Battery Safety - Powermate Aluminum LE Series Operating Manual

SAFETY IN MOTION
Stay alert. Should something break, loosen, or malfunction, on your machine, stop work
and seek qualified assistance to correct the condition. When going down a ramp or
incline, always walk ahead of the machine and use the open/close controls to engage
the rubber guard (foot) with the ground to act as a brake. Do not allow the loaded
®
PowerMate to attain an un-controllable speed. When moving a PowerMate
a stair without a load, always push the wheels off the step before lowering the wheels to
the next step.
Do not compress the top urethane bumper when the machine is under load.

BATTERY SAFETY

Lead-acid batteries contain hydrogen-oxygen gases that can be explosive and sulphuric
acid that can cause severe burns.To help avoid risk of danger and injury, observe
these precautions when handling or working with a lead-acid battery.
Wear ANSI approved safety glasses or goggles and a face shield. Wear proper clothing to
protect hands, and body. Wear appropriate rubber gloves and apron.
Never lean over a battery when testing or charging. Cigarettes, flames or sparks, could
cause a battery to explode. Keep all ignition sources away from battery. Do not strike the
sides of a battery with any spark producing item. Make sure work area is well-ventilated.
Never touch both battery terminals with bare hands at the same time. Remove rings,
watches and dangling jewelry when working with batteries. The metal in the jewelry can
cause a shock and burns if contacted with the battery terminals.
Only use insulated/non-conducting tools when making connections on a battery. Never lay
tools or other parts on top of a battery.
Because the batteries used in L P International products are of the sealed type, the battery
should be replaced if there is evidence of spillage. If there is spilled sulphuric acid present,
neutralize with baking soda. Never remove vent caps on a sealed battery. In the event of an
accident, flush with water and call a physician immediately. If venting gas is significantly
inhaled, seek immediate medical attention.
Never store batteries with explosives, flammable materials, chemicals, or food.
Protect batteries from crushing, punctures and shorting.
Do not charge or use booster cables or adjust battery connections without proper
instructions and training.
Keep batteries out of reach of children.
Do not accumulate used batteries. Dispose used batteries in accordance with local
environmental laws.
continued
2.07
®
PowerMate Operation Manual
PN 013140 Rev.D2
Eng. 12/ 12/ 12
®
unit down