Table of Contents
Advertisement
Maintenance
Instructions
DECK LUBRICATION INSTRUCTIONS
The freedmill deck has been pre-lubricated at the factory. For optimal deck life and performance, the deck should
be checked periodically for lubrication. Keys recommends checking the deck every 30 days or 30 hours of
operation (See Diagram below). Lift the edge of the belt and feel the top of the deck, reaching as far to the center
as possible. If it feels slick, then no further lubricationis required. If it feels dry to the touch, lubricationis required.
Keys recommends NAPA 8300 silicone or Pyroil Silicone Lubricant, available at most auto parts and/or hardware
stores. Follow the directions hera for applying silicone:
TO APPLY LUBRICANT TO THE WALKING BOARD:
1)
Position the belt so that the seam is located on top and in the center of walking board.
2)
Insert the red spray extension tube (included with siliconespray) into siliconespray nozzle.
3)
Lift the edge of the belt and position the red extension tube approximately 6" from the front of the belt. Apply
silicone lubricant to the deck moving from the fi'ont towards the rear. Note: Spray time should not exceed 4
seconds. Repeat for the other side of the deck. WARNING!
DO NOT over lubricate the deck. Any excess
lubricant
should
be wiped off immediately.
Do not spray silicone lubricant inside the motor
compartmenL
4)
After application, allow the siliconeto penetrate for approximately one minute.
5)
To help spread the silicone, turn the treadmill on to 2 miles per hour and walk on ell surface areas. Lubrication
is complete!
CLEANING
Routine cleaning of your Keys treadmill will extend the life of your treadmill.
WARNING!
To prevent electrical
shock, be sure the power to the treadmill is OFF and the unit unplugged from the wall electrical outlet before
attempting any cleaning or maintenance.
AFTER EACH WORKOUT:
Wipe off the console and other treadmill surfaces with a clean, water dampened soft
cloth to remove excess perspiration. USE NO CHEMICALS.
WEEKLY:
Use of a treadmill mat is recommended for ease of cleaning. Dirt from your shoes contacts the belt and
eventually makes it to ur_demeeththe treadmill. Vacuum undemeeth treadmill once a week.
DO NOT CLEAN OR WIPE UNDERNEATH THE BELT!
;earn
Approx.
6"
12
Advertisement
Table of Contents
