Page 1
PCGA-CRWD1 SERVICE MANUAL For American Area US Model Canadian Model Ver 1-2001J All the supplementary information are attached at the end of data files. Update List S400 Lineup : PCGA-CRWD1 CD-RW/DVD-ROM DRIVE 9-872-273-01...
Page 2
Caution Markings for Lithium/Ion Battery - The following or similar texts shall be provided on battery pack of equipment or in both the Sony and VAIO are trademarks of Sony. Intel logo and Intel Inside operating and the service instructions.
CHAPTER 1. REMOVAL 1-1. Flowchart FLEXIBLE CABINET BEZEL PLATE IFX-170 CABINET COMBINATION POWER FLAT (UPPER) (COM) (LOWER) SHIELD DRIVE BOARD CABLE ASSY ASSY P 1-2 P 1-3 P 1-1 P 1-2 P 1-2 P 1-3 P 1-3 SUPPORT PC BOARD P 1-3 REINFORCEMENT P 1-3...
2. Plate Shield 1Screws (P2X2.5) (X2) (Silver) 2Screws (P2X2.5) (X2) 3Plate Shield (Silver) When attaching the spacer, protrude the spacer exceeding the outer edge of plate shield by 1mm. 4Spacer 3. IFX-170 Board 2Screws (P2X2.5) (X2) (Silver) 1Sheet When attaching the sheet, align the sheet 4IFX-170 Board with the corner of the combinaton drive.
CHAPTER 2. SELF DIAGNOSTICS ATTENTION Please confirm “Self Diagnostics” method which will be informed you with distribution of “Self Diagnostics” software. Confidential PCGA-CRWD1 (AM) (END)
3-2. Frame Harness Diagram DC IN 10V DC IN i.link Combination DRIVE IFX-170 Board CN200 IFX-174 Board (Side A) (Side A) CN201 From board to connector (direct connection) Harness (connector at both end) Harness (soldered at one end) Connectors soldered on board and appearing on the panel Confidential PCGA-CRWD1 (AM) (END)
Page 14
LTC1735CGN#TR (LINEAR TECHNOLOGY) MD8408B (FUJIFILM MICRODEVICES) HIGH EFFICIENCY SYNCHRONOUS STEP-DOWN IEEE 1394 PHYSICAL LAYER IC SWITCHING REGULATOR – TOP VIEW – – TOP VIEW – RUN/SS BOOST SGND INTV OSENSE – SENSE PGND SENSE EXTV PIN FUNCTIONS (Pin 1): External capacitor C from this pin to EXTV (Pin 9): Input to the Internal Switch Connected to...
Page 15
RN5RF33AA-TR (RICOH) LOW RIPPLE REGULATOR WITH TRANSISTOR CONNECTED EXTERNALLY – TOP VIEW – RN5VD16AA-TL (RICOH) CMOS VOLTAGE DETECTOR – TOP VIEW – Confidential PCGA-CRWD1 (AM)
Page 17
Pin Function Signal Name PIN I/O Reset Description C33 External Interface (HVDD) The control signal with which "X" was attached to the head of a signal name is low active. (X2SPD 89 P07 I/O Port 07 is removed.) 90 P06 I/O Port 06 91 P05 I/O Port 05...
Page 23
IFX-170 (2/3) • NOTE : Location Schematic Diagram Sheet Number DNI=Do Not Install Confidential 4-15 4-16 PCGA-CRWD1 (AM)
Page 24
IFX-170 (3/3) • NOTE : The components identified by mark 0 or dotted Location line with mark 0 are critical for safety. Schematic Diagram Sheet Number Replace only with part number specified. DNI=Do Not Install Confidential PCGA-CRWD1 (AM) 4-17 4-18...
Page 25
IFX-170 Signal Cross Reference • NOTE : Location Schematic Diagram Sheet Number DNI=Do Not Install Confidential 4-19 4-20 PCGA-CRWD1 (AM)
Page 26
IFX-170 Unit Cross-Reference • NOTE : Location Schematic Diagram Sheet Number DNI=Do Not Install Confidential PCGA-CRWD1 (AM) 4-21 4-22...
Page 27
IFX-170 A side B side Confidential 4-23 4-24 PCGA-CRWD1 (AM)
IFX-174 Parts Location Index 2. IFX-174 Board Parts Location Index X-cordinate Y-cordinate Schematic Ref. No. A/B Value Rating Tol. Part No. Description Notes Value Value Diagram Address CN400 16.375 7.55 179303211 CONNECTOR 50P CN401 16.375 181610521 CONNECTOR, BOARD TO BOARD 50P 177425421 CONNECTOR, BOARD TO BOARD 50P Alt.CN401 •...
Page 30
IFX-174 (2/2) • NOTE : Location Schematic Diagram Sheet Number DNI=Do Not Install Confidential PCGA-CRWD1 (AM) 4-29 4-30...
Page 31
IFX-174 Unit Cross Reference • NOTE : Location Schematic Diagram Sheet Number DNI=Do Not Install A side B side Confidential 4-31 4-32 PCGA-CRWD1 (AM) (END)
CHAPTER 5. EXPLODED VIEWS AND PARTS LIST Ref.No. Part No. Description Ref.No. Part No. Description X-4624-072-1 BEZEL (COM) ASSY ACCESSORY 1-796-072-21 COMBO DRIVE (UJDA710) ********* 4-657-336-01 REINFORCEMENT 0800 4-657-338-01 SUPPORT, PC BOARD 1-476-940-11 ADAPTOR, AC NOTE: 0801 A-8067-015-A IFX-174 MOUNTED PWB 1-757-562-31 CORD, POWER The components identified by mark 0 or •...