Page 1
OPERATION MANUAL SERIES MODEL LD6 RIDE-ON POWER TROWEL (B&S VANGUARD 23 HP GASOLINE ENGINE) Revision #0 (02/10/20) To find the latest revision of this publication or associated parts manual, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Pressurized fluid hazards Addresses practices not related to personal injury. Hydraulic fluid hazards LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 7...
Page 8
Fire, Smoking, Explosion, Inhalation Hazard DO NOT smoke or light matches near this equipment. This equipment contains highly flammable fuel. DO NOT use this equipment in an enclosed area. PAGE 8 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 9
No one other than the operator is to be in the working area when the equipment is in operation. NEVER use the equipment for any purpose other than its intended purposes or applications. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 9...
Page 10
NEVER place your feet or hands inside the guard rings while starting or operating this equipment. PAGE 10 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 11
The battery contains combustible gases and liquids. If these gases and liquids come into contact with a fl ame or spark, an explosion could occur. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 11...
Page 12
Recyclers and manufacturers alike promote the process of recycling metal. Using a metal recycling center promotes energy cost savings. PAGE 12 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
The label must remain with the engine for its entire life. If a replacement emission label is needed, please contact your authorized engine distributor. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 13...
DO NOT lift the trowel to unnecessary heights. ALWAYS shut down the engine before transporting. Tighten the fuel tank cap securely and close the fuel cock to prevent fuel from spilling. PAGE 14 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 15
Broken or worn stitching that exposes the core fibers Knots Any other condition which may cause doubt as to the strength of the sling LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 15...
Page 16
Figure 2. Lifting the Trowel 2. Insert forklift forks through the loops at the ends of the lifting slings. Keep the slings as close to vertical as possible. PAGE 16 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Figure 5. DO NOT wrap the tie-downs around the frame as shown in Figure 6. NOTICE Use tie-downs with flat hooks or U-hooks only. CORRECT Figure 5. Tie-Down Method (Correct) LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 17...
SA(8). The daily exposure limit value is Per EU Directive 2002/44/EC, the daily exposure action value for whole body vibration is 0.5 m/s SA(8). 1.15 m/s PAGE 18 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
The LD6 is equipped with a Briggs & Stratton Vanguard 3864 gasoline engine. Refer to the engine owner’s manual for specific instructions regarding engine operation and maintenance. PAGE 20 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Holds up to 3 gallons (11.4 liters) button controls the flow of retardant spray when the of retardant. optional retardant spray kit is installed. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 21...
Page 22
26. Light, Right Side (Optional) — One of six LED lights 20. Tie-Down Locations (4) — Secure tie-down straps to included with the optional light kit. these attachment points when transporting the trowel. PAGE 22 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
32. Carbon Canister — A container filled with activated charcoal traps gasoline vapor emitted by the fuel system and releases it to the engine. Reduces emissions and increases fuel efficiency. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 23...
8. Muffler Mounting Bracket — Secures the muffler to the hydraulic pump valve. the trowel frame. 9. Air Cleaner — Prevents dirt and debris from entering the engine cylinders. PAGE 24 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
3. Connect the positive (RED) battery cable to the into operation. positive (+) terminal on the battery, then connect the negative (BLACK) battery cable to the negative (–) terminal. See Figure 13. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 25...
Figure 17. Hydraulic Oil Level Inspection NEVER overfill the oil pan. ALWAYS allow time for any added oil to make its way to the oil pan before rechecking the level. PAGE 26 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 27
3. If fuel is low, remove the fuel filler cap (Figure 18) and fill the tank with unleaded 87 or 89 octane gasoline. DO NOT overfill. The fuel tank holds 4 gallons (15 liters) of gasoline. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 27...
DO NOT grab the steering control joysticks to lift yourself onto the trowel. Damage to the joysticks may result. P/N 45650 ENGINE THROTTLE LEVER (IDLE) Figure 20. Engine Throttle Lever (Idle) PAGE 28 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 29
6. Place the engine throttle lever in the FAST (rabbit) position. See Figure 22. ENGINE THROTTLE LEVER (FAST) P/N 45650 Figure 22. Engine Throttle Lever (Fast) LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 29...
Page 30
Table 7 illustrates the various directional positions of the joysticks and their effect on the movement of the trowel. NOTICE All directional references with respect to the joysticks are from the operator’s seated position. PAGE 30 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 31
(Figure 25) with your right foot to begin rotating the blades. 2. Move the rotor speed control lever to about midway between high speed (rabbit) and low speed (turtle). LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 31...
8. Pull both the left and right joysticks backward (Figure 28) and repeat steps 3–4 while substituting the word reverse for forward. Figure 28. Joysticks (Reverse) PAGE 32 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Note 2 = Clean more often under dusty conditions or when airborne debris is present. Replace the air cleaner if very dirty. Note 3 = Use Parker DuraClean ISO 46 hydraulic oil only. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 33...
Page 34
8. Replace the air cleaner cover and secure with the KNOB latches. PLATE FOAM PRE-CLEANER CARTRIDGE BODY Figure 29. Air Filter Components 2. Remove the knob and the plate (Figure 29). PAGE 34 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 35
3. Fully insert the dipstick then remove it again. 4. Determine if engine oil is low. Oil should be between the upper and lower marks (Figure 32) on the dipstick. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 35...
Page 36
OIL FILTER WRENCH Figure 35. Oil Filter Removal 7. Clean the sealing surface where the filter mounts onto the engine. PAGE 36 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 37
NOTICE NEVER attempt to charge a battery that is frozen. The battery can explode unless first allowed to thaw. Figure 38. Hydraulic Oil Filter LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 37...
Page 38
5 ft. × 5 ft. (1.5 m × 1.5 m), 3/4 inch-thick, flat steel plate should be used. 3. Lubricate the Zerk grease fitting with 1–1½ shots of multipurpose grade grease. Replace the Zerk grease fitting cap when finished. PAGE 38 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 39
A slight tap with a rubber mallet may be SURFACE necessary to dislodge the spider from the hydraulic DISHED EFFECT ON motor shaft. FINISHED CONCRETE Figure 43. Incorrect Spider Plate Alignment LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 39...
Page 40
4. Install the new blades, maintaining the proper blade orientation as noted during removal. Secure with the bolts that were removed earlier. PAGE 40 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 41
3. Adjust the fixture adjustment bolt distance shown in Figure 48 to 0.15 in. (3.81 mm). 4. Replace the trowel arm if it is bent or uneven. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 41...
Page 42
3. The remainder can be brought to a salvage yard or 3. Reinstall the bronze bushings onto the trowel arm. metal reclamation facility for further dismantling. 4. Repeat steps 2–3 for each trowel arm. PAGE 42 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Check to ensure that each blade is adjusted to have the Blade pitch? same pitch as all other blades. Adjust per Maintenance section in manual. LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 43...
Page 44
Check to ensure that hydraulic steering pressure is Hydraulic pressure? adequate. Wiring? Check and repair wiring and connectors as necessary. Pitch system not working. Actuators? Check pitch system fuses. Replace if necessary. PAGE 44 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
18 AWG RED/B 18 AWG BLACK 18 AWG RED/Y 18 AWG BLACK 18 AWG PINK 14 AWG BLACK ACCESSORY POWER FOOT SW HOUR METER SEAT SWITCH FUEL SOLENOID PAGE 48 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
Page 49
18 AWG RED/BLUE BLACK 18 AWG RED/YELLOW 18 AWG ORANGE/BLUE BLACK 18 AWG BLACK WG BLACK 18 AWG BLACK SPEED LEVER 120Ω 0.4W FOOT SWITCH RESISTOR DC CONVERTER LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 49...
16 AWG BLACK RIGHT PITCH ACTUATOR 14 AWG RED 14 AWG BLACK CONNECT TO ACCESSORY POWER OUT MAIN HARNESS CONNECT LIGHT KIT ACCESSORY POWER OR SPRAY KIT HERE PAGE 50 — LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20)
14 AWG BLACK LIGHT ACCESSORY POWER OUT CONNECT SPRAY KIT HERE 18 AWG RED/WHITE 18 AWG BLACK LEFT REAR LIGHT 18 AWG RED/WHITE 18 AWG BLACK LD6 RIDE-ON POWER TROWEL • OPERATION MANUAL — REV. #0 (02/10/20) — PAGE 51...