Table Of Contents - Montigo DelRay Square Series Installation & Maintenance Manual

Indoor direct vent gas fireplace
Table of Contents

Advertisement

This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. A conversion kit is
supplied with the appliance.
Contents
Safety Alert Key .................................................................................. 2
Introduction ....................................................................................... 2
Efficiency ............................................................................................. 2
Section A: Before You Begin .......................................................................4
Installation Checklist ......................................................................................4
Standard Installation Checklist ....................................................................5
Rating Plate Sample .......................................................................................6
Section 1: Dimensions ....................................................................... 7
DelRay Square Dimensions ..........................................................................7
Section 2: Framing ............................................................................ 8
In Wall and Corner Dimensions ..................................................................8
Rear vent, rigid or flex ...................................................................................8
Top vent, flex ...................................................................................................8
Top vent, rigid ..................................................................................................8
Clearances ........................................................................................................9
Section 3: Venting .............................................................................. 9
Restrictor plate ..............................................................................................10
Primary air adjustment ...............................................................................10
Section 3-3-1: Venting Layout ......................................................... 11
DRSQ38 5/8 TOP Venting - .........................................................................11
Wall and roof termination ..........................................................................11
DRSQ38 4/7 TOP Venting - .........................................................................11
Wall and roof termination ..........................................................................11
DRSQ38 Rear Venting ..................................................................................12
45° Corner Installation 5''/8'' .....................................................................12
45° or less Corner Installation 5''/8'' ........................................................12
............................................................................................................ 13
Section 3-2-1: Venting Layout ...................................................................13
Section 3-1: Converting top/rear vent ....................................................15
DRSQ38 units) ...............................................................................................17
Section 3-3-3: Heat Shields .............................................................. 18
Section 4: Wiring .............................................................................. 19
DRSQ (N/L) I Wiring Diagram .....................................................................19
Installation of the wall switch .....................................................................19
DRSQ (N/L) I-2 Wiring Diagram .................................................................20
Installation of Electrical Supply .................................................................20
Section 5: Installing the gas line..................................................... 21
Fuel Type .........................................................................................................21
XG0230 - 052020
Gas Pressure .................................................................................................21
Section 5-3: GAS CONNECTION ................................................................21
Finishing Safety Zone ...................................................................................21
Section 6: Finishing .......................................................................... 22
Finishing Around the Fireplace .................................................................22
Sidewall clearances ......................................................................................22
Cement Board Install ...................................................................................22
Elevated surface temperatures ...............................................................23
Standard installation ....................................................................................23
Venting ports open w/ vented chase .......................................................23
Heat distribution kit installed ....................................................................23
Removing the Screen...................................................................................24
Reinstalling the Screen ................................................................................24
Removing the door ......................................................................................24
Reinstalling the door ....................................................................................24
Propane Conversion ........................................................................ 25
Section 9: Installing the Accessories .............................................. 27
The DelRay Square transitional burner ...................................................27
Installing glass media ...................................................................................27
Installing the speckled stone media ........................................................27
Traditional Logset Installation ...................................................................28
Birch Logset Installation..............................................................................30
Driftwood Logset Installation.....................................................................31
Black Reflective Glass ..................................................................................32
Brick Liner Install ..........................................................................................33
Section 10: Cleaning and Maintenance ........................................ 35
General............................................................................................................35
Cleaning ..........................................................................................................35
Pilot Burner Adjustment. ............................................................................35
See through fireplace ..................................................................................36
Notes ...............................................................................................................36
Single sided fireplace ...................................................................................36
Appendix A: Venting Terminations ................................................ 37
Appendix B: Warranty ..................................................................... 38
Appendix B: Warranty Continued .................................................. 39
Appendix C: Amendment ................................................................ 40
General
3

Hide quick links:

Advertisement

Table of Contents
loading

This manual is also suitable for:

Drsq38niDrsq38ni-2Drsq38liDrsq38li-2Drsqc38niDrsqc38ni-2 ... Show all

Table of Contents