Sharp AL-1651CS Operation Manual page 108

MATERIAL SAFETY DATA SHEET
8. EXPOSURE CONTROL / PERSONAL PROTECTION
Engineering Measures
Ventilation
Exposure limit values
OSHA-PEL (USA)
ACGIH-TLV (USA)
Personal Protective Equipment
Respiratory Protection
Hand Protection
Eye Protection
Skin Protection
Other Protective equipment :Use of a dust mask and goggles are recommended when
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State : Solid
Ph
Boiling/Melting Point
Softening Point (°C)
Flash Point (°C )
Ignition Point (°C )
Explosion Properties
3
Density (g/cm )
Solubility in water
10. STABILITY AND REACTIVITY
Stability
Hazardous Reactions
Conditions to avoid
Materials to avoid
Hazardous Decomposition Products :CO, CO
Further Information
11. TOXICOLOGICAL INFORMATION
Acute Toxicity
Ingestion (oral) :LD
Dermal :LD
Inhalation :No data
Eye irritation :Not an irritant
Skin irritation :Not an irritant
Skin sensitizer :No sensitization
Mutagenicity :Negative (Ames Test)
Carcinogenicity :In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible
human carcinogen). This classification is given to chemicals for which there is
inadequate human evidence, but sufficient animal evidence on which to base an
opinion of carcinogenicity. The classification is based upon the development of
lung tumors in rats receiving chronic inhalation exposures to free carbon black at
levels that induce particle overload of the lung. Studies performed in animal
models other than rats did not show any association between carbon black and
lung tumors. Moreover, a two-year cancer bioassay using a typical toner
preparation containing carbon black demonstrated no association between toner
exposure and tumor development in rats.
:None required with intended use.
3
:15mg/m (Total Dust) , 5mg/m
3
:10mg/m (Total Dust) , 3mg/m
:Not required under intended use.
:Not required under intended use.
:Not required under intended use.
:Not required under intended use.
handling a large quantity of toner or during long term exposure,
as with any non-toxic dust.
Form: Powder
:Not applicable
:Not applicable
:No data
:Not applicable
:No data
:No data
:1.1 (bulk density : 0.34)
:Negligible
:Stable
:Dust explosion, like most finely divided organic powders.
:Electric discharge, throwing into fire.
:Oxidizing Materials
and NO
2
:None
>2000mg/kg (Rats)
50
>2000mg/kg (Rats)
50
Data Revised: Jul. 31, 2002
Data Issued: Jun. 1, 1998
MSDS NO. F-00831
3
(Respirable Dust)
3
(Respirable Dust)
Color: Black Odor: odorless
X
Page: 3/4