Troubleshooting - Gravely Pro-Walk Hydro 36HR PS Owner's/Operator's Manual

Engine
Problem
Engine Will Not Start or Is Hard to
Start
Engine Will Not Slow Idle
Engine Runs Rough or Stalls
Engine Knocks
Engine Overheats
Engine Lacks Power

TROUBLESHOOTING

Probable Cause
Control levers not in the neutral position.
Neutral position switches not depressed fully.
Ignition switch not in proper position.
PTO engaged.
Fuel tank empty See FILLING FUEL TANK on page 16.
Stale fuel.
Plugged fuel filter.
Plugged air intake filter.
Spark plug wire is loose or disconnected.
Spark plug not gapped correctly.
Blown 20-amp fuse (main power circuit).
Electrical problem – discharged battery. (988154, 155,
157, 158, 159, 169)
Faulty relay or relay connection(s) (see page See Electric
Start (988154, 155, 157, 158, 159, 169) on page 18.).
Choke adjusted incorrectly. See servicing dealer.
Bent or kinked throttle cable.
Bent governor control.
Incorrect governor idle control.
Carburetor problems. See servicing dealer.
Plugged fuel filter.
Plugged air intake system.
Fuel cap vent dirty.
Stale or improper fuel/fuel level.
Spark plug not gapped correctly.
Replace spark plug.
Choke adjusted incorrectly. See servicing dealer.
Engine oil level low.
Reduce load. (Slower ground speed.)
Fuel is bad. Fill tank with fresh fuel, correct octane.
Idle speed too slow.
Clean cooling fins.
Low oil level.
Operating at slow idle – operate at full-throttle setting.
Cooling air intake screen is dirty.
Plugged air intake filter.
Operating at too fast ground speed for conditions.
Plugged air intake system.
Plugged fuel filter.
Improper type of fuel. Drain tank and fill with correct fuel.
Clean cooling fins to help prevent overheating.
Replace spark plug.
EN - 47