Checking Spark Arrester Of Exhaust Pipe (If Equipped) (R); Checking And Changing Gearbox Oil (S); Checking And Changing Gearbox Oil (S); Checking Spark Arrester Of - Cushman 646442 Owner's Manual

7
hauler 4x4 Diesel
-2

ChECkING spARk ARREsTER of

EXhAUsT pIpE (If EQUIppED) (R)

1. park the vehicle on level ground
and apply the parking brake firmly.
2. stop the engine and let the engine
cooled down sufficiently.
3. Loosen the fixing bolt and then re-
move the spark arrester.
4. apply WD-40 or equivalent to the
inner side and blow any residual
with compressed air. Do not blow
with compressed air too closely, or
the filter can be damaged.
5. If the filter is damaged, replace the
spark arrester with a new one.
WARNING
you can get burnt by touch-

ing hot parts, such as the muf-
fler. Wait until hot parts have
cooled down after stopping
the engine.

ChECkING AND ChANGING GEARBoX oIl (s)

1. park the vehicle on level ground
and apply the parking brake firmly.
2. stop the engine and let the engine
cooled down sufficiently.
3. raise the cargo bed and support it
with the support rod.
(1) filler plug
4. clean around filler plug, then re-
move the filler plug.
5. check that the gearbox surface
is not hot. then, check the oil lev-
el and condition with a finger bent
slightly. if you cannot reach the oil,
it means the oil level is low. add oil
as needed to fill.
6. if the color or viscosity of the oil is
not normal or it is at the oil change
interval, change the oil.
(1) Drain plug
7. to change oil, place a container
UUVo734A
with wide opening under the drain
plug. then, remove the drain plug.
8. after draining all the oil, install the
drain plug firmly.
9. W h e n a d d i n g n e w o i l , a d d i t
through a long hose into the fill
plug location. fill till oil starts to
spill out of filler plug hole.
UUVo735A