Product Specific And Important Safety Information; Appliance Certification; Btu & Efficiency Specifications; Mobile Home Approved (Usa Only) - Vermont Castings 2115 Owner's Manual

1

Product Specific and Important Safety Information

A. Appliance Certification
MODEL: Intrepid FlexBurn
LABORATORY: OMNI Test Laboratories, Inc
REPORT NO. 0135WS038S / 0135WS038E
TYPE: Solid Fuel Type Room Heaters
STANDARD(s): UL 1 482-2011 ( R2015), U LC-S627-00
B. BTU & Efficiency Specifications
EPA Report #:
EPA Certified Emissions:
*LHV Tested Efficiency:
**HHV Tested Efficiency:
***EPA BTU Output:
****Peak BTU/Hour Output:
Vent Size:
Firebox Size:
Max. Wood Length:
Fuel Orientation:
Fuel
* Weighted average LHV efficiency using Douglas Fir
dimensional lumber and data collected during EPA
emissions test.
**Weighted average HHV efficiency using Douglas
Fir dimensional lumber and data collected during EPA
emissions test.
***Efficiencies are based on test results calculated using
B415; these calculated efficiencies are then used to
calculate output BTU's.
****A peak BTU out of the appliance calculated using the
maximum first hour burn rate from the High EPA Test and
the BTU content of cord wood (8600) times the efficiency.
The Vermont Castings Intrepid FlexBurn
meets the U.S. Environmental Protection Agency's crib wood
emission limits for wood appliances sold after May 15, 2020.
This wood appliance needs periodic inspection and repair for
proper operation. It is against federal regulations to operate
this wood appliance in a manner inconsistent with operating
instructions in this manual.
3-90-30007345c
2115/2115-CAT
®
0135WS038E
.6 g/hr
(without catalyst)
.3 g/hr
(catalytic)
80.3%
(without catalyst)
82.8%
(catalytic)
74.3%
(without catalyst)
76.7%
(catalytic)
12,500 - 18,500
(without catalyst)
10,700 - 16,000
(catalytic)
36,900
(without catalyst)
34,900
(catalytic)
6 Inch (152 mm)
1.3 cu. ft.
16" Maximum
East, West
Seasoned Cordwood
(20% moisture)
Wood Appliance
®
Vermont Castings • Intrepid FlexBurn
C. Mobile Home Approved (USA ONLY)
• This appliance is approved for mobile home installations
in the USA when not installed in a sleeping room and
when an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceiling,
and walls must be maintained.
• The appliance must be properly grounded to the frame
of the mobile home with #8 copper ground wire, and
chimney must be listed to UL103 HT or a listed UL-1777
full length six inch (152mm) diameter liner must be used.
• Outside Air Kit, part 0003265 must be installed in a
mobile home installation.
D. Glass Specifications
This appliance is equipped with 5mm ceramic glass.
Replace glass only with 5mm ceramic glass. Please contact
your dealer for replacement glass.
E. California Safety Information
This product and the fuels used to operate this product
(wood), and the products of combustion of such fuels, can
expose you to chemicals including carbon black, which
is known to the State of California to cause cancer, and
carbon monoxide, which is know to the State of California
to cause birth defects or other reproductive harm. For
more information go to: www.P65Warnings.ca.gov
Proposition 65 Warning: Fuels used in gas, wood
burning or oil fired appliances, and the products of
combustion of such fuels, contain chemicals known to
the State of California to cause cancer, birth defects and
other reproductive harm.
California Health & Safety Code Sec. 25249.6
Owner's Manual_R2 • 2018 - ___ • 07/18
®
!
WARNING
7