Safety Instructions Related To Electricity And Carbon Dioxide Bottles (Co ) - Cornelius PearlMini User Manual


5. Safety Instructions related to electricity and carbon dioxide bottles (CO
Safety Instructions -> Electricity
An electric shock may be fatal or result in serious injury! For this reason, any unauthorized
tampering is strictly prohibited. Water and electricity are a fatal mixture!
Always pull the 230 Volt mains plug before any cleaning work on or near the unit.
Upon delivery, the unit is supplied with a moulded earthing-pin plug that must be connected to a
socket outlet with an appropriate earthing contact. Make sure that the plug is easy accessible to
enable a quick disconnection from the mains power supply if needed.
Safety Instructions -> CO
The unit is operated with an external CO
Handling of CO
- in operation, always place the carbon dioxide (CO
secure it against falling over.
- do not throw the CO
- store the bottle in a dry, cool and ventilated area and protect it against heat (e.g. sunshine, heating
pipes, etc.). Always keep a minimum distance of 0.5 m from heaters.
- In case of heat impact, there is a substantial risk of explosion. The CO
a safety valve that will automatically discharge the excessive gas pressure.
- When operating the unit with an external CO
specific regulations and safety instructions must be followed (e.g. calculation of the maximal
allowed gas concentrations, etc). If necessary, additional ventilation must be installed in order to
ensure the required safety level.
- Escaping carbon dioxide (CO
above 3 vol.% occur in closed areas.
- Be reminded that parts of the unit are under operating pressure. Do not loosen or dismantle any
components while the system is at operating pressure.
- When connecting a new CO
no liquid CO enters the regulator, thus putting it out of function. At all times consider your
2
responsibility as a service technician when judging the risk potential and health risks of CO
6. Intended Use
The PearlMini water dispensers are designed for cooling and dispensing drinking water only.
The unit is only to be operated with potable drinking water that meets local regulations.
Only food suitable CO gas is to be used with the dispenser (bottles are marked with E290 CO
2
The cooling of other drinks or liquids is forbidden.
Gas Supply (only relevant for units with soda water option)
2
bottles
2
bottle
2
) is heavier than air and will lead to suffocation if concentrations
2
bottle, open the valve on the bottle for 1-2 sec. in order to assure that
2
gas bottle
2
) bottle in an upright position next to the unit and
2
Gas supply (e.g. 10 kg CO
2
17
PearlMini
POU WATERDISPENSER
)
2
cylinders are equipped with
2
-bottles) all country-
2
2
gas)
2
leaks