Important Safety Information; Appliance Certification; Btu & Efficiency Specifications; Glass Specifications - Quadra-Fire CB1200M-MBK Installation Manual

1

Important Safety Information

A. Appliance Certification
Model CB1200 Pellet Appliance
Laboratory
OMNI Test Laboratories, Inc.
Report No.
061-S-21-4
Type
Solid Fuel Room Appliance/Pellet Fuel Burn-
ing Type
Standard ASTM E1509-04, ULC S627-00 and ULC/
ORD-C1482-M1990 Room Appliance Pellet
Fuel Burning type and (UM) 84-HUD, Mobile
Home Approved.
FCC Complies with Part 15 of FCC Rules. Opera-
tion is subject to the following two conditions:
(1) this device may not cause harmful inter-
ference, and (2) this device must accept any
interference received, including interference
that may cause undesired operation.
NOTICE: This installation must conform with local codes. In the
absence of local codes you must comply with the ASTM E1509-
04, ULC S627-00, (UM) 84-HUD and ULC/ORD-C-1482.
B. BTU & Efficiency Specifications
The Quadra-Fire CB1200 Pellet Appliance meets the U.S. Environ-
mental Protection Agency's emission limits for pellet appliances
sold after May 15, 2015.
This pellet appliance needs periodic inspection and repair for proper
operation. It is against federal regulations to operate this pellet
appliance in a manner inconsistent with operating instructions in
this manual.
EPA Certification #: 955-14
EPA Certified Emissions: 1.1 grams per hour
*LHV Tested Efficiency: 76%
**HHV Tested Efficiency: 70.3%
***EPA BTU Output: 13,500 - 37,600 / hr
****BTU Input: 18,500 - 51,600 / hr
Vent Size: 3" or 4" L or PL
Hopper Capacity: 80 lbs.
Fuel: Wood Pellets
*Weighted average LHV efficiency using data collected
during EPA emissions test.
**Weighted average HHV efficiency using data collected
during EPA emissions test.
***A range of BTU outputs based on EPA Default Effi-
ciency and the burn rates from the low and high EPA
tests.
****Based on the maximum feed rate per hour multi-
plied by approximately 8600 BTU's which is the average
BTU's from a pound of pellets.
C. Glass Specifications
This appliance is equipped with 5mm ceramic glass. Replace
glass only with 5mm ceramic glass. Please contact your dealer
for replacement glass.
November 30, 2017
D. Electrical Rating
115 VAC, 60 Hz, Start 4.1 Amps, Run 1.1 Amps
E. Mobile Home Approved
• This appliance is approved for mobile home installations
when not installed in a sleeping room and when an outside
combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceiling, and
walls must be maintained.
• The appliance must be properly grounded to the frame of
the mobile home and use only Listed pellet vent Class "L" or
"PL" connector pipe.
• Outside Air Kit, part OAK-ACC must be installed in a mobile
home installation.
F. Non-Combustible Materials
Material which will not ignite and burn, composed of any combina-
tion of the following:
- Steel - Plaster
- Concrete - Tile
Materials reported as passing ASTM E 136, Standard Test
Method for Behavior of Metals, in a Vertical Tube Furnace of
750° C.
G. Combustible Materials
Material made of/or surfaced with any of the following materials:
- Wood
- Plant Fibers
- Plywood/OSB
Any material that can ignite and burn: flame proofed or not, plas-
tered or non-plastered.
Fire Risk.
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be
voided by, the following actions:
• Installation and use of any damaged appliance.
• Modification of the appliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installation and/or use of any component part not approved by
Hearth & Home Technologies.
• Operating appliance without fully assembling all components.
• Operating appliance without legs attached (if supplied with
appliance).
• Do NOT Over fire - If appliance or chimney connector glows,
you are over firing.
Any such action that may cause a fire hazard.
Improper installation, adjustment, alteration, service or maintenance
can cause injury or property damage.
For assistance or additional information, consult a qualified installer,
service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of this appli-
ance, reserves the right to alter its products, their specifications
and/or price without notice.
7014-258B
CB1200 FREESTANDING
- Brick - Iron
- Glass - Slate
- Compressed Paper
- Plastic
- Sheet Rock (drywall)
WARNING
3