Aerco INNOVATION INN1060 Manuals

Manuals and User Guides for Aerco INNOVATION INN1060. We have 4 Aerco INNOVATION INN1060 manuals available for free PDF download: User Manual, Electrical Manual

Aerco INNOVATION INN1060 User Manual (206 pages)

Natural Gas or Propane Modulating, Condensing Water Heater

Brand: Aerco | Category: Water Heater | Size: 12 MB

Table of Contents
3
Foreword

7
Chapter 1. Safety Precautions

13
- Warnings & Cautions
  13
- Emergency Shutdown
  14
- Prolonged Shutdown
  15
Chapter 2. Installation

17
- Introduction
  17
- Receiving the Unit
  17
- Unpacking
  17
- Site Preparation
  18
  - Installation Clearances
    18
  - Setting the Unit
    19
- Water Inlet and Outlet Piping
  20
  - WHM Actuator-Controlled Ball Valve Installation
    20
- Test Hose Bib Connection
  21
- System Recirculation Loop
  22
- Pressure & Temperature Relief Valve Installation
  23
- Condensate Drain & Piping
  24
- Gas Supply Piping
  26
- Ac Electrical Power Wiring
  28
  - Electrical Power Requirements
    28
- Field Control Wiring
  29
  - OUTDOOR AIR in Terminal
    30
  - COMBUSTION AIR Terminals
    30
  - O2 SENSOR Terminals
    30
  - SPARK SIGNAL Terminals
    30
  - ANALOG in Terminals
    31
  - VALVE FEEDBACK Terminals
    31
  - SHIELD Terminals
    31
  - ANALOG out Terminals
    31
  - RS485 Comm Terminals
    32
  - RS232 Comm Terminals
    32
  - VFD/BLOWER Terminals
    32
  - Interlock Terminals
    32
  - FAULT RELAY Terminals
    33
  - AUX RELAY Terminals
    33
- Flue Gas Vent Installation
  33
- Combustion Air
  34
  - Combustion from Outside the Building
    34
  - Combustion Air from Inside the Building
    34
- Ducted Combustion
  35
Chapter 3. Operation

37
- Introduction
  37
- Control Panel Description
  37
- Control Panel Menus
  41
  - Menu Processing Procedure
    41
- Operating Menu
  43
- Setup Menu
  44
- Configuration Menu
  44
- Tuning Menu
  46
- Calibration Menu
  47
- Start Sequence
  49
- Start/Stop Levels
  52
Chapter 4. Initial Start-Up

53
Chapter 5. Safety Device Testing

67
- Introduction
  67
- Low Gas Pressure Fault Test
  67
- High Gas Pressure Fault Test
  68
- Low Water Level Fault Test
  69
- Water Temperature Fault Test
  69
- Interlock Tests
  70
  - Remote Interlock
    70
  - Delayed Interlock
    71
- FLAME FAULT Tests
  71
- Air Flow Fault Tests
  72
- Ssov Proof of Closure Switch
  74
- Purge Switch Open During Purge
  75
- Ignition Switch Open During Ignition
  75
- Safety Pressure Relief Valve Test
  76
Chapter 6. Maintenance

77
Chapter 7. Troubleshooting Guide

97
- Introduction
  97
- Additional Faults Without Specific Fault Messages
  109
Chapter 8. Water Heater Management

113
- General Description
  113
- Whm Principles of Operation
  114
- New Aerco Whm Features
  114
  - Valve Feedback
    114
  - Valve Supervisor
    114
  - Valve Control
    114
  - Modbus Header Sensor
    115
  - Automatic Temperature Sensor Calibration
    115
  - Manual Mode Password Required
    115
  - Quick Re-Flash Feature
    115
  - WHM Auto Mstr
    116
  - Run Hours and Run Cycles
    116
  - High Temperature Governor
    116
- Whm Status Displays
  116
- Bst Alternating Status Displays
  117
- Whm Menu
  117
- Whm Menu Item Descriptions
  119
- Whm Hardware Installation & Set-Up Instructions
  123
  - Hardware Installation
    123
  - WHM Modbus Network Wiring
    124
  - Control and Power Wiring
    125
- Whm Programming & Start-Up
  127
- Troubleshooting
  129
- Sequencing Valve Description & Operation
  129
  - Sequencing Valve Description
    129
  - Sequencing Valve Operating Characteristics
    132
Appendix A - Innovation Menu Item Descriptions

133
Appendix B - Startup, Status and Fault Messages

143
Appendix C - Temperature Sensor Resistance/Voltage Chart

147
Appendix D - Dimensional Drawings

149
Appendix E - Parts List Drawings

151
Appendix F - Piping Drawings

173
Appendix G - C-More Control Panel Views

187
Appendix H - C-More Wiring Diagrams

189
Appendix I - Recommended Spares

197
Appendix J - Combustion Calibration (Korea Only)

199
Appendix K - Warranty

203

Aerco INNOVATION INN1060 User Manual (190 pages)

Brand: Aerco | Category: Water Heater | Size: 18 MB

Table of Contents

3
Foreword

7
Chapter 1 Safety Precautions

11
- Warnings & Cautions
  11
- Emergency Shutdown
  12
- Prolonged Shutdown
  12
Chapter 2 Installation

15
- Introduction
  15
- Receiving the Unit
  15
- Unpacking
  15
- Site Preparation
  15
  - Installation Clearances
    16
  - Setting the Unit
    17
- Water Inlet and Outlet Piping
  17
  - WHM Actuator-Controlled Ball Valve Installation
    18
- Test Hose Bib Connection
  19
- System Recirculation Loop
  20
- Pressure & Temperature Relief Valve Installation
  22
- Condensate Drain & Piping
  22
- Gas Supply Piping
  24
- Ac Electrical Power Wiring
  25
  - Electrical Power Requirements
    26
- Field Control Wiring
  27
  - Outdoor Sensor in
    28
  - Air Temp Sensor
    28
  - O2 Sensor Terminals
    28
  - Flow +/Flow
    28
  - Analog in
    28
  - Pwm) in
    29
  - Shield
    29
  - Ma out
    29
  - RS485 Comm
    29
  - RS232 Comm (Txd/Rxd)
    29
  - Vfd/Blower
    29
  - Interlocks
    29
  - Fault Relay
    30
  - Auxiliary (Aux) Relay Contacts
    30
- Flue Gas Vent Installation
  30
- Combustion Air
  31
  - Combustion from Outside the Building
    31
  - Combustion Air from Inside the Building
    31
- Sealed Combustion
  31
Chapter 3 Operation

33
- Introduction
  33
- Control Panel Description
  33
- Control Panel Menus
  37
  - Menu Processing Procedure
    37
- Operating Menu
  40
- Setup Menu
  40
- Configuration Menu
  41
- Water Heater Management (Whm) Menu
  43
- Tuning Menu
  43
- Start Sequence
  44
- Start/Stop Levels
  46
Chapter 4 Initial Start-Up

49
Chapter 5 Safety Device Testing

59
- Testing of Safety Devices
  59
- Low Gas Pressure Fault Test
  59
- High Gas Pressure Fault Test
  60
- Low Water Level Fault Test
  61
- Water Temperature Fault Test
  61
- Interlock Tests
  62
  - Remote Interlock
    62
  - Delayed Interlock
    63
- Omm-0078_0G
  63
- Flame Fault Tests
  63
- Air Flow Fault Tests
  64
- Ssov Proof of Closure Switch
  66
- Purge Switch Open During Purge
  67
- Ignition Switch Open During Ignition
  67
- Safety Pressure Relief Valve Test
  68
Chapter 6 Maintenance

69
- Maintenance Schedule
  69
- Igniter-Injector
  70
  - Igniter-Injector Part No. 58023
    70
  - Igniter Part No. 66023
    72
- Flame Detector
  74
- Combustion Calibration
  74
- Safety Device Testing
  74
- Fireside Inspection
  74
- Waterside Inspection
  79
- Heat Exchanger Cleaning
  81
- Condensate Drain Trap
  83
- Air Filter Replacement
  84
- Shutting the Water Heater down for an Extended Period of Time
  85
- Placing the Heater Back in Service after a Prolonged Shutdown
  86
Chapter 7 Troubleshooting Guide

87
- Introduction
  87
- Additional Faults Without Specific Fault Messages
  99
Chapter 8 Rs232 Communication

103
- Introduction
  103
- Rs232 Communication Setup
  103
- Menu Processing Utilizing Rs232 Communication
  103
- Data Logging
  104
  - Fault Log
    104
  - Operation Time Log
    105
  - Sensor Log
    105
Chapter 9 Water Heater Management

107
- Introduction
  107
- General Description
  107
- Whm Principles of Operation
  108
- Whm Menu
  108
- Whm Hardware Installation & Set-Up Instructions
  109
  - Hardware Installation
    109
  - WHM Modbus Network Wiring
    110
  - Control and Power Wiring
    110
- Whm Menu Settings
  112
  - WHM Mode
    112
  - Comm Address (Located in Setup Menu)
    112
  - WHM Setpoint
    112
  - WHM Nxt on VP
    112
  - WHM Nxt off VP
    112
  - Lead/Lag Hours
    112
  - Setback Setpoint
    112
  - Setback Start & Setback End
    112
  - WHM Auto Mstr
    113
  - WHM Auto Timer
    113
- Whm Programming & Start-Up
  113
- Troubleshooting
  115
- Sequencing Valve Description & Operation
  116
  - Sequencing Valve Description
    116
  - Sequencing Valve Operating Characteristics
    118
Appendix A: Innovation Menu Item Descriptions

119
Appendix B: Startup, Status and Fault Messages

125
Appendix C: Temperature Sensor Resistance/Voltage Chart

129
Temperature Sensor Resistance/Voltage Chart

129
Appendix D: Innovation Default Settings

131
Appendix E: Parts List Drawings

133
Appendix F: Piping Drawings

147
Appendix G: C-More Control Panel Views

169
Appendix H: C-More Wiring Diagrams

171
Appendix I: Recommended Spares

179
Appendix J: Combustion Calibration (Korea Only)

181
Appendix K: Warranty

185

Aerco INNOVATION INN1060 User Manual (200 pages)

gas-fired

Brand: Aerco | Category: Water Heater | Size: 6 MB

Table of Contents
3
Foreword
7
Chapter 1. Safety Precautions

9
- Warnings & Cautions
  9
- Emergency Shutdown
  10
- Prolonged Shutdown
  10
Chapter 2. Installation

13
- Introduction
  13
- Receiving the Unit
  13
- Unpacking
  13
- Site Preparation
  13
  - Installation Clearances
    14
  - Setting the Unit
    15
- Water Inlet and Outlet Piping
  15
- Test Hose Bib Connection
  16
- Pressure & Temperature Relief Valve Installation
  17
- System Recirculation Loop
  17
- Condensate Drain & Piping
  17
- Gas Supply Piping
  19
- Ac Electrical Power Wiring
  21
  - Electrical Power Requirements
    21
- Field Control Wiring
  22
  - Outdoor Air Sensor
    23
  - Aux Sensor in
    23
  - Analog in
    23
  - Pwm) in
    24
  - Shield
    24
  - Ma out
    24
  - Exhaust Sensor in
    24
  - Interlocks
    24
  - Fault Relay
    25
  - Auxiliary Relay Contacts
    25
- Flue Gas Vent Installation
  25
- Combustion Air
  25
  - Combustion from Outside the Building
    26
  - Combustion Air from Inside the Building
    26
- Sealed Combustion
  26
Chapter 3. Operation

27
- Introduction
  27
- Control Panel Description
  27
- Control Panel Menus
  31
  - Menu Processing Procedure
    31
- Operating Menu
  32
- Setup Menu
  33
- Configuration Menu
  34
- Tuning Menu
  35
- Start Sequence
  36
- Start/Stop Levels
  38
Chapter 4. Initial Start-Up

41
Chapter 5. Safety Device Testing

49
- Testing of Safety Devices
  49
- Low Gas Pressure Fault Test
  49
- High Gas Pressure Test
  50
- Low Water Level Fault Test
  50
- Water Temperature Fault Test
  51
- Interlock Tests
  52
  - Remote Interlock
    52
  - Delayed Interlock
    53
- Flame Fault Tests
  53
- Air Flow Fault Tests
  54
- Ssov Proof of Closure Switch
  56
- Purge Switch Open During Purge
  56
- Ignition Switch Open During Ignition
  57
- Safety Pressure Relief Valve Test
  58
Chapter 6. Maintenance

59
- Maintenance Schedule
  59
- Igniter-Injector
  60
- Flame Detector
  61
- Combustion Calibration
  62
- Safety Device Testing
  62
- Fireside Inspection
  62
- Waterside Inspection
  65
- Heat Exchanger Cleaning
  67
- Condensate Drain Trap
  69
- Air Filter Replacement
  70
- Shutting the Water Heater down for an Extended Period of Time
  71
- Placing the Heater Back in Service after a Prolonged Shutdown
  71
Chapter 7. Troubleshooting Guide

73
- Introduction
  73
- Additional Faults Without Specific Fault Messages
  84
Chapter 8. Rs232 Communication

87
- Introduction
  87
- Rs232 Communication Setup
  87
- Menu Processing Utilizing Rs232 Communication
  87
- Data Logging
  88
  - Fault Log
    88
  - Operation Time Log
    89
  - Sensor Log
    89
Appendix A: Water Heater Menu Item Descriptions

91
Appendix B: Startup, Status and Fault Messages

95
Appendix C 99Temperature Sensor Resistance/Voltage Chart

99
Appendix D: Water Heater Default Settings

101
Appendix E: Parts List Drawings

103
Appendix F: Piping Drawings

113
Appendix G: C-More Control Panel Views

127
Appendix H: C-More Wiring Diagrams

129
Appendix I: Recommended Spares

137
Appendix J: Gf-5030: Gas Components & Supply Design Guide

139
- Gas Pressure Requirements
  143
- Gas Piping
  145
Appendix K: Gf-5050: Venting & Combustion Air Guide

151
- Combustion Air System
  158
- Vent System
  165
Appendix L: Gf-5060: Electrical Power Guide

175
Appendix M: Gf-5080: Commercial Laundry Sizing Guide

183
Appendix N: Limited Warranty

195
- AERCO International, Inc. · 100 Oritani Dr. · Blauvelt, NY 10913 · Ph: 800-526-0288
  200

Aerco INNOVATION INN1060 Electrical Manual (5 pages)

Natural Gas Modulating Condensing Hot Water Boiler

Brand: Aerco | Category: Boiler | Size: 0 MB

General
2
Hot Water Boiler Electrical Requirements
2
Unit Wiring
4
Provisions for Service
4
Multiple Unit Wiring
4
Change Log
5

Aerco Categories

Boiler Water Heater Tools Heater Controller

More Aerco Manuals

Aerco INNOVATION INN1060 Manuals

Aerco INNOVATION INN1060 User Manual (206 pages)

Table of Contents

Foreword

Chapter 1. Safety Precautions

Chapter 2. Installation

Chapter 3. Operation

Chapter 4. Initial Start-Up

Chapter 5. Safety Device Testing

Chapter 6. Maintenance

Chapter 7. Troubleshooting Guide

Chapter 8. Water Heater Management

Appendix A - Innovation Menu Item Descriptions

Appendix B - Startup, Status and Fault Messages

Appendix C - Temperature Sensor Resistance/Voltage Chart

Appendix D - Dimensional Drawings

Appendix E - Parts List Drawings

Appendix F - Piping Drawings

Appendix G - C-More Control Panel Views

Appendix H - C-More Wiring Diagrams

Appendix I - Recommended Spares

Appendix J - Combustion Calibration (Korea Only)

Appendix K - Warranty

Aerco INNOVATION INN1060 User Manual (190 pages)

Table of Contents

Table of Contents

Foreword

Chapter 1 Safety Precautions

Chapter 2 Installation

Chapter 3 Operation

Chapter 4 Initial Start-Up

Chapter 5 Safety Device Testing

Chapter 6 Maintenance

Chapter 7 Troubleshooting Guide

Chapter 8 Rs232 Communication

Chapter 9 Water Heater Management

Appendix A: Innovation Menu Item Descriptions

Appendix B: Startup, Status and Fault Messages

Appendix C: Temperature Sensor Resistance/Voltage Chart

Temperature Sensor Resistance/Voltage Chart

Appendix D: Innovation Default Settings

Appendix E: Parts List Drawings

Appendix F: Piping Drawings

Appendix G: C-More Control Panel Views

Appendix H: C-More Wiring Diagrams

Appendix I: Recommended Spares

Appendix J: Combustion Calibration (Korea Only)

Appendix K: Warranty

Aerco INNOVATION INN1060 User Manual (200 pages)

Table of Contents

Chapter 1. Safety Precautions

Chapter 2. Installation

Chapter 3. Operation

Chapter 4. Initial Start-Up

Chapter 5. Safety Device Testing

Chapter 6. Maintenance

Chapter 7. Troubleshooting Guide

Chapter 8. Rs232 Communication

Appendix A: Water Heater Menu Item Descriptions

Appendix B: Startup, Status and Fault Messages

Appendix C 99Temperature Sensor Resistance/Voltage Chart

Appendix D: Water Heater Default Settings

Appendix E: Parts List Drawings

Appendix F: Piping Drawings

Appendix G: C-More Control Panel Views

Appendix H: C-More Wiring Diagrams

Appendix I: Recommended Spares

Appendix J: Gf-5030: Gas Components & Supply Design Guide

Appendix K: Gf-5050: Venting & Combustion Air Guide

Appendix L: Gf-5060: Electrical Power Guide

Appendix M: Gf-5080: Commercial Laundry Sizing Guide

Appendix N: Limited Warranty

Aerco INNOVATION INN1060 Electrical Manual (5 pages)

Table of Contents

Related Products

Aerco Categories