_04/13...
Alternate floor protector dimension may be used as long as they satisfy the measurement requirements shown below. Minumum size floor protection for a corner installation hearth pad is 36" x 36". Clearance shown as 9" with optional side shields installed. 3-90-00684R22_04/13 XXV Pellet Stove...
Page 7
S t r u c t u r a l i n t e g r i t Y O F t h e ManuFactured hOMe FlOOr, wall, and ceiling/ rOOF MuSt be Maintained. warning dO nOt inStall in a SleePing rOOM. 3-90-00684R22_04/13 XXV Pellet Stove...
Inside Corner Detail Fixed Porch or Deck Closed Openable Openable or Fixed Fixed Closed Openable Sidewalk =Vent Terminal =Air Supply Inlet =Area where termination is mot permitted XXV Pellet Stove 3-90-00684R22_04/13...
Page 9
However, in some cases a perfect seal is not achieved. For this reason and the fact that the XXV operates with a positive vent pressure we specify that the joints also be sealed with silicone.
Page 10
4 1/2" to 10 1/8" thick with a single square opening in the wall of 6-1/2 inches. Canadian Standard, ULC-S627-00 Requires that all out- door-aired appliances must be secured to the structure. XXV Pellet Stove 3-90-00684R22_04/13...
Page 11
Note: Do not place joints within wall pass-throughs. Combustibles cautiOn Keep any materials that may be affected by the elevated exhaust temperatures at least 3 feet away from the flue termination 3 ft. Fig. 10 to Combustibles 3-90-00684R22_04/13 XXV Pellet Stove...
Page 12
* all jOintS FOr cOnnectOr PiPe MuSt be Secured with a MiniMuM OF three ScrewS. chiMneY MuSt be OF a tYPe Suitable FOr SOlid Fuel burning. 6" from pipe to wall Fig. 13 XXV Pellet Stove 3-90-00684R22_04/13...
Page 13
* all jOintS FOr cOnnectOr PiPe MuSt be Secured with a MiniMuM OF three ScrewS. chiMneY MuSt be OF a tYPe Suitable FOr SOlid Fuel burning. Fig. 15 3-90-00684R22_04/13 XXV Pellet Stove...
Page 14
MuSt be OF a tYPe Suitable FOr SOlid PL vent manufacturer's Fuel burning. firestop spacer and support No insulation or other combustible materials are allowed within 3" of the PL vent pipe. 3" min. Fig. 17 XXV Pellet Stove 3-90-00684R22_04/13...
Page 15
Hearth & Home Technologies assumes no responsibility for, nor does the warranty extend to, smoke damage caused by reverse drafting of pellet appliances under shut-down or power failure conditions. 3-90-00684R22_04/13 XXV Pellet Stove...
If error still occurs call your Dealer. 5 Blinks (In Igniter Auto. Mode Only): Indicates that the unit has failed to light within the 36 minute start cycle. To reset - Turn Mode Selector to "OFF", then turn to either mode again.) XXV Pellet Stove 3-90-00684R22_04/13...
4. Record the high draft_____in W.C. (Normal is -.50 to -.60) The control board on the XXV is equipped with a low draft The control will be on the High Draft for a total of 1 minute.
The XXV is a fully automatic stove that features two operating room temperature Mode modes; Stove temperature Mode and room temperature Mode. In Stove Temperature Mode, you select a burn rate and the stove will remain at the same burn rate regardless of the room temperature.
Page 19
If the stove is left to run out of fuel, you may get a 6 blink status light. If this happens simply reset the control board by turning the mode selector to OFF and back ON. 3-90-00684R22_04/13 XXV Pellet Stove...
Page 20
If , at #6 setting, a 1" or less ash bed is not obtainable, it is not a problem. The 1" ash bed is only a maximum burn rate and at most normal settings the ash bed will be larger. XXV Pellet Stove 3-90-00684R22_04/13...
Manual ignitiOn/OPeratiOn The XXV Pellet Stove is capable of manual operation. This also allows the operator to manually control operation during an emergency (i.e. igniter failure, or when using certain generators.) The unit can be switched between "AUTO" and "MANUAL" at any time during operation.
Page 22
If , at #6 setting, a 1" or less ash bed is not obtainable, it is not OPerating. a problem. The 1" ash bed is only a maximum burn rate and at most normal settings the ash bed will be larger. XXV Pellet Stove 3-90-00684R22_04/13...
Distances of more than 25 feet from the unit or in another room are not recommended. The room sensor is essential for the XXV's excellent efficiency. nOte: It is recommended that the room sensor be installed, even if only installed on the rear of the unit as a return air sensor.
5. Open the burn pot clean-out. Clean fly ash from the burn pot and replace the cover. See Figures 39 and 40 on page 6. Remove the ash pan and dispose of ashes in an approved manner, according to local codes. Fig. 35 XXV Pellet Stove 3-90-00684R22_04/13...
Page 25
"OFF" position. Allow the unit to shut- brush. down. Do NOT disconnect the power to the appliance. Do NOT open the appliance door or hopper lid. Contact your dealer to have the unit professionally inspected and cleaned prior to use. Fig. 38 3-90-00684R22_04/13 XXV Pellet Stove...
Page 26
(3 mm or more), it should be removed to reduce the risk of a chimney or venting system Igniter hot lead wires (High temperature) fire. Fig. 41 Viewed is through the ash pan opening. XXV Pellet Stove 3-90-00684R22_04/13...
Page 27
Lay the glass into the door, making sure that the glass is contained within the channels and raised areas of the door itself. Lay the glass retainers into position and install the screws. Tighten each screw evenly to avoid making any stress points. 3-90-00684R22_04/13 XXV Pellet Stove...
Options XXV Top Flue Option - Harman® Part #1-00-677120 The Top Flue option attaches to the exhaust on the rear of the stove, and extends it to the top with a six inch stub. This gives the appearance of a wood stove and also allows venting with existing single wall, connector.
3% or more. The exhaust vent is the only part of the system that is under The XXV is capable of burning all 3 categories of pellets or positive pressure. a mixture of up to 50% shelled corn and pellets.
3 inch or optional 6" top exit Outside Air Size 2 3/8" I.D. inch Fuse rating 6 amp wiring diagram HARMAN - ACCENTRA, XXV, P35I PELLET STOVE WIRING DIAGRAM MALE/FEMALE CONNECTIONS BROWN ROOM SENSOR TERM. P35I WHITE GREEN WIRE IS GROUND...
CAUTION! Always keep appliance doors and hopper lid closed and latched during operation and during power failures to minimize risk of smoke or burn-back. CAUTION! Use only Harman® approved battery back-up devices. Other products may not operate properly, can create unsafe conditions or damage your appliance. XXV Pellet Stove 3-90-00684R22_04/13...
Hearth & Home Technologies liMited liFetiMe warrantY Hearth & Home Technologies, on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer. warrantY cOVerage: HHT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership of the appliance at the site of installation within two years following the date of original purchase, that the HHT appliance...
warrantY cOnditiOnS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. •...
Addendum for Burning Corn and Pellet Fuel Mixture Harman pellet burning, free-standing stoves and inserts have been tested to ASTM E1509 for burning shelled corn in a mixture with wood pellets. The listing approves up to a 50% corn and 50% pellet mixture. Different mixtures of corn will have distinctively different burn characteristics depending upon moisture content and variety.
Page 36
XXV Pellet Stove Service Parts Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stocked parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer.
Page 37
XXV Pellet Stove Service Parts Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stocked parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer.
Page 38
XXV Pellet Stove Service Parts Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stocked parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer.
Page 39
XXV Pellet Stove Service Parts Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active #43 Feeder assembly 43.1 Pre Serial Number 12871 43.2 43.17 43.3 43.4 43.16 43.15 43.14 43.13 43.6 43.5 43.8 43.10 43.9 43.7 43.12 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stocked parts for your appliance please provide model number and serial number.
Page 40
XXV Pellet Stove Service Parts Beginning Manufacturing Date: N/A Ending Manufacturing Date: Active #44 Feeder Assembly Post Serial Number 12871 44.15 44.12 44.16 44.14 44.13 44.1 44.2 44.11 44.10 44.3 44.9 44.4 44.5 44.8 44.7 44.6 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stocked parts for your appliance please provide model number and serial number.
Page 41
Service & Maintenance Log Date Of Service Performed By Description Of Service XXV Pellet Stove 3-90-00684R22_04/13...
Page 42
Service & Maintenance Log Date Of Service Performed By Description Of Service 3-90-00684R22_04/13 XXV Pellet Stove...
Page 44
At Harman®, we build each product to a standard, not a price. This powerful heating appliance boasts uncompromising attention to detail and helps preserve our planet by using environmentally responsible fuels. (Signature of Boxer) Your premium quality hearth product designed and assembled by the experienced and skilled members at Harman®...