Night Light Tm Replacement; Bulb Replacement; Lens Assembly Installation; Lens Assembly Replacement - Napoleon GDS26N Installation And Operating Instructions Manual

40
10.2 NIGHT LIGHT
10.2.1

BULB REPLACEMENT

EN
The GDS26 comes equipped with our "Night Light™". If in the event the lamp or lens
needs to be replaced, follow these instructions.
Turn off all electrical supply.
A.
Remove the safety barrier front and door from the fi rebox.
B.
Unscrew the lens cover making sure the washer stays in place.
C.
NOTE: Do not handle the lamp (bulb) with bare fi ngers, protect with a
clean dry cloth.
The lamp will pull straight out of the socket. Replace with Wolf Steel Ltd. parts only (W387-0006), as lamp
D.
and lens are special "high temperature" products.
Replace lens with gasket, lens covers, attach wires to quick connects and replace the door when fi nished.
E.
NOTE: The fi rebox must be sealed.
When re-assembling the light assembly, care must be taken. "Light Leakage" from above the cast doors
may be noticed. The holes in the lamp housing are necessary for ventilation and must not be covered.
10.2.2

LENS ASSEMBLY INSTALLATION

Remove the safety barrier and door from the fi rebox.
A.
Run the wires up through the lens hole.
B.
Align key hole with lens assembly.
C.
Snap into place.
D.
Replace light shields, attach the wires and replace the door to the fi rebox.
E.
10.2.3

LENS ASSEMBLY REPLACEMENT

Remove the safety barrier and front door and top shield from the fi rebox.
A.
Compress the retainer fi ns in with a screw driver while pressing fi rmly on
B.
the top of the light assembly.
Once all the retainer fi ns are pushed in the lens assembly will snap out of
C.
place.

10.3 CARE OF GLASS

DO NOT CLEAN GLASS WHEN HOT! DO NOT USE
ABRASIVE CLEANERS TO CLEAN GLASS.
Buff lightly with a clean dry soft cloth. Clean both sides
of the glass after the fi rst 10 hours of operation with a
recommended fi replace glass cleaner. Thereafter clean
as required. If the glass is not kept clean permanent
discoloration and / or blemishes may result.
This appliance is factory equipped with 5mm ceramic glass. Use only replacement glass available from your
Napoleon® dealer. DO NOT SUBSTITUTE MATERIALS.
W415-1333 / 06.25.14
REPLACEMENT
TM
KEY HOLE
WARNING
!
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
5.1
5.5.1