Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Jenn-Air 720-0063-LP
Summary of Contents for Jenn-Air 720-0063-LP
- Page 1 STAINLESS STEEL GAS GRILL MODEL NO.: 720-0063-LP Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SECTION ONE Safety Instructions…………………………. Placement of the grill……………………….. SECTION TWO Side Shelf Assembly……………………….. Side Shelf Handle & Grease Tray Handle Assembly……………………………………. Battery & Spice Tray, Individual Shelf Assembly……………………………………. Propane Tank Assembly…………………… SECTION THREE Gas Hook Up……………………………….. Leak Testing………………………………… Installer Final Check………………………. - Page 3 SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion air flow or trap excessive heat in the control area.
- Page 4 SAFETY INSTRUCTIONS WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. WARNING: Always keep your face and body as far away from the burner as possible when lighting.
-
Page 5: Safety Instructions
SAFETY INSTRUCTIONS If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. - Page 6 SIDE SHELF ASSEMBLY • The screws used to attach the side shelf are already screwed into the right side panel (see the figure below). Remove the screws from the right side panel, align with the holes in the side shelf, and then re-screw into the holes on the right side panel of the grill. •...
-
Page 7: Placement Of The Grill
DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL. The 720-0063-LP Grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty. -
Page 8: Side Shelf Assembly
SIDE SHELF ASSEMBLY • The screws used to attach the side shelf are already screwed into the two-side panel (see the figure below). Remove the screws from the two-side panel, align with the holes in the side shelf, and then re-screw into the holes on the side panels of the grill. •... -
Page 9: Side Shelf Handle & Grease Tray Handle Assembly
SIDE SHELF HANDLE & GREASE TRAY HANDLE ASSEMBLY • T h e t w o s c r e w s u s e d a t t a c h t h e g r e a s e t r a y h a n d l e a r e... -
Page 10: Battery & Spice Tray, Individual Shelf Assembly
BATTERY & SPICE TRAY, INDIVIDUAL SHELF ASSEMBLY • In order to install the battery, remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. •... -
Page 11: Propane Tank Assembly
PROPANE TANK ASSEMBLY ● Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below. -
Page 12: Gas Hook Up
This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill has been pre-configured for natural gas use. Total gas consumption (per hour) of 720-0063-LP grill with all burners on “HI”: Main burners 60,000 Btu/hr. -
Page 13: Leak Testing
GENERAL Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. -
Page 14: Installer Final Check
INSTALLER FINAL CHECK Specified clearance maintained 24” from combustibles. All internal packaging removed. Knobs turn freely. Burners are tight and sitting properly on orifices. Pressure regulator connected and set for 11.2” W.C. LP gas. Gas connections to grill using hose & regulator assembly provided (pre-set for 11.0”... -
Page 15: Operating Instruction
OPERATING INSTRUCTION General use of the grill and rotisserie Each main burner is rated at 12,000 BTU/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiant (flame tamers). -
Page 16: Lighting Instructions
LIGHTING INSTRUCTIONS WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose assembly supplied with the unit should be used. -
Page 17: To Match Light The Grill
TO MATCH LIGHT THE GRILL TO MATCH LIGHT THE GRILL: If the burner will not light after several attempts then the burner can be match lit. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. -
Page 18: Lighting Illustration
LIGHTING ILLUSTRATION Main & Side Burner Lighting Illustration 1. Make sure the lid is in open position. 2. Push and turn one of main or side burner knob to HI position. 3. You may need 3 or 4 trials to light the burner. After the burner is lit, adjust the knob as desired. -
Page 19: Using The Side Burner
USING THE SIDE BURNER WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. -
Page 20: Care And Maintenance Of Side Burner
CARE & MAINTENANCE OF SIDE BURNER SIDE BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available. -
Page 23: Grilling Hints
GRILLING HINTS The doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the temperature of the meat when cooking begins, and the degree of... - Page 24 FOOD WEIGHT OR THICKNESS MEATS BEEF Hamburgers 1/2 to 3/4 inch Tenderloin, Porterhouse, Rib eye Rare 1 inch Medium 1-1/2 inch 1 inch 1-1/2 inch Well-done 1 inch 1-1/2 inches Lamb Chops & Steaks Rare 1 inch 1-1/2 inch Medium 1 inch 1-1/2 inch Well-done...
- Page 25 FOOD WEIGHT OR THICKNESS Breasts well-done FISH AND SEAFOOD Steaks Halibut 3/4 to 1 inch Salmon Swordfish Whole Catfish 4 to 8 ounces Rainbow trout FLAME APPROXIMATE SIZE TIME Medium 30 to 45 minutes Marinate with Italian dressing Grill, turning once. Brush with melted butter, margarine or oil to keep moist.
-
Page 26: Grill Recipe Suggestions
GRILL RECIPE SUGGESTIONS SALMON 2 large salmon steaks 2 tbs. oil Salt & pepper 2 oz. thin bacon slices 2 tbs. butter 1 tbs. lemon juice Sprig of parsley Lemon wedges Note: Substitute catfish, halibut or cod for salmon. Preheat the BBQ Brush the steaks with oil and season with salt and pepper. - Page 27 Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a pre-heated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill. Slice meat across grain in thin slices.
-
Page 28: Limited Warranty
MODEL 720-0063-LP STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Jenn-Air Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below.