Follett Horizon Chewblet 1000 Series Manual page 6

Horizon
Chewblet ice icemaker
Front View
Evaporator utility requirements/unit specifications
Models HCD1000
Shipping weight 180 lbs (68 kg)
Standard electrical
Voltage 115
Phase 1-phase
Hertz 60 cycles
Amps 6 (max.)
Circuit 15 Amps
Cord 7 ft (2 m)
Plug NEMA 5-15
Evaporator unit operating limits
All models
Air temperature 50 F (10 C)
Water temperature 45 F (7 C)
Potable water pressure 10 psi (69 kpa)
Energy & water consumption*
Models HCD1000
Electricity per 100 lbs 5.1 kWh
(46 kg) of Ice
Water per 100 lbs 13.6 gal (52 L) 13.2 gal (50 L)
(46 kg) of ice
* 90 F (32 C) air temp & 70 F (21 C) water temp
6
Form# 3815
Side View
21.28" (54 cm)
23.50"
(60 cm)
21.05" (54 cm)
1000 Series –
22.8" (58 cm)
1400 & 1800 Series –
23.77" (60 cm)
HCD1400/HCD1800
190 lbs (86 kg)
115
1-phase
60 cycles
6 (max.)
15 Amps
7 ft (2 m)
NEMA 5-15
Minimum Maximum
100 F (38 C)
90 F (32 C)
70 psi (483 kpa)
HCD1400 HCD1800
4.8 kWh 4.8 kWh
13.2 gal (50 L)
KaTom Restaurant Supply, Inc.
1000 series, 1400 series or 1800 series
with remote air-cooled condensing unit
Evaporator utility requirements/unit specifications
Ice transport hose connection
L2
G
NEMA 5-15
L1
right angle
6.95"
(18 cm)
1.75" (45 mm)
3/8" OD push-in
min. req'd
water inlet
3/4" MPT drain
Important specification/installation notes:
1. 10 ft (3 m) of ice transport tube and insulation are provided
with Satellite-fill models only. Longer tubes available as an
accessory, at extra cost.
2. In Satellite-fill applications, ice enters through top of ice
storage bin or countertop ice and beverage dispenser. For side
entry, contact factory.
3. Separate icemaker and condensing unit drain lines required for
water-cooled models.
4. Drains should be hard piped and insulated. Maintain at least a
¼" per foot (2 cm per meter) slope away from icemaker.
5. Follett recommends installation of an in-line water filtration
system. See available accessories on page 1.
Follett Corporation
801 Church Lane • Easton, PA 18040, USA
+1 (610) 252-7301 • Fax +1 (610) 250-0696
www.follettice.com
Back View
19.3" (49 cm)
2.53"
(65 mm)
2.5" (64 mm)
15.69" (40 cm)
Follett Europe Polska
Mokry Dwór 26C • 83-021 Wislina, Poland
+48 (58) 785-6140 • Fax +48 (58) 785-6159
www.folletteurope.com
5/8" suction line
for HCD1000 and
HCD1400
7/8" suction line
for HCD1800
3/8" liquid line
2.87
(73 mm)
1.81
(46 mm)