Related Manuals for Sailfish 240 CC
Summary of Contents for Sailfish 240 CC
- Page 1 Title Sailfish 240 CC Demand T h e Dif fer e nc e Sailfish 240 CC Owner’s Manual 10/15/2014 Sailfish 270CC Owner’s Manual | sailfishboats.com 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com...
-
Page 2: Table Of Contents
13. Fuel-Water Separator - Yamaha 36. Caring for Aluminum 14. Console / Head Area 37. Caring for Stainless Steel 15. VSR Battery System 38. Windshield, Window and Hatch Care Instructions 16. Bilge Access and Explanation 39. Gel Coat 17. Bilge Pumps 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... - Page 3 Sailfish 240 CC Specifications SPECIFICATIONS Seating OPTIONS Seating Options • Forward Helm Cooler Seat - • Rear Jump Seats - Removable LOA Hull Only ......23’ 6” Electrical Options Removable • Bow Cushions - Bottoms Length Rigged ......25’ 6” • Garmin Radar Cable - Installed • Captain’s Chairs w/ Removable • Bow Cushion Backrest Bolsters Beam ...........9’ 0” • Built-In Battery Charger Cushions (2) • Forward Facing Bow Backrests Fuel Capacity ....146 Gallons • Yamaha Command Link Plus • Bow Filler Cushion Fresh Water ......14 Gallons...
-
Page 4: Boat Trailer Measurement
Sailfish Boat Trailer Measurement Chart Boat Models 208 CC 78 in. 53 in. 28 in. 11 in. 82 in. 218 in. 235 in. 27 in. 1900 BB 88 in. 66 in. 37 in. 10.5 in. 99.5 in. 198 in. 217 in. -
Page 5: Boat Layout
Sailfish 240 CC Boat Layout Description Description Boarding Ladder / Fresh Water Fill Fuel FIll Bilge Access Console and Head Area Fuel Sender and Pick-Up Access Floor Storage Insulated Fish Boxes (Boxes drain 30 Gallon Livewell overboard) Leaning Post Anchor Locker... -
Page 6: Battery Selector Panel And Wiring
Battery Selector Panel and Wiring Front View Back View With Wiring 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 7: Breaker Panel Schematic
Breaker Panel Schematic 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 8: Switch Panel Schematic
Switch Panel Schematic 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 9: Fuel System Layout
Fuel System Layout Description Fuel Filter Access - Yamaha Only Fuel Fill Fuel Tank Location Fuel Pickups Fuel Sender Primer Bulbs - Yamaha Only 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 10: Plumbing Diagram
Plumbing Diagram 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 11: Helm Area
Helm Area Description Compass Switch Panel Optional Stereo Brand Specific Motor Guages Trim Tab Actuator Switches Binnacle (Shown with Twin Engines) 12 Volt Receptacle Inside Storage Pocket Uflex Tilt Helm Ignition Switches Optional Windlass 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 12: Uflex Steering System
Sailfish 240 CC UFLEX Steering System UFLEX has been the choice for steering for Sailfish boats for the last three years because of the quality of the USA built products. Every helm comes standard with a full stainless steel shaft; cylinders are built with carbon steel pistons, coupled with extra-large end caps to prevent leakage. -
Page 13: Ignition Switches, Engine Shut-Off Cord/Lanyard
Sailfish 240 CC Ignition Switches, Engine Shut-off Cord/Lanyard Each Sailfish boat will be equipped with a Yama- ha or Mercury ignition switch with an emergency engine shut off cord/lanyard. This lanyard should be worn at all times while operating the vessel, if the vessel operator falls... -
Page 14: Plug And Play Wiring
Fuel-Water Separator - Yamaha All Sailfish Boats Rigged with Yamaha motors are factory installed with 10 Micron Yamaha fuel water separators. Each engine will have its own filter. These filters can be accessed in the bilge access door located at the aft of the boat. -
Page 15: Console/Head Area
Console/Head Area Description Large panel for easy access to Console Components Breaker Panel Battery Selector Panel Battery Storage and Access Hatch 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 16: Vsr Battery System
The other battery is used for other operations. As the fisherman runs the boat from hole to hole, the engine alternator elevates the voltage to the cranking battery above 13.7 volts. This triggers the VSR to automatically connect the starting 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 17: Bilge Access And Explanation
This large door allows easy access too many of the boats components. You may also access it through the two access plates in the splash-well. The bilge area of your sailfish boat should be checked before, during and after each operation. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 18: Bilge Pumps
Sailfish boats 240CC and larger are equipped with a forward bilge pump that is an electronic sensor pump. These pumps have a state of the art internal water... -
Page 19: Raw Water Washdown System
Sailfish 240 CC Raw water Washdown system The raw water wash down on your Sailfish Boat is powered by a Shur-flo Pro Blaster Pump which creates a pressur- ized system, once the pump is turned on and pressure is created the pump will shut down until more pressure is needed. -
Page 20: Freshwater Washdown And Shower System
Freshwater Washdown and Shower System The freshwater washdown and shower system on your Sailfish Boat is powered by a Shur-flo Pro Blaster Pump which creates a pressurized system, once the pump is turned on and pressure is created throughout the freshwater hoses;... -
Page 21: Livewell Operation
The livewell will fill up until it reaches the Overflow built into the side of the livewell. This allows the water to continually pump in and drain out while maintaining the water level. • To drain the livewell open the red handle ball valve. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 22: Trim Tab Maintenance
CLEAN THE TRIM TAB BLADES. • Periodically test system for smooth MARYKATE’S ON & OFF PRODUCT operation. IS A GOOD CHOICE. RINSE THOR- OUGHLY UPON COMPLETION. BIODEGRADABLE, BUT PLEASE FOLLOW THE MANUFACTURER’S INSTRUCTIONS BEFORE APPLYING. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 23: Optional Hard Top
Optional Hard Top Description Spreader Lights Courtesy Lights Switch Panel Storage Box/E-Box 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 24: Optional Lewmar V-700 Windlass
• The Gypsy should be examined on a reg- ular basis, because it is a high wear item. The Gypsy is designed for short scopes of chain and will last longer if properly used. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... - Page 25 Sailfish 240 CC - Windlass Troubleshooting Chart Failure to Operate Troubleshoot Chart: Reversing Toggle Control Switch (Part No. 0052519) Is there voltage at the input terminal (positive) to the If no voltage is present, the battery isolation is OFF, the control switch? breaker is tripped or a fuse has blown.
-
Page 26: Optional Console Top Organizer
I-pod. Always store the organizer with the lid closed and the spring positioned as it is in the picture to the right. Description Lid Spring MP3/USB and Head- phone Jack 12 Volt Plug 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 27: Optional Marine Head With Waste Tank
Optional Marine Head with Waste Tank Type III MSD Waste Management System 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 28: Msd Waste Management System
Optional Marine Head with Waste Tank Type III MSD Waste Management System Description Battery Fuse Waste Management System Master Switch Controller for Waste Management System Description Vent Inlet Toilet Deck Pumpout Waste Holding Tank Vertical Loop Outlet 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 29: Msd Waste Management System
When Storing the system for more than two weeks, thor- tissues especially designed to disintegrate rapidly (unlike household oughly clean toilet and hoses by flushing with Thetford’s tissues), such as Thetford’s Aqua-Soft (2ply) and RV/Marine Toilet Aqua-Kem, EcoSmart or Aqua-Clean. Tissue (1ply). 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 30: Msd Waste Management System
Discharge hose from macerator pump is Water is siphoning out of bowl due to Bowl drains dry after flush pulled down. Straighten hose so that top of discharge hose pulled down. discharge hose is in line with toilet nozzle Note: This Troubleshooting guide is intended to provide a basic service aid in the case of incorrect toilet operation. If the suggested actions above do not resolve the issue, it may be necessary to bring unit in for professional service. Thetford Customer Service – 1-800-521-3032. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 31: Msd Waste Management System
7/8 full or after the pump is set to run, the pump will shut down and indi- greater. cate a fault check pump and plumbing for a blockage. Empty Button: This button needs to be pressed and held for 3 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 32: Msd Waste Management System
• 1 x 1” Overboard discharge port macerator pump out. Dis- the dash in the first panel charge: connect to the overboard discharge thru-hull fitting. coming off the bus bar, * See plumbing diagram for recommended installation. pictured to the left. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 33: Optional Porta Potti
RV Dealer. Thetford SupremeGreen NEVER use scouring powders, For warranty issues or more infor- Thetford Aqua-Kem acids or concentrated cleaners, mation, call Thetford’s Customer Thetford Campa-Chem which can damage plastic parts Relations Department: 1-800-521-3032. and rubber seals. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... - Page 34 RV Dealer. Thetford SupremeGreen NEVER use scouring powders, For warranty issues or more infor- Thetford Aqua-Kem acids or concentrated cleaners, mation, call Thetford’s Customer Thetford Campa-Chem which can damage plastic parts Relations Department: 1-800-521-3032. and rubber seals. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com...
- Page 35 Sailfish Boats Marine Vinyl Cleaning Steps What is NBT™? 1. Apply soap and water with a cloth/sponge, rinse clean Nano-Block Technology™ (NBT™) is the most exclusive with water – dry with clean cloth. vinyl product available today in the Marine Manufacturing Industry! NBT™...
-
Page 36: Aluminum Cosmetic Corrosion (Pitting)
Concentrated alkaline based solutions. formed at local shipyards and dry Many concentrated soaps fall into this docks. category. Be aware of local sources that Chlorine, sulfurs, solvents and ammonia can expose your new boat to based products. corrosive chemicals. 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 37: Caring For Aluminum
Below are some metal protection products that are readily available at marine retailers. Woody Wax Woody Wax CPR woody-wax.com 800-619-4363 PMS Products, Inc. Boeshield T-9 boeshield.com 800-962-1732 Aquatech Premier Polish aquatech-marine.com 800-853-7760 Lear Chemical Corrosion Block learchem.com 800-256-2548 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 38: Caring For Stainless Steel
The grade of Stainless Steel is primarily Stainless Steel typically has a recycled determined by the amount of the Chro- content of between 65% & 80% which mium and Nickel alloys contained in the makes it one of the highest average con- 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 39: Stainless Steel
Clean with fresh water periodically. purposes. denatured alcohol, clean water, or a Touch up scratches and areas where commercially available plastic polisher paint has chipped off with touch-up 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... -
Page 40: Gel Coat
After washing with a mild soap may occur. or detergent, give the surface a good 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com... - Page 41 To restore the gloss to the affected area, use a high-grade marine or automotive Apply the mixture to the pit, chip or gouge wax. with a single-edge razor blade, matching the surface and contour of the area being 02/23/2015 Sailfish 240 CC Owner’s Manual | sailfishboats.com...