User Manuals: Aerco innovation 1060p Water Heater

Manuals and User Guides for Aerco innovation 1060p Water Heater. We have 1 Aerco innovation 1060p Water Heater manual available for free PDF download: User Manual

Aerco innovation 1060p User Manual (194 pages)

Natural Gas and Propane Gas Modulating, Condensing Water heaters

Brand: Aerco | Category: Water Heater | Size: 12 MB

Table of Contents
2
Foreword

7
Chapter 1. Safety Precautions

11
- Warnings & Cautions
  11
- Emergency Shutdown
  12
- Prolonged Shutdown
  12
Chapter 2. Installation

15
- Introduction
  15
- Receiving the Unit
  15
- Unpacking
  15
- Site Preparation
  16
  - Installation Clearances
    16
  - Setting the Unit
    17
- Water Inlet and Outlet Piping
  18
  - WHM Actuator-Controlled Ball Valve Installation
    19
- Test Hose Bib Connection
  20
- Internal Recirculation Loop
  21
- Pressure & Temperature Relief Valve Installation
  22
- Condensate Drain & Piping
  22
- Gas Supply Piping
  24
- Ac Electrical Power Wiring
  27
  - Electrical Power Requirements
    28
- Field Control Wiring
  29
  - OUTDOOR AIR in Terminal
    30
  - COMBUSTION AIR Terminals
    30
  - O2 SENSOR Terminals
    30
  - SPARK SIGNAL Terminals
    30
  - ANALOG in Terminals
    30
  - VALVE FEEDBACK Terminals
    31
  - SHIELD Terminals
    31
  - ANALOG out Terminals
    31
  - RS485 Comm Terminals
    32
  - RS232 Comm Terminals
    32
  - VFD/BLOWER Terminals
    32
  - Interlock Terminals
    32
  - FAULT RELAY Terminals
    32
  - AUX RELAY Terminals
    33
- Flue Gas Vent Installation
  33
- Combustion Air
  34
  - Combustion from Outside the Building
    34
  - Combustion Air from Inside the Building
    34
- Ducted Combustion
  35
Chapter 3. Operation

37
- Introduction
  37
- Control Panel Description
  37
- Control Panel Menus
  41
  - Menu Processing Procedure
    41
- Operating Menu
  43
- Setup Menu
  44
- Configuration Menu
  44
- Tuning Menu
  47
- Calibration Menu
  48
- Start Sequence
  50
- Start/Stop Levels
  53
Chapter 4. Initial Start-Up

55
Chapter 5. Safety Device Testing

69
- Introduction
  69
- Low Gas Pressure Fault Test
  69
- High Gas Pressure Fault Test
  70
- Low Water Level Fault Test
  71
- Water Temperature Fault Test
  71
- Interlock Tests
  72
  - Remote Interlock
    72
  - Delayed Interlock
    73
- FLAME FAULT Tests
  73
- Air Flow Fault Tests
  74
- Ssov Proof of Closure Switch
  76
- Purge Switch Open During Purge
  77
- Ignition Switch Open During Ignition
  77
- Safety Pressure Relief Valve Test
  78
Chapter 6. Maintenance

79
Chapter 7. Troubleshooting Guide

101
- Introduction
  101
- Additional Faults Without Specific Fault Messages
  113
Chapter 8. Water Heater Management

117
- General Description
  117
- Whm Principles of Operation
  118
- New Aerco Whm Features
  118
  - Valve Feedback
    118
  - Valve Supervisor
    118
  - Valve Control
    118
  - Modbus Header Sensor
    119
  - Automatic Temperature Sensor Calibration
    119
  - Manual Mode Password Required
    119
  - WHM Auto Mstr
    119
  - Run Hours and Run Cycles
    119
  - High Temperature Governor
    120
- Whm Status Displays
  120
- Water Heater Management Alternating Status Displays
  121
- Whm Menu
  122
- Whm Menu Item Descriptions
  124
- Whm Hardware Installation & Set-Up Instructions
  128
  - Installation Notes
    128
  - Hardware Installation
    129
  - WHM Modbus Network Wiring
    130
  - Control and Power Wiring
    131
- Whm Programming & Start-Up
  132
- Troubleshooting
  134
- Sequencing Valve Description & Operation
  135
  - Sequencing Valve Description
    135
  - Sequencing Valve Operating Characteristics
    137
APPENDIX A - Innovation Menu Item Descriptions

139
APPENDIX B - Startup, Status and Fault Messages

149
APPENDIX C - Temperature Sensor Resistance/Voltage Chart

153
APPENDIX D - Dimensional Drawings

155
APPENDIX E - Parts List Drawings

157
APPENDIX F - Piping Drawings

169
APPENDIX G - C-More Control Panel Views

179
APPENDIX H - C-More Wiring Diagrams

181
APPENDIX I - Recommended Spares

189
APPENDIX J - Warranty

191

Aerco Categories

Boiler Water Heater Heater Controller Recording Equipment

More Aerco Manuals

User Manuals: Aerco innovation 1060p Water Heater

Aerco innovation 1060p User Manual (194 pages)

Table of Contents

Foreword

Chapter 1. Safety Precautions

Chapter 2. Installation

Chapter 3. Operation

Chapter 4. Initial Start-Up

Chapter 5. Safety Device Testing

Chapter 6. Maintenance

Chapter 7. Troubleshooting Guide

Chapter 8. Water Heater Management

APPENDIX A - Innovation Menu Item Descriptions

APPENDIX B - Startup, Status and Fault Messages

APPENDIX C - Temperature Sensor Resistance/Voltage Chart

APPENDIX D - Dimensional Drawings

APPENDIX E - Parts List Drawings

APPENDIX F - Piping Drawings

APPENDIX G - C-More Control Panel Views

APPENDIX H - C-More Wiring Diagrams

APPENDIX I - Recommended Spares

APPENDIX J - Warranty

Related Products

Aerco Categories