Related Manuals for Sailfish 320 CC
Summary of Contents for Sailfish 320 CC
- Page 1 Title Sailfish 320 CC Demand T h e Dif fer e nc e Sailfish 320 CC Owner’s Manual 10/15/2014 Sailfish 290CC Owner’s Manual | sailfishboats.com 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com...
-
Page 2: Table Of Contents
14. Console / Head Area 39. Caring for Aluminum 15. VSR Battery System 40. Caring for Stainless Steel 16. Bilge Access and Explanation 41. Windshield, Window and Hatch Care Instructions 17. Bilge Pumps 42. Gel Coat 18. Raw Water Washdown System 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 3: Specifications
Sailfish 320 CC Specifications SPECIFICATIONS Gallon Livewell, Backrest Rod Holders, • 10 Micron Yamaha Fuel Filter / Water Ladder Back Tops Only) Footrest & 2 Drawer Storage Separator (Yamaha Only) • Outriggers For T-Top & Hard Tops LOA Hull Only ........ 31’ 6” • Bow Cushion Back Rest Bolsters • NBT Vinyl Protection (Stain Resistant, • Misting System (Hard Tops Only) Length Rigged ........ 34’ 0” Mildew Inhibitor, UV Protector • Deluxe Hard Top w/ LED Spreader Beam ..........10’ 0” Storage • 6 Standard Hull Colors Overhead, Docking Lights & Rod Fuel Capacity ....... 284 Gallons • Anchor Locker - Finished Fiberglass w/ • T-Top w/ LED Spreader Lights / LED... -
Page 4: Trailer Measurement Chart
Sailfish Boat Trailer Measurement Chart Boat Models 208 CC 78 in. 53 in. 28 in. 11 in. 82 in. 218 in. 235 in. 27 in. 1900 BB 88 in. 66 in. 37 in. 10.5 in. 99.5 in. 198 in. 217 in. -
Page 5: Boat Layout
Sailfish 320 CC Boat Layout Description Description Boarding Ladder / Fresh Water Fill Fuel Fill 30 Gallon Livewell Console and Head Area Bilge Access Floor Storage In Floor Fish Box Insulated Fish Boxes Built-in Rod and Tackle Storage Bow Storage... -
Page 6: Battery Selector Panel And Wiring
Battery Selector Panel and Wiring Front View Back View With Wiring 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 7: Breaker Panel Schematic
Breaker Panel Schematic 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 8: Switch Panel Schematic
Switch Panel Schematic 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 9: Fuel System Layout
Fuel System Layout Description Fuel Filter Access - Yamaha Only Fuel Fill Fuel Tank Location Fuel Pickups Fuel Sender Primer Bulbs - Yamaha Only 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 10: Plumbing Diagram
Sailfish 320 CC - Plumbing Diagram 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 11: Helm Area
Helm Area Description Compass Optional Garmin Unit Switch Panel Optional Fusion Stereo Brand Specific Motor Guages Trim Tab Actuator Switches Binnacle (Shown with Twin Engines) 12 Volt Receptacle Inside Storage Pocket Uflex Tilt Helm Ignition Switches Optional Windlass 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 12: Uflex Steering System
Sailfish 320 CC UFLEX Steering System UFLEX has been the choice for steering for Sailfish boats for the last three years because of the quality of the USA built products. Every helm comes standard with a full stainless steel shaft; cylinders are built with carbon steel pistons, coupled with extra-large end caps to prevent leakage. -
Page 13: Ignition Switches, Engine Shut-Off Cord/Lanyard
Sailfish 320 CC Ignition Switches, Engine Shut-off Cord/Lanyard Each Sailfish boat will be equipped with a Yama- ha or Mercury ignition switch with an emergency engine shut off cord/lanyard. This lanyard should be worn at all times while operating the vessel, if the vessel operator falls... -
Page 14: Plug And Play Wiring
Fuel-Water Separator - Yamaha All Sailfish Boats Rigged with Yamaha motors are factory installed with 10 Micron Yamaha fuel water separators. Each engine will have its own filter. These filters can be accessed in the bilge access door located at the aft of the boat. -
Page 15: Console/Head Area
Console/Head Area Description Large panel for easy access to Console Components Breaker Panel Battery Selector Panel Battery Storage and Access Hatch 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 16: Vsr Battery System
The other battery is used for other operations. As the fisherman runs the boat from hole to hole, the engine alternator elevates the voltage to the cranking battery above 13.7 volts. This triggers the VSR to automatically connect the starting 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 17: Bilge Access And Explanation
This large door allows easy access too many of the boats components. You may also access it through the two access plates in the splash-well. The bilge area of your sailfish boat should be checked before, during and after each operation. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 18: Bilge Pumps
Sailfish 320 CC Bilge Pumps All Sailfish Boats are furnished with Rule Bilge Pumps, The Rule 2000 GPH (gallon per hour) pump has a built in automatic float switch. This is engaged when the water level rises in the bilge and the float rises in the pump causing the pump to turn on. -
Page 19: Raw Water Washdown System
Sailfish 320 CC Raw water Washdown system The raw water wash down on your Sailfish Boat is powered by a Shur-flo Pro Blaster Pump which creates a pressur- ized system, once the pump is turned on and pressure is created the pump will shut down until more pressure is needed. -
Page 20: Freshwater Washdown And Shower System
Freshwater Washdown and Shower System The freshwater washdown and shower system on your Sailfish Boat is powered by a Shur-flo Pro Blaster Pump which creates a pressurized system, once the pump is turned on and pressure is created throughout the freshwater hoses;... -
Page 21: Livewell Operation
The livewell will fill up until it reaches the Overflow built into the side of the livewell. This allows the water to continually pump in and drain out while maintaining the water level. • To drain the livewell open the red handle ball valve. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 22: Fishbox Pump
Fishbox Pump The 320 CC is equipped with a diaphragm pump called the gulper grouper (pictured to the right). The Whale Gulper Grouper pump has no impeller to clog or burn out. Unlike impeller pumps these have no-choke valves that easily pump out fish box waste. -
Page 23: Console Top Organizer
Sailfish 320 CC Console Top Organizer Standard on the 290CC and 320CC the console top orga- nizer is a great place to store almost anything. It also includes a 12 Volt plug, MP3/USB hook up, and a headphone jack for playing music from a phone or I-pod. -
Page 24: Trim Tab Maintenance
CLEAN THE TRIM TAB BLADES. • Periodically test system for smooth MARYKATE’S ON & OFF PRODUCT operation. IS A GOOD CHOICE. RINSE THOR- OUGHLY UPON COMPLETION. BIODEGRADABLE, BUT PLEASE FOLLOW THE MANUFACTURER’S INSTRUCTIONS BEFORE APPLYING. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 25: Optional Lewmar V-700 Windlass
• The Gypsy should be examined on a reg- ular basis, because it is a high wear item. The Gypsy is designed for short scopes of chain and will last longer if properly used. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 26: Lewmar Windlass Troubleshooting Chart
Is the voltage low? (Below 11.0V on a 12V system? isolation switch or solenoid. (Feel them to see if they are heating up). Is the voltage correct? (Above 11.0V and anchor is not fouled). The motor is defective. Replace the motor. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 27: Optional Acrylic Enclosure
4. Crazing: This is when the acrylic glints as you go towards the sun. It is microcracking and is usually caused by chemicals. Chief among them is the use of glass-cleaning liquids that contain ammonia. Crazing is also caused by petroleum products such as fuels, paint solvents or acetone. If the boat has a cover be sure to provide some ventilation since fuel vapors attack acrylics. Crazing is not repairable. Acrylic Enclosure optional on 270CC - 320CC (as shown on 270CC above) 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 28: Optional Hard Tops
Optional Hard Top Description Anchor Light The optional hard top is equipped with courtesy lights, spreader lights, Spreader Lights docking lights, an anchor light , two speakers and an overhead storage box. Courtesy Lights Switch Panel Overhead Storage Box 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... - Page 29 Optional Hard Top Description The optional hard top is equipped with courtesy lights, spreader lights, docking lights, an anchor light , two speakers and an overhead storage box. Courtesy Lights Docking Lights 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com...
-
Page 30: Optional Marine Head With Waste Tank
Optional Marine Head with Waste Tank Type III MSD Waste Management System 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 31: Msd Waste Management System
Optional Marine Head with Waste Tank Type III MSD Waste Management System Description Battery Fuse Waste Management System Master Switch Controller for Waste Management System Description Vent Inlet Toilet Deck Pumpout Waste Holding Tank Vertical Loop Outlet 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 32: Msd Waste Management System
When Storing the system for more than two weeks, thor- tissues especially designed to disintegrate rapidly (unlike household oughly clean toilet and hoses by flushing with Thetford’s tissues), such as Thetford’s Aqua-Soft (2ply) and RV/Marine Toilet Aqua-Kem, EcoSmart or Aqua-Clean. Tissue (1ply). 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 33: Msd Waste Management System
Discharge hose from macerator pump is Water is siphoning out of bowl due to Bowl drains dry after flush pulled down. Straighten hose so that top of discharge hose pulled down. discharge hose is in line with toilet nozzle Note: This Troubleshooting guide is intended to provide a basic service aid in the case of incorrect toilet operation. If the suggested actions above do not resolve the issue, it may be necessary to bring unit in for professional service. Thetford Customer Service – 1-800-521-3032. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 34: Msd Waste Management System
7/8 full or after the pump is set to run, the pump will shut down and indi- greater. cate a fault check pump and plumbing for a blockage. Empty Button: This button needs to be pressed and held for 3 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 35: Msd Waste Management System
• 1 x 1” Overboard discharge port macerator pump out. Dis- the dash in the first panel charge: connect to the overboard discharge thru-hull fitting. coming off the bus bar, * See plumbing diagram for recommended installation. pictured to the left. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 36: Optional Porta Potti
RV Dealer. Thetford SupremeGreen NEVER use scouring powders, For warranty issues or more infor- Thetford Aqua-Kem acids or concentrated cleaners, mation, call Thetford’s Customer Thetford Campa-Chem which can damage plastic parts Relations Department: 1-800-521-3032. and rubber seals. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... - Page 37 RV Dealer. Thetford SupremeGreen NEVER use scouring powders, For warranty issues or more infor- Thetford Aqua-Kem acids or concentrated cleaners, mation, call Thetford’s Customer Thetford Campa-Chem which can damage plastic parts Relations Department: 1-800-521-3032. and rubber seals. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com...
-
Page 38: Vinyl Care And Cleaning
Dry cleaning fluids and lacquer solvents should not be used as they will remove printed pattern and gloss. Waxes should be used with caution as many contain dyes or solvents that can permanently damage the protective coating. *Suntan lotion, tree pollen, wet leaves, and some other products can contain dyes that stain permanently. *Always Remove Stains Immediately! 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 39: Aluminum Cosmetic Corrosion (Pitting)
Concentrated alkaline based solutions. formed at local shipyards and dry Many concentrated soaps fall into this docks. category. Be aware of local sources that Chlorine, sulfurs, solvents and ammonia can expose your new boat to based products. corrosive chemicals. 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 40: Caring For Aluminum
Below are some metal protection products that are readily available at marine retailers. Woody Wax Woody Wax CPR woody-wax.com 800-619-4363 PMS Products, Inc. Boeshield T-9 boeshield.com 800-962-1732 Aquatech Premier Polish aquatech-marine.com 800-853-7760 Lear Chemical Corrosion Block learchem.com 800-256-2548 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 41: Caring For Stainless Steel
Chro- makes it one of the highest average con- mium and Nickel alloys contained in the tent recycled construction materials on the material. 304 and 316 are the prominent planet. grades of Stainless Steel: 304 contains 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 42: Stainless Steel
Clean with fresh water periodically. purposes. denatured alcohol, clean water, or a Touch up scratches and areas where commercially available plastic polisher paint has chipped off with touch-up 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... -
Page 43: Gel Coat
After washing with a mild soap may occur. or detergent, give the surface a good 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com... - Page 44 To restore the gloss to the affected area, use a high-grade marine or automotive Apply the mixture to the pit, chip or gouge wax. with a single-edge razor blade, matching the surface and contour of the area being 01/20/2015 Sailfish 320 CC Owner’s Manual | sailfishboats.com...
Need help?
Do you have a question about the 320 CC and is the answer not in the manual?
Questions and answers