Page 2
99-9224 T ABLE OF CONTENTS Dash Disassembly 1999-2006 Volvo S80 ....... . .1,2 Kit Assembly DIN Head Unit Provision with Pocket .
Page 3
99-9224 1999-2006 VOLVO S80 Disconnect the negative battery terminal to prevent an accidental short circuit. Unsnap gear shifter trim panel. (Figure A) Unsnap gear shifter boot to separate it from the gear shifter trim panel and remove trim panel. (Figure B) Remove (2) T-25 Torx head screws from bottom of climate controls.
Page 4
99-9224 1999-2006 VOLVO S80 Remove (2) T-25 Torx head screws from bottom of radio. Unplug and remove the radio. (Figure E) Depress the snaps on the top and bottom of the pocket to remove it from the radio bracket. (Figure F)
Page 5
99-9224 DIN HEAD UNIT PROVISION NOTE: Also refer to the instructions included with the aftermarket radio. Using a Phillips screw driver remove the rear support bracket from the radio housing. (Figure A) Snap the radio housing into the radio bracket (removed from factory radio) and replace rear support bracket.
Page 6
99-9224 FINAL ASSEMBL Y 1 Locate the factory wiring harness in the dash and make the connection as shown. Metra recomends using the proper mating adapter and making the connections as shown. (Isolate and individually tape off the ends of any unused wires to prevent electrical short circuit.)