Carrier AquaSnap 30MPA Series Controls, Start-Up, Operation, Service, And Troubleshooting page 101

NOTE: To avoid injury to personnel and damage to equipment or
property when completing the procedures listed in this start-up
checklist, use good judgment, follow safe practices, and adhere to
the safety considerations/information as outlined in preceding
sections of this Controls, Start-Up, Operation, Service and Trou-
bleshooting document.
A. Preliminary Information
JOB NAME _____________________________
ADDRESS _____________________________
CITY ____________________ STATE ______________ ZIP ___________
MARK FOR _____________________________
INSTALLING CONTRACTOR ______________
SALES OFFICE _________________________
START-UP PERFORMED BY ______________
B. Preliminary Equipment Check
Is there any shipping damage?
Was it noted on the freight bill?
Has a claim been filed with the shipper?
Will this damage prevent unit start-up?
Check power supply. Does it agree with unit?
Has the circuit protection been sized and installed properly?
Are the power wires to the unit sized and installed properly?
Has the ground wire been connected?
Are all electrical terminals tight?
System fluid volume in the loop ____________________gal (l)
Does this meet installation guide requirements?
Water system cleaned per installation guide?
Minimum flow rates verified per installation guide?
In-line minimum 40-mesh strainer installed within 10 ft of the cooler/condenser water inlet?
Cooler:
Condenser:
Air separation / bleed devices installed per installation guide?
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
Catalog No. 04-53300170-01
START-UP CHECKLIST FOR 30MP LIQUID CHILLER
(Remove and use for job file.)
(Yes or No)
If so, where
Printed in U.S.A. Form 30MP-4T Pg CL-1
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
 
YES NO
8-17 Replaces: 30MP-3T