Trouble-Shooting - Factory Cat 34 Operating Instructions Manual

PROBLEM
No power - Nothing operates
Main Broom does not sweep
Clutch Drive does not operate
Poor Dust Control
Poor Sweeping quality
Main Broom noisy / bounces
Tires noisy / Poor traction
Low run time
- 20 -

TROUBLE-SHOOTING

CAUSE
Faulty Power Switch
Batteries need charging
Faulty Batteries
Loose Battery Cable
Main Broom is not down
Carbon Brushes worn
Hood Safety Switch not depressed
Defective Relay
Fault Motor or Wires
Inspect the Clutch Donut
Faulty Drive Motor
Faulty Wiring
Filter clogged
Hopper Gasket faulty
Hopper full
Faulty Vacuum fan
Battery Charge is low
Wet Sweep By-pass Door is open
Main Broom worn out
Debris stuck to Main Broom
Broken Main Broom belt
Broken Jackshaft belt
Main Broom Belt fell off
Jackshaft Belt fell off
Battery charge is low
Broom has fl at spots
Debris stuck in Main Broom
Main Broom out of round
Debris stuck in Main Broom belt
Rear Tires loose
Worn Front Drive Tire
Batteries run down
Batteries still down
Batteries low on Water
Batteries over cycled
SOLUTION
Contact Local Servicing Dealer
See CHARGING BATTERIES
Replace Battery
Tighten loose cable
Slide Main Broom Lever to the down
position
Contact Local Servicing Dealer
Check Safety Switch
Check Relay
Contact Local Servicing Dealer
Contact Local Servicing Dealer
Contact Local Servicing Dealer
Contact Local Servicing Dealer
Turn Filter Shaker for 20 seconds
Replace Gasket
Empty Hopper
Contact Local Servicing Dealer
Fully charge batteries
Close By-pass Door
Replace Main Broom
Remove debris
Replace Belt
Replace Belt
Reinstall Belt
Reinstall Belt
Fully charge Batteries
Replace Broom
Remove debris
Replace Main Broom
Remove debris
Tighten Lug Nuts
Contact Local Servicing Dealer
Contact Local Servicing Dealer
Contact Local Servicing Dealer
See Battery Maintenance
Contact Local Servicing Dealer
34-OP-EN