Table of Contents
Advertisement
Quick Links
Download this manual
See also:
Operator's Manual
Operator's Manual
Manual del operador
Manuel de l'utilisateur
U.S. Patent No. 6,760,947; No. 6,105,192; No. 6,493,896 (Deluxe Machines); & Patent Pending
READ THIS BOOK
This book has important information for the use and safe operation of this machine. Failure to read this
book prior to operating or attempting any service or maintenance procedure to your Clarke machine could
result in injury to you or to other personnel; damage to the machine or to other property could occur as
well. You must have training in the operation of this machine before using it. If your operator(s) cannot
read English, have this manual explained fully before attempting to operate this machine.
Si Ud. o sus operadores no pueden leer el Inglés, se hagan explicar este manual completamente antes
de tratar el manejo o servicio de esta máquina.
All directions given in this book are as seen from the operator's position at the rear of the machine.
For new books write to: Clarke
Form No. 70851A 4/06
Order Parts Here:
www.ivie-ent.com/parts
Ph:(918)254-5161
®
, 2100 Highway 265, Springdale, Arkansas 72764.
Clarke
®
S28 / L28 WB
S33 / L33 WB
S38 / L38 WB
Printed in the U.S.A.
Advertisement
Table of Contents
Related Manuals for Clarke Focus S28 WB
Summary of Contents for Clarke Focus S28 WB
- Page 1 This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well.
- Page 2 Este manual contiene información importante acerca del uso y la seguridad de la máquina. Si no lee el manual antes de utilizar su máquina Clarke o de intentar realizar los procedimientos de reparación o mantenimiento de la misma, usted o el resto del personal podrían sufrir lesiones; asimismo, podrían producirse daños a la máquina o a otras propiedades.
-
Page 3: Table Of Contents
Electrical Plate Connection Diagram L28/L33/L38 ..................99 Control Housing Connection Diagram ......................100 Electrical Schematic S28/S33/S38 ........................101 Electrical Schematic (Top) L28/L33/L38 ......................102 Electrical Schematic (Bottom) L28/L33/L38 ....................103 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 3 -... - Page 4 Diagrama de conexión de la placa eléctrica L28/L33/L38 ................99 Diagrama de conexión del alojamiento de controles ..................100 Esquemas eléctricos S28/S33/S38 ........................ 101 Esquemas eléctricos (parte superior) L28/L33/L38 ..................102 Esquemas eléctricos (parte inferior) L28/L33/L38 ..................103 ® Clarke Page Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 5 Schéma de connexion du boîtier de commandes ..................100 Schéma du circuit électrique (modèles S28/S33/S38) ................... 101 Schéma du circuit électrique (haut) des modèles L28/L33/L38 ..............102 Schéma du circuit électrique (bas) des modèles L28/L33/L38 ..............103 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 5 -...
-
Page 6: Operator Safety Instructions
La non-lecture et le non-respect des MISES EN GARDE risquent d’endommager la machine ou de provoquer d’autres dégâts matériels. Lisez et respectez toutes les MISES EN GARDE se trouvant dans le Manuel de l’utilisateur et sur la machine. Clarke ® Page Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 7 Failure to read the Owner's Manual prior to operating or attempting any service or maintenance procedure to your Clarke machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well. You must have training in the operation of this machine before using it.
- Page 8 N’arrêtez et ne sationner cette machine que sur une surface plane. Lorsque vous arrêtez la machine, mettez le commutateur à clé en position « OFF ». Enclenchez le frein de stationnement. ® Clarke Page Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 9 Assurez-vous que tous les autocollants de sécurité et toutes les instructions sont présentes et visibles sur la machine. Vous pouvez obtenir des autocollants et des plaques de rechange auprès de votre revendeur Clarke. WARNING: Wet floor surfaces can be slippery.
- Page 10 Your machine warranty will be voided if anything other than genuine Clarke parts are used on your machine. Always use Clarke parts for replacement. PRECAUCIÓN: Si no utiliza los repuestos originales de Clarke la garantía de la máquina se anulará. Utilice siempre repuestos de Clarke.
-
Page 11: Introduction
Introducción Introducción: Los nuevos modelos de fregadora automática Focus 38, 33 y 28 de Clarke son máquinas efectivas y de calidad superior para la limpieza de pisos. El modelo Focus 38 utiliza dos cepillos o almohadillas para limpiar un recorrido de 38 pulgadas de ancho. El modelo Focus 33 utiliza dos cepillos o almohadillas para limpiar un recorrido de 33 pulgadas de ancho. -
Page 12: Machine Specifications
1005 lbs. 456kg Shipping Weight 1328 lbs. 602kg 1318 lbs. 598kg 1308 lbs. 593kg w/batteries (330AH) Noise 76.5 dBA 76.5 dBA 76.5 dBA Vibration <2.5 m/s <2.5 m/s <2.5 m/s ® Clarke Page -12- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 13 Peso de envío 1328 lbs. 602kg 1318 lbs. 598kg 1308 lbs. 593kg con baterías (330AH) Ruido 76.5 dBA 76.5 dBA 76.5 dBA Vibraciones <2.5 m/s <2.5 m/s <2.5 m/s Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 13 -...
-
Page 14: Caractéristiques De La Machine
456 kg Poids à l’expédition 602 kg 598 kg 593 kg avec batteries (330 Ah) Niveau sonore 76.5 dBA 76.5 dBA 76.5 dBA Vibration <2.5 m/s <2.5 m/s <2.5 m/s ® Clarke Page -14- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 15: Procedures For Transporting
9. Replace squeegee assembly, brush housings, & brushes or pad drivers after the machine is unloaded and ready to use. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 16 9. Vuelva a colocar el montaje de la escobilla de goma, los alojamientos de los cepillos y los cepillos o impulsores de almohadillas una vez que la máquina haya sido descargada y esté lista para usar. ® Clarke Page -16-...
-
Page 17: Procédures De Transport
9. Remettez en place la raclette, les protections des brosses, les brosses ou les entraîneurs de disque une fois la machine déchargée et prête à être utilisée. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 17 -... -
Page 18: Symbols Used On S28, S33, S38
SYMBOLS USED ON FOCUS S28, S33, & S38 Hazard Alert Symbol Additional Brush Pressure On/Off Key Switch Charge/Battery Meter Brush Up/Down Solution Control Power Traverse Speed Control Clarke ® Page -18- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 19: Symbols Used On L28, L33, L38
SYMBOLS USED ON FOCUS L28, L33 & L38 Hazard Alert Symbol Brush Up/Down On/Off Key Switch Charge Indicator Squeegee Up/Down One Touch Switch Solution Control Hour Meter Switch Power Traverse Speed Control Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 19 -... - Page 20 Símbolo de alerta de riesgo Presión adicional del cepillo Interruptor de llave On/Off (encendido/ apagado) Medidor de carga /batería Cepillo Arriba/ Abajo Control de solución Alimentación Control de velocidad de desplazamiento ® Clarke Page -20- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 21 Indicador de carga Escobilla de goma Arriba/ Abajo Interruptor de pulsación única Control de solución Interruptor de cuentavueltas calibrado en horas de trabajo Alimentación Control de velocidad de desplazamiento Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 21 -...
-
Page 22: Symboles Utilisés Sur S28, S33, S38
Symbole d’avertissement d’un danger Augmentation de la pression des brosses Commutateur à clé Marche/Arrêt Indicateur de charge des batteries Abaissement/relèvement des brosses Niveau de solution Alimentation Contrôle de la vitesse de déplacement ® Clarke Page -22- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 23: Symboles Utilisés Sur L28, L33, L38
Commutateur à clé Marche/Arrêt Indicateur de charge Relèvement/Abaissement de la raclette Commutateur One Touch Niveau de solution Commutateur du compteur horaire Alimentation Contrôle de la vitesse de déplacement Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 23 -... -
Page 24: Machine Control Panel S28, S33, S38
Hour Meter (See Figure #1, Item "N") The hour meter indicates the number of hours the machine has operated. It runs only when the machine is moving forward or reverse. ® Clarke Page -24- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 25 MACHINE CONTROL PANEL S28, S33 & S38 Figure #1 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 25 -...
- Page 26 Cuentavueltas calibrado en horas de trabajo (consulte la figura 1, elemento “N”) El cuentavueltas calibrado en horas de trabajo indica el número de horas que ha funcionado la máquina. Sólo funciona cuando la máquina se mueve hacia adelante o hacia atrás. ® Clarke Page -26- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 27 PANEL DE CONTROL DE LA MÁQUINA S28, S33 y S38 Figura 1 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 27 -...
-
Page 28: Panneau De Commandes Des Machines S28, S33, S38
« ON », et ré-essayez. Un technicien agréé doit être contacté si le disjoncteur se déclenche de nouveau. Compteur horaire (Cf. Figure 1N) Le compteur horaire indique le nombre d’heures de fonctionnement de la machine. Il ne fonctionne que lorsque la machine avance ou recule. ® Clarke Page -28- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 29 PANNEAU DE COMMANDE DES MODELES S28, S33, S38 Figure 1 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 29 -...
-
Page 30: Machine Control Panel L28, L33, L38
Pressing the black display button will toggle between the main machine functions and the hour meter. The hour meter indicates the number of hours the machine has operated. It displays brush motor, vacuum motor, traverse motor and total key on hours.) ® Clarke Page -30- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 31 If a circuit breaker trips, determine which motor is not operating and turn the key switch "OFF". Wait five minutes and push the reset button back in. Turn the key switch "ON", and try again. An authorized service person should be contacted if the breaker trips again. Figure #2 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 31 -...
- Page 32 Muestra la cantidad total de horas de trabajo del motor del cepillo, del motor de vacío, del motor de desplazamiento y de todas las teclas. ® Clarke Page -32- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 33 (apagado). Espere cinco minutos y pulse el botón de reposición. Gire el interruptor de llave a “ON” (encendido) y vuelva a intentarlo. Si el disyuntor se dispara de nuevo, hay que ponerse en contacto con una persona del servicio técnico autorizado. Figura 2 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 33 -...
-
Page 34: Panneau De Commandes Des Machines L28, L33, L38
Le compteur horaire indique le nombre d’heures de fonctionnement de la machine. Il affiche le temps de fonctionnement du moteur des brosses, du moteur d’aspiration, du moteur de déplacement ainsi que le temps total de fonctionnement. ® Clarke Page -34- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 35 « OFF ». Attendez cinq minutes et appuyez sur le bouton de réinitialisation. Mettez le commutateur à clé en position « ON », et ré-essayez. Un technicien agréé doit être contacté si le disjoncteur se déclenche de nouveau. Figure 2 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
-
Page 36: Display Screen For L28, L33, L38
The Diagnostic only. It will not show unless a fault with the machine occurs. When the fault happens the icon and error code will be displayed. See "Common Error Codes" at end of "Maintenance Section". ® Clarke Page -36- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 37 El icono aparece en la pantalla cuando se produce el fallo, y se muestra un código de error. Consulte “Códigos de error comunes” al final de la “Sección de mantenimiento”. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 37 -...
-
Page 38: Ecran D'affichage Des Modèles L28, L33, L38
Lorsque la panne survient, l’icône et le code d’erreur apparaissent. Consultez la rubrique “Codes d’erreur courants” située à la fin de la “Section Maintenance”. ® Clarke Page -38- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 39 NOTES Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 39 -...
-
Page 40: Machine Controls And Features
The shut-off switch for the vac motor is located in the recovery tank. It automatically turns off the vac motor when the recovery tank is full. Figure #3b Figure #4 Figure #3c Figure #5 ® Clarke Page -40- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 41: Commandes Et Fonctions De La Machine
Il éteint de recuperación está lleno. automatiquement le moteur d’aspiration lorsque le réservoir de récupération est plein. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 41 -... -
Page 42: How To Prepare The Machine For Operation
See figure 6a and 6b. 8. Install the tank, reconnecting hoses and plugging in vac motor and float switch connectors. Install tank support bracket. NOTE: Charge the batteries before using the machine. ® Clarke Page -42- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 43: Préparation De La Machine Avant Son Utilisation
Remettez le dispositif de fixation Instale la abrazadera de apoyo del depósito. du réservoir en place. NOTA: Cargue las baterías antes de utilizar REMARQUE: Charger les batteries avant la máquina. d’utiliser la machine. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 43 -... -
Page 44: Battery Maintenance
To clean the terminals and connectors, use a terminal and connector cleaning tool. Do not allow ammonia or bicarbonate of soda to get into batteries. 3. Keep the batteries charged. ® Clarke Page -44- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 45: Entretien Des Batteries
Ne laissez pas l’ammoniaque ou le bicarbonate de soude Mantenga las baterías cargadas. pénétrer dans les batteries. Veillez à ce que les batteries soient chargées. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 45 -... -
Page 46: How To Charge The Batteries
When recharging the batteries, keep the recovery tank open. After every 20 recharging cycles, check the level of the electrolyte and if necessary top off with distilled water. ® Clarke Page -46- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 47: Chargement Des Batteries
Cada 20 operaciones l’eau distillée. de recarga, verifique el nivel de electrolito, y de ser necesario cubra por completo con agua destilada. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 47 -... -
Page 48: How To Install The Brushes Or Pad Drivers
3. Turn the key switch "OFF". 4. Go to the front of the machine. 5. Push down on two sides of the brush or pad driver until the gimbals release. ® Clarke Page -48- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 49: Installation Des Brosses Ou Des Entraîneurs De Disque
5. Empuje hacia abajo los dos lados del cepillo o axes se libèrent. impulsor de almohadillas, hasta que se liberen las suspensiones cardánicas. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 49 -... -
Page 50: How To Operate The Machine
The settings should be returned to 4 bars of solution and 2 bars of brush pressure. NOTE: The squeegee vac switch must be in the middle position for default settings to work. ® Clarke Page -50- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 51: Utilisation De La Machine
REMARQUE : Le commutateur d’aspiration las configuraciones por omisión. doit être en position centrale pour correspondre aux réglages usine. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 51 -... -
Page 52: How To Operate The Squeegee
Only use a cleaning concen- tration recommended by the chemical manufacturer. WARNING: Clarke recommends a maximum water temperature of 120°F(49°C) 4. Replace the solution tank lid. 5. When filling the machine from the rear, position the clear drain hose against bracket and insert hose as shown in figure 16. -
Page 53: Utilisation De La Raclette
AVERTISSEMENT : Clarke recommande une ADVERTENCIA: Clarke recomienda un máximo de température d’eau maximum de 49°C. temperatura para el agua de 120°F (49°C). 4. Remettez le couvercle du réservoir de solution en place. -
Page 54: How To Traverse Machine
NOTE: When you make more passes across the floor, let the brushes clean approximately 2 inches of the area already cleaned by the brushes. NOTE: During most cleaning procedures, apply and remove the solution in one operation. Clarke ® Page -54- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 55: Conduite De La Machine
REMARQUE : Lors de la plupart des opérations de nettoyage, vous aplique y quite la solución en una sola operación. appliquerez et retirerez la solution en une seule et même opération. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 55 -... -
Page 56: Maintenance
6. Make sure brush housings and skirts are in position on the brush head. 7. Make sure the brushes are in position and installed correctly 8. Check the installation of the squeegee and squeegee hose. Clarke ® Page -56- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 57 8. Verifique la instalación de la escobilla de goma 8. Verifique la instalación de la escobilla de goma y de la manguera de la misma. y de la manguera de la misma. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 57 -...
- Page 58 Use a clean cloth and wipe the surface of the machine. Charge the batteries. See the instruction in the section of this book called “How To Charge The Batteries”. Clarke ® Page -58- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 59 Manuel intitulée « Rechargement de Cargue las baterías. Consulte las instrucciones incluidas en la batterie ». la sección de este manual llamada “Carga de las baterías”. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 59 -...
- Page 60 5. Use a grease gun to lubricate the drive wheel and the casters. See figure #25. 6. Check tire pressure. Tire pressure should be about 50 psi. ® Clarke Page -60- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 61 Cf. figure 25. 6. Controle la presión del neumático. La presión del neumático debe ser de aproximadamente 50 psi. 6. Vérifiez la pression des pneus. Celle-ci doit être d’environ 50 psi. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 61 -...
- Page 62 "Y" up. Make very small adjustments and try it until a uniform flare is achieved. Changing the tilt may also require readjusting the squee- gee pressure. ® Clarke Page -62- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
- Page 63 Si se cambia la inclinación, puede que sea también exercée sur la raclette. necesario realizar ajustes en la presión de la escobilla de goma. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 63 -...
- Page 64 WARNING: Electrical repairs must be done by authorized per- Figure #29 sonnel only. Consult your Clarke Authorized Service Person to do the service procedures. Use only genuine Clarke parts. How to Clean the Solution Line If the solution line becomes clogged, pull the filter...
- Page 65 N’utilisez que des pièces d’origine Clarke. Consulte con el personal técnico autorizado de Clarke para realizar los procedimientos de servicio. Nettoyage du tuyau d’écoulement de la solution Utilice únicamente repuestos originales de Clarke.
-
Page 66: How To Correct A Problem
Check wire connection to traverse motor. Replace the fuses. Check the batteries connections. Check parking brake overide lever position (if installed) NOTE: If the motors continue to stop, consult an authorized service person. ® Clarke Page -66- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 67 Verifique la posición de la palanca de transferencia de mando del freno de estacionamiento (si está instalada) NOTA: si el motor sigue deteniéndose, consulte a una persona del servicio técnico autorizado. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 67 -...
-
Page 68: Résolution Des Problèmes
Vérifiez les connexions de la batterie. Vérifiez la position du levier du frein de stationnement (s’il est installé) REMARQUE : si le moteur continue à s’arrêter, consultez un technicien agréé. ® Clarke Page -68- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 69: Common Error Codes (Focus L28/L33/L38)
Release traverse switch and reactivate. to turning key switch "ON". NOTICE: IF ERROR CODE/FAULT OCCURS TURN KEY SWITCH OFF AND THEN BACK ON. For further codes and explanations, contact a Clarke Service Center. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... - Page 70 AVISO: SI SE GENERA UN CÓDIGO DE ERROR O UN FALLO, APAGUE Y VUELVA A ENCENDER EL INTERRUPTOR DE LLAVE Para obtener otras explicaciones y más información sobre otros códigos de error, contacte al Centro de Mantenimiento Clark. ® Clarke Page -70- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB...
-
Page 71: Codes D'erreur Courants (Focus L28/L33/L38)
“ON”. REMARQUE : EN CAS DE CODE ERREUR/PANNE, ETEIGNEZ PUIS RALLUMEZ LE COMMUTATEUR A CLE. Pour plus de codes d’erreur et plus d’explications, contactez un Centre de service Clarke. Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 72: Accessories
Clarke Care Kit 14607A Squeegee Asm., Optional 29" (28 model only) 18818A Drive Wheel, Foam Filled 59955A Imperial Electric Parking Brake Kit 10684A Clarke Battery Maintenance System (CBMS) 53390A Optional Squeegee Blades Machine Blade Type Material Length Part No. Inner... - Page 73 Montaje de la escobilla de goma, opcional 29” (únicamente en el modelo 28) 18818A Rueda propulsora, con relleno de espuma 59955A Kit Imperial de freno eléctrico de estacionamiento 10684A Sistema de mantenimiento de batería Clarke (CBMS) 53390A Hojas opcionales de la escobilla de goma Máquina Hoja Tipo Material Longitud Pieza N°.
-
Page 74: Accessoires
Bras de raclette, en option 29" (modèle 28 uniquement) 18 818A Roue, remplie de mousse 59 955A Kit frein de stationnement électrique Imperial 10 684A Système de maintenance de la batterie Clarke (CBMS) 53 390A Balais de raclette en option: Machine Balai Type Matériau Longueur N°... -
Page 75: Section Ii Parts And Service Manual
S28 / L28 WB S33 / L33 WB S38 / L38 WB Section II Parts and Service Manual (70851A) U.S. Patent No. 6,760,947; No. 6,105,192; No. 6,493,896 (Deluxe Machines); & Patent Pending... -
Page 76: Solution Tank Assembly
® Clarke FOCUS 28/33/38 WB Solution Tank Assembly Drawing 12/05 33 34 ® Clarke Page -76- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 77: Parts List
Clarke ® FOCUS 28/33/38 WB Solution Tank Assembly Parts List 12/05 Ref # Part No. Description 881317 Battery - 250 AH - 6 Volt 891384 Battery - 330 AH - 6 Volt 842406 Series Cable - 9" 40613A Battery Cable, Black... -
Page 78: Recovery Tank Assembly
® Clarke FOCUS 28/33/38 WB Recovery Tank Assembly Drawing 8/05 ® Clarke Page -78- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 79: Parts List
Clarke ® FOCUS 28/33/38 WB Recovery Tank Assembly Parts List 8/05 Ref # Part No. Description 962798 Screw, 10-24 x 1/2 PN 30057A Recovery Lid 920296 Nut, 10-24 ESNA 30065A Gasket, Lid 38020A Strap 962666 Screw, 10-24 x 3/4 PN... -
Page 80: Electrical Panel Assembly S28, S33. S38
® Clarke FOCUS S28/S33/S38 WB Electrical Panel Assembly Drawing 11/04 ® Clarke Page -80- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 81: Parts List
Clarke ® FOCUS S28/S33/S38 WB Electrical Panel Assembly Parts List 11/04 Ref # Part No. Description 40740A Cord, Charger 61598A Bracket, Cord Wrap 85391A Screw, 1/4-20 x 5/8 PN 30594A Rear Cover 81104A Nut, ESNA 1/4-20 87007A Washer, 1/4 Flat... -
Page 82: Electrical Panel Assembly L28, L33, L38
® Clarke FOCUS L28/L33/L38 WB Electrical Panel Assembly Drawing 11/04 ® Clarke Page -82- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 83: Parts List
Clarke ® FOCUS L28/L33/L38 WB Electrical Panel Assembly Parts List 11/04 Ref # Part No. Description 40740A Cord, Charger 61598A Bracket, Cord Wrap 85391A Screw, 1/4-20 x 5/8 PN 30626A Rear Cover 81104A Nut, ESNA 1/4-20 87007A Washer, 1/4 Flat... -
Page 84: Control Panel Assembly
Clarke ® FOCUS 28/33/38 WB Control Panel Assembly Drawing 11/04 ® Clarke Page -84- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 85: Parts List
® Clarke FOCUS 28/33/38 WB Control Panel Assembly Parts List 2/05 Ref. # Part No. Description "L" "S" 30592A Control Handle 85815A Screw, 5/16-18 x 1 1/2 980205 Washer, 5/16 Flat 85813A Screw, 5/16-18 X 1 920110 Nut, LK 5/16-18... -
Page 86: Squeegee Swing Arm Assembly
Clarke ® FOCUS 28/33/38 WB Squeegee Swing Arm Assembly Drawing 4/06 NOTE: #51 and #52 are on top of bracket for the "S" models ® Clarke Page -86- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 87: Parts List
® Clarke FOCUS 28/33/38 WB Squeegee Swing Arm Assembly Parts List 4/06 Ref # Part No. Description Qty Model Ref # Part No. Description Qty Model 57275A Pulley 69673A Squeegee Base 87623A Washer, Nylon 1¼x¼x 69674A Squeegee Base 60452A Swing Arm, Front... -
Page 88: Traverse System Assembly
® Clarke FOCUS 28/33/38 WB Traverse System Assembly Drawing 11/04 ® Clarke Page -88- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 89: Parts List
® Clarke FOCUS 28/33/38 WB Traverse System Assembly Parts List 11/04 Ref # Part No. Description Qty Model 66531A Swing Arm Pin 836711 Hair Pin 81104A Nut, .25-20 ESNA 69877A Swing Bracket 85811A Screw, .312-18 x .75 57275A Cable Pulley 87623A Washer, Nylon 1¼x¼IDx.120... -
Page 90: Brush Head Assembly
Clarke ® FOCUS 28/33/38 WB Brush Head Assembly Drawing 11/04 ® Clarke Page -90- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 91: Parts List
® Clarke FOCUS 28/33/38 WB Brush Head Assembly Parts List 11/04 Ref # Part No. Description Qty Model Ref # Part No. Description Qty Model 82501A 56941A Center-Lock Asm. 766780 Hair Pin (Pad Driver Only) 38723A Nylon Spacer 11427B Poly Brush Assembly-14 52497A Actuator &... -
Page 92: Brush Motor
® Clarke FOCUS 28/33/38 WB Brush Motor #45036A 11/04 Seam Location Rotation Ref # Part No. Description 46734A Stator Assembly (w/Magnets & Clips) 40318A Armature Asm.(w/B.E. & F.E. bearings) 902654 Bearings B.E. 902550 Bearing F.E. 51840A Commutator Bracket Assembly (w/Brush BRD Assembly Leads) -
Page 93: Gearbox
Clarke ® FOCUS 28/33/38 WB Gear Box #54238A 11/04 Ref # Part No. Description 57846A Ring, Snap 507641 Seal, Oil, Small 52050A Cap End 56668A O'Ring 51176A Bearing, Large 58316A Shaft & Gear, Gearbox 902605 Bearing, Small 54883A Housing 58144A... -
Page 94: Vac Motor
Clarke ® FOCUS 28/33/38 WB Vac Motor Assembly #45019A 11/04 Ref # Part No. Description Ref # Part No. Description 51913A Clip (optional) 59803A Washer - neoprene 54809A Housing 50610A Bracket and shell 53905A 58501A Spacer 85303A Screw - 8-32 x... -
Page 95: Imperial Transaxle Parts 11/04
Clarke ® FOCUS 28/33/38 WB Imperial Transaxle Parts 11/04 PN 59116A Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 95 -... -
Page 96: Control Panel Connection Diagram S28/S33/S38
Clarke ® FOCUS S28/S33/S38 WB Control Panel Connection Diagram 11/04 ® Clarke FOCUS S28/S33/S38 WB (Front of Machine) Connection Diagram 11/04 ® Clarke Page -96- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 97: Control Panel Connection Diagram L28/L33/L38
® Clarke FOCUS L28/L33/L38 WB Control Panel Connection Diagram 11/04 ® Clarke FOCUS L28/L33/L38 WB (Front of Machine) Connection Diagram 11/04 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 97 -... -
Page 98: Electrical Plate Connection Diagram S28/S33/S38
Clarke ® FOCUS S28/S33/S38 WB Electrical Plate Connection Diagram 11/04 ® Clarke Page -98- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 99: Electrical Plate Connection Diagram L28/L33/L38
Clarke ® FOCUS L28/L33/L38 WB Electrical Plate Connection Diagram 11/04 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 99 -... -
Page 100: Control Housing Connection Diagram 11/04
® Clarke FOCUS S28/S33/S38 & L28/L33/L38 WB Control Housing Connection Diagram 11/04 ® Clarke Page -100- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 101: Electrical Schematic S28/S33/S38
® Clarke FOCUS S28/S33/S38 WB Electrical Schematic 11/04 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 101 -... -
Page 102: Electrical Schematic (Top) L28/L33/L38
Clarke ® FOCUS L28/L33/L38 WB Electrical Schematic (pages 102-103) 11/04 Clarke ® Page -102- Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB... -
Page 103: Electrical Schematic (Bottom) L28/L33/L38
® Clarke FOCUS L28/L33/L38 WB Electrical Schematic (pages 102-103) 11/04 Clarke ® Operator's Manual - FOCUS S28/L28/S33/L33/S38/L38 WB - 103 -... - Page 104 NOTES...
- Page 105 ALTO Cleaning Systems (UK) Ltd., Penrith (810) 544-6300 Gilwilly Industrial Estate Penrith American Lincoln ® / Clarke, Marietta, Georgia 30066 Cumbria CA11 9BN 1455 Canton Road +44 1768 868 995 (770) 973-5225 ALTO France S.A. Strasbourg B.P. 44, 4 Place d’Ostwald...
-
Page 106: Maintenance
STATED WARRANTIES ARE IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED Clarke's liability under this warranty is limited to repair of the product and/or replacement of parts and is given to purchaser in lieu of all other remedies, including INCIDENTAL AND CONSEQUENTIAL DAMAGES.