Field Wiring - Superior VRE4336ZEN Installation And Operation Instructions Manual

FIELD WIRING

CAUTION: LABEL ALL WIRES PRIOR TO DIS-
CONNECTION WHEN SERVICING CONTROLS.
WIRING ERRORS CAN CAUSE IMPROPER AND
DANGEROUS OPERATION. VERIFY PROPER
OPERATION AFTER SERVICING.
Refer to Figure 11 for the wiring schematic
for these fireplaces.
This fireplace is completely wired internally.
On the right hand side of the fireplace, at the
rear, are four (4) wires required to connect the
Battery and switch for operation.
Two brown wires are for the connection of the
switch. These are labeled SW and SW. A black
and red pair are for connection to the battery
pack. These are labeled (+) and (–).
ELECTRONIC IGNITION WIRING DIAGRAM
NOTES:
1. If any of the original wire as supplied must be replaced, use Type AWM 105°C - 18 gage wire ONLY.
2. Electrical Rating: 3V DC.
CAUTION: label all wires prior to disconnection when servicing controls. Wiring errors can cause
improper and dangerous operation. Verify proper operation after servicing.
WALL SWITCH BOX
WEATHER
SEAL
COVER
REMOTE WALL SWITCH
WALL SWITCH BOX
REMOTE
WALL
SWITCH
Figure
11
10
These wires are for low voltage current. An
electrical box has been provided to contain both
the switch and battery pack. Mount the box in
an appropriate location within the length of the
wiring provided. Feed all four wires through one
of the lower inlets to the box. Connect the switch
wires to the switch and the corresponding (+),
(–) to the battery holder.
Install two D-cell batteries (not provided) and
test the switch before closing the switch box
(refer to Figure 12). The igniter should spark
to the pilot when the switch is on.
Wiring diagrams are provided here for refer-
ence purposes only. This information is also
provided on schematics attached directly to
the appliance on a pullout panel located within
the control compartment.
D-CELL BATTERIES
BLACK
BATTERY
RED
BROWN
BROWN
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
IGNITER MODULE - 3V
BLACK
BLACK
PILOT SENSOR CABLE
(THTP)
ORANGE
BLACK (TP)
HIGH LIMIT
(TH)
SWITCH
BLACK JUMPER
GREEN
UMBILICAL CORD (9 Feet)
Weather Seal
Cover
Switch
Figure 12
PILOT BURNER
IGNITER-SENSOR
ASSEMBLY
IGNITER
ROD
SPARK WIRE CABLE
PILOT TUBE
ELECTRONIC GAS CONTROL VALVE - DEXEN
HI
LO
Schematic Representation Only
Orient Batteries Vertically
To Fit Within Box
FLAME
SENSOR