Aerco innovation 1350p Manuals

Manuals and User Guides for Aerco innovation 1350p. We have 1 Aerco innovation 1350p manual available for free PDF download: User Manual

Aerco innovation 1350p User Manual (194 pages)

Natural Gas and Propane Gas Modulating, Condensing Water heaters

Brand: Aerco | Category: Water Heater | Size: 12 MB

Table of Contents
2
Foreword

7
Chapter 1. Safety Precautions

11
- Warnings & Cautions
  11
- Emergency Shutdown
  12
- Prolonged Shutdown
  12
Chapter 2. Installation

15
- Introduction
  15
- Receiving the Unit
  15
- Unpacking
  15
- Site Preparation
  16
  - Installation Clearances
    16
  - Setting the Unit
    17
- Water Inlet and Outlet Piping
  18
  - WHM Actuator-Controlled Ball Valve Installation
    19
- Test Hose Bib Connection
  20
- Internal Recirculation Loop
  21
- Pressure & Temperature Relief Valve Installation
  22
- Condensate Drain & Piping
  22
- Gas Supply Piping
  24
- Ac Electrical Power Wiring
  27
  - Electrical Power Requirements
    28
- Field Control Wiring
  29
  - OUTDOOR AIR in Terminal
    30
  - COMBUSTION AIR Terminals
    30
  - O2 SENSOR Terminals
    30
  - SPARK SIGNAL Terminals
    30
  - ANALOG in Terminals
    30
  - VALVE FEEDBACK Terminals
    31
  - SHIELD Terminals
    31
  - ANALOG out Terminals
    31
  - RS485 Comm Terminals
    32
  - RS232 Comm Terminals
    32
  - VFD/BLOWER Terminals
    32
  - Interlock Terminals
    32
  - FAULT RELAY Terminals
    32
  - AUX RELAY Terminals
    33
- Flue Gas Vent Installation
  33
- Combustion Air
  34
  - Combustion from Outside the Building
    34
  - Combustion Air from Inside the Building
    34
- Ducted Combustion
  35
Chapter 3. Operation

37
- Introduction
  37
- Control Panel Description
  37
- Control Panel Menus
  41
  - Menu Processing Procedure
    41
- Operating Menu
  43
- Setup Menu
  44
- Configuration Menu
  44
- Tuning Menu
  47
- Calibration Menu
  48
- Start Sequence
  50
- Start/Stop Levels
  53
Chapter 4. Initial Start-Up

55
Chapter 5. Safety Device Testing

69
- Introduction
  69
- Low Gas Pressure Fault Test
  69
- High Gas Pressure Fault Test
  70
- Low Water Level Fault Test
  71
- Water Temperature Fault Test
  71
- Interlock Tests
  72
  - Remote Interlock
    72
  - Delayed Interlock
    73
- FLAME FAULT Tests
  73
- Air Flow Fault Tests
  74
- Ssov Proof of Closure Switch
  76
- Purge Switch Open During Purge
  77
- Ignition Switch Open During Ignition
  77
- Safety Pressure Relief Valve Test
  78
Chapter 6. Maintenance

79
Chapter 7. Troubleshooting Guide

101
- Introduction
  101
- Additional Faults Without Specific Fault Messages
  113
Chapter 8. Water Heater Management

117
- General Description
  117
- Whm Principles of Operation
  118
- New Aerco Whm Features
  118
  - Valve Feedback
    118
  - Valve Supervisor
    118
  - Valve Control
    118
  - Modbus Header Sensor
    119
  - Automatic Temperature Sensor Calibration
    119
  - Manual Mode Password Required
    119
  - WHM Auto Mstr
    119
  - Run Hours and Run Cycles
    119
  - High Temperature Governor
    120
- Whm Status Displays
  120
- Water Heater Management Alternating Status Displays
  121
- Whm Menu
  122
- Whm Menu Item Descriptions
  124
- Whm Hardware Installation & Set-Up Instructions
  128
  - Installation Notes
    128
  - Hardware Installation
    129
  - WHM Modbus Network Wiring
    130
  - Control and Power Wiring
    131
- Whm Programming & Start-Up
  132
- Troubleshooting
  134
- Sequencing Valve Description & Operation
  135
  - Sequencing Valve Description
    135
  - Sequencing Valve Operating Characteristics
    137
APPENDIX A - Innovation Menu Item Descriptions

139
APPENDIX B - Startup, Status and Fault Messages

149
APPENDIX C - Temperature Sensor Resistance/Voltage Chart

153
APPENDIX D - Dimensional Drawings

155
APPENDIX E - Parts List Drawings

157
APPENDIX F - Piping Drawings

169
APPENDIX G - C-More Control Panel Views

179
APPENDIX H - C-More Wiring Diagrams

181
APPENDIX I - Recommended Spares

189
APPENDIX J - Warranty

191

Aerco Categories

Boiler Water Heater Heater Controller Recording Equipment

More Aerco Manuals

Aerco innovation 1350p Manuals

Aerco innovation 1350p User Manual (194 pages)

Table of Contents

Foreword

Chapter 1. Safety Precautions

Chapter 2. Installation

Chapter 3. Operation

Chapter 4. Initial Start-Up

Chapter 5. Safety Device Testing

Chapter 6. Maintenance

Chapter 7. Troubleshooting Guide

Chapter 8. Water Heater Management

APPENDIX A - Innovation Menu Item Descriptions

APPENDIX B - Startup, Status and Fault Messages

APPENDIX C - Temperature Sensor Resistance/Voltage Chart

APPENDIX D - Dimensional Drawings

APPENDIX E - Parts List Drawings

APPENDIX F - Piping Drawings

APPENDIX G - C-More Control Panel Views

APPENDIX H - C-More Wiring Diagrams

APPENDIX I - Recommended Spares

APPENDIX J - Warranty

Related Products

Aerco Categories