Page 1
Date Purchased: _____________________ Installation & Operation Manual Self-Generating Steam Jacketed Counter Tilting Kettles EC-6TW, EC-10TW and EC-12TW Model EC-6TW WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment.
Self-Generating Steam Jacketed Counter Tilting Kettles Table of Contents RETAIN THIS MANUAL FOR FUTURE REFERENCE. Table of Contents Important Notes For Installation and Operation ..............2 Service Connections ......................4 Introduction ........................... 5 Installation ..........................6 Operation ..........................7 Cleaning ..........................8 Troubleshooting ........................
12.0 33.3 31.5 28.9 18.3 16.7 14.5 11.5 [86 kg] (76 mm) (51 mm) As continued product improvement is a policy of Crown, specifications are subject to changge without notice. PAGE OF 20 INSTALLATION & OPERATION MANUAL 10121 REV 0 (04/21)
Introduction Description Models EC-6TW (6 gallon capacity) and EC-10TW (10 gallon capacity) and EC-12TW (12 gallon capacity) electrically powered, self-contained, countertop, tilting kettles. Each model has a jacket of double-wall construction forming a sealed reservoir around the lower two-thirds of the kettle. The reservoir is charged with distilled water. Kettles are equipped with a removable electric heating element and controls, including a low water cutoff device for protection of the heating element.
Self-Generating Steam Jacketed Counter Tilting Kettles NSTALLATION Installation NPACKING IMMEDIATELY INSPECT FOR SHIPPING DAMAGE Immediately after unpacking the steamer, check for possible shipping damage. If the steamer is found to be damaged, save the packaging material and contact the carrier within 15 days of delivery. Installation Instructions Immediately after unpacking, check for possible shipping damage.
Self-Generating Steam Jacketed Counter Tilting Kettles PERATION Operation Tilting Instructions Your kettle has the standard “Clean Lock” feature and may not be tilted without disengaging the tilt knob located on the console at the top right. This feature locks the kettle in the upright position and also allows the operator to lock the kettle at 105 degrees for ease of cleaning.
Cleaning Self-Generating Steam Jacketed Counter Tilting Kettles Cleaning The kettle interior and exterior should be thoroughly washed after each use in preparation of a different food. 1. Add water and mild detergent to the kettle immediately after use. 2. Scrub kettle interior with nylon brush. NOTICE Never scrape the inside of the kettle with metal tools, steel scouring pads, or abrasive cleaners.
1. Trip the safety relief valve lever to relieve all pressure from the kettle jacket. 2. At exterior rear of kettle jacket remove nut from Air Vent. 3. Insert funnel into Air Vent opening and slowly add the indicated amount of distilled water for: EC-6TW Add 50 oz. (1.5 litres) EC-10TW and EC-12TW Add 100 oz.
Page 20
STEAM JACKETED COUNTER TILTING KETTLES A product with the Crown name incorporates the best in durability and low maintenance. We all recognize, however, that replacement parts and occasional professional service may be necessary to extend the useful life of this appliance.