Preventative Maintenance - Jackson DISHSTAR Series Installation, Operation And Service Manual

MAINTENANCE
PREVENTATIVE
MAINTENANCE
i
!
CAUTION
CAUTION! Do NOT beat
strainers to remove
soil and debris!
07610-004-99-71-B

PREVENTATIVE MAINTENANCE

The manufacturer highly recommends that any maintenance and repairs not specifically
discussed in this manual only be performed by qualified service personnel.
Performing maintenance on the machine may void a warranty.
By following the operating and cleaning instructions in this manual, users should get
the most efficient results from the machine. As a reminder, here are some steps to
ensure the machine is used properly:
1. Ensure water temperatures match those listed on the machine data plate (on
front-left of machine).
SERIAL NO.:
MODEL: DISHSTAR ADA-SEER
WASH MOTOR WASH HEATER 3.3 KW 3/4 HP
RINSE HEATER 4.1 KW
TOTAL LOAD
NOTE: WASH AND RINSE HEATER DO NOT OPERATE
4000897 AT THE SAME TIME. TOTAL LOAD BASED ON HIGHER LOAD.
Conforms to NSF Std 3 OPERATING PARAMETERS
MINIMUM WASH TEMP
MINIMUM RINSE TEMP
MIN/MAX INCOMING WATER TEMP
4000897 Intertek RINSE CYCLE TIME WASH CYCLE TIME
Conforms to UL Std 921 Conforms to CSA Std C22.2 No.168 WATER FLOW PRESSURE
CAUTION: IF THIS MACHINE IS CONNECTED TO A CIRCUIT PROTECTED BY FUSES,
USE ONLY 30 A (208 V)/35 A (230 V) TIME-DELAY FUSE OR OVERCURRENT PROTECTION.
ATTENSION: SE CONNECTER A UN MINIMUM D'ALIMENTATION 30 AMPERES (208 V)/35 AMPERES
(230 V) DELAI FUSIBLE DE TYPE TEMPS OU LA PROTECTION CONTRE LES SURINTENSITES.
MINIMUM CIRCUIT AMPACITY @208 VOLTS: 27.9 AMPS
@230 VOLTS: 30.0 AMPS
MAXIMUM OVERCURRENT PROTECTION @208 VOLTS: 30 AMPS
@230 VOLTS: 35 AMPS
2. Remove as much soil as possible from ware before loading into racks.
3. Ensure strainers are in place, laying flat in the tub, and free of soil and debris
before operating the machine. To clean strainers, wipe out with a rag and rinse
under a faucet. For stubborn debris, a toothpick can be used. Do not beat
strainers on waste cans; once bent, they will not work properly.
4. Ensure all wash and rinse arms are secure in the machine before operating.
XXXXXXXXX
60Hz 1 PH 2 WIRE
208 VOLT 230 VOLT
15.7 A 6.6 A 4 KW 3/4 HP 6.6 A 17.4 A
19.7 A 5 KW 21.8 A
26.3 A 28.4 A
155°F
180°F
40-90°F
9 SEC 80 SEC
10 PSI
Jackson WWS, Inc Made in the USA
6209 N US HWY 25E
Gray, KY 40734
09905-004-99-60-A (606) 523-9795
17