Hoshizaki FM-150KE Instruction Manual
Hoshizaki FM-150KE Instruction Manual

Hoshizaki FM-150KE Instruction Manual

Self-contained ice maker
Hide thumbs Also See for FM-150KE:

Advertisement

SELF-CONTAINED ICE MAKER
FM-150KE
FM-150KE-N
FM-150KE-50
FM-150KE-50-N
FM-120KE
FM-80KE
INSTRUCTION MANUAL
FM-80KE-N
L1F080111 (093014)

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the FM-150KE and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Hoshizaki FM-150KE

  • Page 1 SELF-CONTAINED ICE MAKER FM-150KE FM-150KE-N FM-150KE-50 FM-150KE-50-N FM-120KE FM-80KE INSTRUCTION MANUAL FM-80KE-N L1F080111 (093014)
  • Page 2: Table Of Contents

    ENGLISH IMPORTANT SAFETY INFORMATION ....................1 I. INSTALLATION INSTRUCTIONS ......................2 1. CONSTRUCTION .........................2 2. ACCESSORIES ..........................2 3. UNPACKING ..........................2 4. LOCATION ...........................3 5. INSTALLATION ..........................3 6. ELECTRICAL CONNECTIONS ....................3 7. WATER SUPPLY AND DRAIN CONNECTIONS .................4 II. OPERATING INSTRUCTIONS ......................5 1. START UP ............................5 2.
  • Page 3: English Important Safety Information

    ENGLISH IMPORTANT SAFETY INFORMATION Throughout this manual, notices appear to bring your attention to situations which could result in death, serious injury, or damage to the unit. Indicates a hazardous situation which, if not avoided, could result in death or WARNING serious injury.
  • Page 4: Installation Instructions

    ENGLISH I. INSTALLATION INSTRUCTIONS 1. CONSTRUCTION Top Panel Storage Bin Operation Panel Door Front Panel (Left) Louver Air Filter Front Cover 2. ACCESSORIES Scoop Power Supply Cord Scoop Power Supply Cord Adjustable Leg Connector Cover Braided SS Inlet Hose Outlet Hose Dual Check Valve Braided SS Outlet Hose...
  • Page 5: Location

    * The service of a licensed electrician may be required to ensure the installation is in accordance with the local codes and regulations. * If the supply cord is damaged, it must be replaced by a replacement cord available from Hoshizaki Parts/Service Centres.
  • Page 6: Water Supply And Drain Connections

    Contact your Tap Washer local water treatment professional or Hoshizaki service agent. * Water supply pressure should be minimum 0.05 MPa (0.5 bar) and maximum 0.8 MPa (8 bar). If the pressure exceeds 0.8 MPa (8 bar), use a proper pressure Braided SS reducing valve.
  • Page 7: Operating Instructions

    ENGLISH * Drain lines should not be installed directly to the sewer system. A vertical air gap of a minimum of 5 cm should be between the end of the drain hoses from the icemaker and the floor drain. 5cm air gap * To prevent a backflow into the storage bin, the outlet hose must be laid as shown. GOOD Floor Upgrade Downgrade Drain II. OPERATING INSTRUCTIONS CAUTION Do not step into the storage bin, or put your hands into the machine compartment inside the storage bin.
  • Page 8: Preparing The Icemaker For Long Storage

    1) Either mix 1 litre of water with 4 ml of 5.25% sodium hypochlorite solution in a suitable container, or the recommended Hoshizaki sanitiser as directed. 2) Soak the scoop in the solution for more than 3 minutes. Rinse thoroughly, and shake to remove surplus liquid.
  • Page 9: Inspection And Maintenance

    Replacement of these parts is required if wear exceeds factory recommendations. Their service life, however, depends on water quality and environment. More frequent inspection and maintenance are recommended in bad or severe water conditions. Consult with your local Hoshizaki service agent about inspection and maintenance service.
  • Page 10: Before Calling For Service

    * The power is supplied to the unit. * The water is turned on. * The air filter is clean. For further assistance or advice, contact your local Hoshizaki service agent. 4. DISPOSAL Comply with local regulations regarding disposal of this appliance and its refrigerant gas. Before you scrap the appliance, take off the door to prevent children trapped.
  • Page 11: Warranty

    5. WARRANTY Hoshizaki warrants to the original owner/user that all Hoshizaki branded products shall be free of defects in material and/or workmanship for the duration of the “warranty period”. The warranty shall be effective for two years from the date of installation.
  • Page 12 This product meets the essential health and safety requirements demanded by the following regulations: EMC Directive (2004/108/EC) Low Voltage Directive (2006/95/EC) RoHS Directive (2011/65/EU) Food Contact Materials Regulation (EC 1935/2004) Manufacturer: Hoshizaki Europe Ltd. Telford 70 Stafford Park 7, Telford, Shropshire TF3 3BQ England...

Table of Contents