Yamaha F15B Service Manual page 176

Index
A.
Adjusting the pilot screw ...........................4-10
Adjusting the throttle cable..........................3-8
Adjusting the throttle link rod ....................4-10
Aft view........................................................8-5
After test run ...............................................1-9
Applicable model.........................................1-5
Assembling the carburetor ..........................4-9
Assembling the cylinder block...................5-47
Assembling the fuel pump.........................4-13
Assembling the lower case .......................6-17
Assembling the manual starter .................5-13
Assembling the piston and connecting rod
assemblies ..............................................5-45
Assembling the propeller shaft
assembly .................................................6-12
Assembling the propeller shaft
housing....................................................6-12
Assembling the upper case.......................7-14
B.
Backlash....................................................6-26
Bottom cowling............................................7-4
Bracket ......................................................3-11
Break-in .......................................................1-9
C.
Carburetor ...................................................4-5
Changing the engine oil ..............................3-3
Charging system .......................................8-12
Checking the CDI unit ...............................8-10
Checking the anode ..................................3-13
Checking the bearing housing ..................6-16
Checking the bearings ..............................6-17
Checking the camshaft .............................5-30
Checking the carburetor..............................4-8
Checking the charge coil.............................8-9
Checking the compression pressure...........5-3
Checking the connecting rod
big end side clearance ............................5-41
Checking the connecting rod
small end inside diameter .......................5-41
Checking the cooling water passages ........3-7
Checking the cooling water pilot hole .........1-8
Checking the crankshaft ...........................5-42
Checking the crankshaft main journal oil
clearance.................................................5-43
Checking the crankshaft pin
oil clearance ............................................5-42
Checking the cylinder bore .......................5-39
Checking the cylinder head.......................5-31
Checking the diaphragm and valves.........4-13
Checking the drive shaft ...........................6-17
i-1
Checking the electrical components ...........8-2
Checking the engine idle speed................3-10
Checking the engine oil...............................3-3
Checking the engine oil level ......................1-6
Checking the engine stop
lanyard switch ...........................................1-8
Checking the engine stop
lanyard switch..........................................8-11
Checking the fuel filter ................................3-3
Checking the fuel filter ................................4-4
Checking the fuel joint.................................4-4
Checking the fuel line..................................3-3
Checking the fuel pump ............................4-12
Checking the fuel system............................1-6
Checking the gear oil ..................................1-6
Checking the gear oil level........................3-12
Checking the gearshift and
throttle operation .......................................1-7
Checking the gearshift operation ................3-9
Checking the ignition coil ............................8-8
Checking the ignition spark gap..................8-7
Checking the ignition timing ......................3-11
Checking the lighting coil ..........................8-12
Checking the lower case...........................6-17
Checking the lower unit for air leakage ....3-13
Checking the oil pressure ...........................5-3
Checking the oil pressure switch ................5-4
Checking the oil pressure
warning lamp...........................................8-10
Checking the oil pump ..............................5-31
Checking the outboard motor
mounting height.........................................1-6
Checking the pinion gear and
forward gear ............................................6-16
Checking the piston clearance..................5-39
Checking the piston diameter ...................5-38
Checking the piston pin.............................5-41
Checking the piston pin boss bore............5-41
Checking the piston ring grooves .............5-40
Checking the piston ring
side clearance .........................................5-40
Checking the piston rings..........................5-39
Checking the propeller ..............................3-13
Checking the propeller shaft .....................6-11
Checking the propeller shaft housing........6-11
Checking the pulser coil..............................8-8
Checking the rectifier regulator .................8-12
Checking the remote control cables ...........1-7
Checking the rocker arms and
rocker arm shaft ......................................5-29
Checking the shift rod ...............................6-17
Checking the spark plug caps.....................8-7
Checking the spark plugs............................3-6
Checking the spiral spring.........................5-12
6D45F11