Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Jenn-Air 720-0061-LP
Summary of Contents for Jenn-Air 720-0061-LP
- Page 1 STAINLESS STEEL GAS GRILL MODEL NO.: 720-0061-LP Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions………………………….. Exploded View……………………….….. Placement of the grill……………………….. Parts List ………………………………… SECTION TWO SECTION SIX Side Burner & Side Shelf Assembly………. Grilling Hints …………………………….. Side Burner Handle Assembly…………….. Grill Cooking Chart ……………………… 22-24 Battery Assembly……………………………... -
Page 3: Safety Instructions
PRECAUTIONS SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injuray or death. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. - Page 4 PRECAUTIONS SAFETY INSTRUCTIONS WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present.
-
Page 5: Safety Instructions
SAFETY INSTRUCTIONS WARNING *** FOR YOUR SAFTY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1. - Page 6 PRECAUTIONS SAFETY INSTRUCTIONS WARNING Do not try lighting this appliance without first reading CHILDREN SHOULD NOT BE LEFT ALONE OR the “LIGHTING INSTRUCTIONS” section of this UNATTENDED IN AN AREA WHERE THE GRILL manual. IS BEING USED. NEVER ALLOW THEM TO SIT, STAND OR PLAY ON OR AROUND THE GRILL AT TESTED IN ACCORDANCE WITH ANSI Z21.58b- ANY TIME.
-
Page 7: Placement Of The Grill
THE GRILL. them periodically for optimum performance. The burners will only operate in one position and must The 720-0061-LP Grill is designed for optimum be mounted correctly for safe operation. performance without the use of briquettes. Do not place briquettes on the radiant as this will block off Clean the grill with caution. -
Page 8: Side Burner & Side Shelf Assembly
SIDE SHELF & SIDE BURNER ASSEMBLY INSTALLATION OF • The screws used to attach the side shelf and side burner are already screwed into the two- side panels (see the figure below). Remove the screws from the two-side panel, align with the holes in the left side shelf, and then re-screw into the holes on the left side panel of the grill. -
Page 9: Side Burner Handle Assembly
SIDE BURNER HANDLE ASSEMBLY • To assemble the side burner lid handle, open the lid first, cut off the plastic tie tied in the screw hole. Install the handle in the lid as shown in figure below. • Take four of the side burner handle screws from hardware bag. Align the side burner hole in the side shelf, and tighten up the screws (see figure below). -
Page 10: Battery Assembly
BATTERY ASSEMBLY • In order to install the battery, remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. -
Page 11: Side Burner Gas Hose Assembly
SIDE BURNER GAS HOSE ASSEMBLY • The side burner PVC gas hose is attached on the valve manifold inside the grill cart. Insert the gas hose to the hole on right panel of the grill. Secure it on the gas hose connector under the side burner as shown in figure below. -
Page 12: Propane Tank Assembly
PROPANE TANK ASSEMBLY • Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below. -
Page 13: Gas Hook Up
It is also equipped use. with a high capacity hose/regulator assembly for connection to a standard 20lb. LP cylinder (18-1/4” Total gas consumption (per hour) of 720-0061-LP high, 12-1/4” diameter). grill with all burners on “HI”: To connect the L.P. gas supply cylinder: Main burners 45,000 Btu/hr. -
Page 14: Leak Testing
LEAK TESTING GENERAL local gas supply may make it necessary to adjust Although all gas connections on the grill are leak the burners. The flames of the burners should be tested at the factory prior to shipment, a complete visually checked. gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being... -
Page 15: Installer Final Check
INSTALLER FINAL CHECK Specified clearance maintained 24” from hose & regulator assembly provided (pre-set for combustibles. 11.0” water column). All internal packaging removed. Unit tested and free of leaks. Knobs turn freely. User informed of gas supply shut off valve Burners are tight and sitting properly on orifices. -
Page 16: Operating Instructions
OPERATING INSTRUCTIONS General use of the grill and rotisserie Each main burner is rated at 15,000 BTU/hr. The the stainless steel motor mount. The rotisserie main grill burners encompass the entire cooking motor must be electrically grounded in accordance area and are side ported to minimize blockage from with local codes or, in the absence of local codes, falling grease and debris. -
Page 17: Lighting Instructions
LIGHTING INSTRUCTIONS variations in the local gas supply may take minor WARNING: IMPORTANT! adjustments necessary. BEFORE LIGHTING… Burner flames should be blue and stable with no Inspect the gas supply hose prior to turning the gas yellow tips, excessive noise, or lifting. If any of “ON”. -
Page 18: To Match Light The Grill
TO MATCH LIGHT THE GRILL TO MATCH LIGHT THE GRILL: If the burner will not light after several attempts then the burner can be match lit. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. -
Page 19: Lighting Illustration
LIGHTING ILLUSTRATION Main & Side Burner Lighting Illustration Rotisserie Burner Lighting Illustration 1. Make sure the lid is open 1. Push and turn the rotisserie knob to HI. 2. Push and turn one of main or side burner knobs 2. Press the electric igniter 3 to 4 seconds to to HI position light the rotisserie burner 3. -
Page 20: Using The Side Burner
USING THE SIDE BURNER control knob counterclockwise to the “HI” position. If the burner does not light, turn the control knob to WARNING: IMPORTANT! “OFF”. If the smell of gas is detected and the igniter USING THE SIDE BURNER: is not functioning, immediately turn the control knob Inspect the gas supply hose prior to turning the gas “OFF”. -
Page 21: Care And Maintenance Of Side Burner
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available. -
Page 22: Exploded View
EXPLODED VIEW... -
Page 23: Parts List
MODEL720-0061-LP PARTS LIST REF# DESCRIPTION REF# DESCRIPTION Lid, Front 3” Caster Heat Indicator Slide Assembly Name Plate Door Handle Heat Insulating spacer Front Door Handle Assembly, Lid Side Panel, Cart Infrared Burner Slide Bracket Gas Collector 3” Caster With Brake Inner Lid Side Panel, Cart Bowl Assembly... -
Page 24: Grilling Hints
GRILLING HINTS The doneness of meat, whether rare, medium, or Use a spatula instead of tongs or a fork to turn the well done, is affected to a large degree by the meat, as a spatula will not puncture the meat and thickness of the cut. - Page 25 FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended since a flare-up could occur quickly.
- Page 26 FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS Breasts Medium 30 to 45 minutes Marinate with Italian dressing well-done FISH AND Grill, turning once. Brush with SEAFOOD melted butter, margarine or oil to keep moist. Steaks Halibut 3/4 to 1 inch Medium to...
-
Page 27: Grill Recipe Suggestions
GRILL RECIPE SUGGESTIONS In medium bowl, combine shrimp and aluminum foil. Bake covered 25 SALMON scallops. In small bowl combine chili minutes on medium with the lid of sauce and next six ingredients. Pour your BBQ grill closed. Remove foil 2 large salmon steaks over seafood. - Page 28 ½ tsp. pepper Heat through. If sauce gets too thick, Marinade ribs for 3 hours. Use ¼ tsp. oregano add 1 tbs. water. Serve sauce with marinade for basting by adding beer ¼ tsp. cumin kabobs. to it. Place pan under the ribs and Flour tortillas baste frequently.
-
Page 29: Limited Warranty
MODEL 720-0061-LP STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Jenn-Air Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below.