Safety Decals - MULTIQUIP WHISPERWATT Series Operation Manual

SAFETY DECALS

Safety decals are attached to the generator as shown in
Figure 1. Keep these safety decals clean at all times. When
the safety decals become worn or damaged, contact your
nearest dealer or the Multiquip Parts Department.
MOVING PARTS can cause
severe injury.
DO NOT operate with doors
open.
Stop engine before servicing.
FAN SHROUD
NOTES:
DCA400SSI4F ONLY.
1
2 DCA400SSI4F3 ONLY.
WARNING
DIESEL FUEL can cause
fire or explosion.
Stop engine before fueling.
Keep cigarettes, sparks
and flame away.
DANGER
Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide. This is
a poison gas you cannot see or smell.
Honda Engines POWERED by GAC-2.2H 120V 15A NEUTRE MIS A LA MASSE A LA CARCASSE DU MOTEUR 120 NEUTRAL BONDED TO FRAME V
GAC-2.2H 120V 15A 120 V NEUTRE MIS A LA MASSE A NEUTRAL BONDED TO FRAME LA CARCASSE DU MOTEUR GAC-2.2H 15A 120V NEUTRE MIS A LA MASSE A V 120 NEUTRAL BONDED TO FRAME GR PRISE DE 211052 TERRE COURANT PRINCIPAL AC CIRCUIT BREAKER INTERRUPTEUR DE
211052 POWERED by Honda Engines GR PRISE DE TERRE COURANT PRINCIPAL INTERRUPTEUR DE AC CIRCUIT BREAKER GR PRISE DE TERRE 211052 POWERED by Honda Engines LA CARCASSE DU MOTEUR AC CIRCUIT BREAKER INTERRUPTEUR DE COURANT PRINCIPAL
ONLY use OUTSIDE and
NEVER use inside a home
far away from windows,
or garage. Even if doors
doors, and vents.
and windows are open.
Avoid other generator hazards.
READ MANUAL BEFORE USE.
A90400001
WARNING
ENGINE EXHAUST can cause
severe injury or death.
Use only in open, well
ventilated areas or
vent exhaust outside.
B90420000
CAUTION
During urea SCR system purging, the smell of
ammonia may emanate from the tailpipe temporarily.
Do not operate the machine in a place with poor
ventilation.
If you begin to feel sick, stop the engine
immediately and ventilate the area.
C90420050
Operation of this equipment may create
sparks that can start fires around dry
vegetation.
A spark arrestor may be required.
The operator should contact local fire
agencies for laws or regulations
relating to fire prevention requirements.
M90420000
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
B93110060
PAGE 4 — DCA400SSI4F/DCA400SSI4F3 60 HZ GENERATOR • OPERATION MANUAL — REV. #3 (04/18/22)
WARNING
B90400040
REAR VIEW
2
B90450000
D
No Diesel
2
TIER 4F
FRONT VIEW
SAFETY INSTRUCTIONS
Improper operation of this machine can cause
severe injury or death.
Read the instruction manual carefully
before operation or servicing.
This machine should only be operated by a
person with sufficient knowledge and skill
to ensure safe operation.
High voltage circuits are located inside the
output terminal cover and control panel.
Close the cover and control panel before
operating.
Moving parts and hot surfaces are contained
within the enclosure.
Close all doors and lock them before
operating.
C25100000
WARNING
ARC FLASH AND SHOCK HAZARD
Appropriate PPE Required
Appropriate Personal Protection
Equipment and Tools Required
when working on this equipment.
M92010070
Figure 1. Safety Decals
NOTICE
For safety decal part numbers, refer to the associated
parts manual.
1
TOP VIEW
1
WARNING
HOT COOLANT can cause
severe burns.
Do not remove cap if
radiator is hot.
B90410010
SIDE VIEW
CAUTION
EXHAUST FLUID ONLY
Filling this tank with
anything other than
DIESEL EXHAUST FLUID
may result in severe
engine damage.
M94110000
CAUTION
This machine stops and starts automatically
and without notice.
C92210000
400
WARNING
ELECTRIC SHOCK HAZARD
Do not touch output
terminals while this
machine is operating.
Turn power off before
servicing.
B93110050
SAFETY DECALS
CAUTION CAUTION
Maximum Capacity of lifting Maximum Capacity of lifting
bail is 18,000 lbs. bail is 21,000 lbs.
C90400030
CAUTION
Ensure the "Auto-Off/Reset-Manual" switch is
in the "Off/Reset" position. If it is not, when
the battery cables are connected, the engine
will crank and attempt to start.
M90530000
2
CAUTION
HOT PARTS can burn skin.
DO NOT touch until the
machine has sufficiently
cooled.
B90400030
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
B93110060
SIDE VIEW
2
WARNING
WARNING
ELECTRIC SHOCK HAZARD Before connecting this generator to any building's
Always complete the grounding electrical system, a licensed electrician must install
path from the ground terminal
an isolation (transfer) switch.
on the genset to an external
grounding source.
Serious injury or death may result without this
See instruction manual for
transfer switch.
details.
B91110040
2
C90400060
CAUTION
This machine stops and starts automatically
and without notice.
C92210000
400
WARNING
HOT COOLANT can cause
severe burns.
Do not remove cap if
radiator is hot.
B90410010
B91110030