Page 1
Manual de servicio ACONDICIONADOR DE AIRE TIPO MINI SPLIT DSC-097L DSC-127L Aviso En este manual, algunas partes pueden cambiar sin previo aviso en la lista de partes si usted necesita la ultima informacion por favor dirigirse a PPL (Parts Price List) Centro de informacion de...
CONTENTS Contents..................1 Service and Maintenance ............2 Controls specification ..............4 Disassembly and reassembly ............9 Troubleshooting ................13 Exploded views and part list .............15 Wiring diagram .................20 Block diagram ................21...
SERVICE AND MAINTENANCE Air Conditioner no use for a long time. Want to use the Air Conditioner Start fan only for 3-4 hours to comple- Clean filters and replace them to origi- tely dry the inside of the indoor unit. nal position.Clean indoor unit with soft Set COOL mode or HEAT mode, cloth.
Page 4
SERVICE AND MAINTENANCE Deodorization filter, Air cleaner, Filters must be cleaned termly. Open front panel only after air conditioner stops completely. Filters should be cleaned once every two weeks. Clean deodorization filters and air cleaner. Take out filters. Take out filters first, then take out deodorization filter and air cleaner.
CONTROLS SPECIFICATION ABBREVIATION Ts: Setting Temperature Tr: Room Temperature Ti: Indoor defrost sensor temperature To: Outdoor defrost sensor temperature OPERATION OF MAIN BOARD COOL MODE If Tr > Ts, cool operation is activated. Compressor and outdoor fan are turned on. Indoor fan runs at the set speed.
Page 6
CONTROLS SPECIFICATION DRY MODE If Tr 15 , dry operation is activated. Compressor and outdoor fan are turned on interval. If Tr 23 , Compressor and outdoor fan are operating in sequence as follows: See A of fig1 If Tr<23 Compressor and outdoor fan are operating in sequence as follows: see B of FIG1.
Page 7
CONTROLS SPECIFICATION HIGH PRESSURE PROTECTION If Ti > 50 , the outdoor fan is turned off. After that, if Ti < 47 , the system will start again.( For 07.09 type) If Ti > 55 , the outdoor fan is turned off. After that, if Ti < 50 , the system will start again.( For 12.18 type) If Ti >...
Page 8
CONTROLS SPECIFICATION AUTO FAN SPEED In cool mode, if Tr-Ts < 0 , indoor fan is run at low speed. If 0 <Tr-Ts<2 , if indoor fan is running at low speed, there will be no change in speed , if fan is running at medium speed ,there will be no change in speed ,if indoor fan is run at high speed ,it will change to medium speed.
Page 9
CONTROLS SPECIFICATION OPERATION OF CONTROL PANEL ON INDOOR UNIT MANUAL OPERATION BUTTON Every press of this button will turn the system on or off. (Cool only type) Every time the switch is pressed, it changes in sequence of COOL STOP. (Heat pump type) Every time the switch is pressed, it changes in sequence of COOL...
DISASSEMBLY AND REASSEMBLY Stop operation of the air conditioner and remove the power cord before repairing the unit Indoor unit Model :DSC-097L DSC-127L Parts Procedure Remark Front grille 1.Stop the air conditioner operation and block the main power. 2.Contract the second finger...
Page 11
DISASSEMBLY AND REASSEMBLY Parts Procedure Remark 2.Loosen the screw of the inside terminal board , separate the board. 3.Loosen the screw of the inside terminal board , separate the board. 4.Take all the connector of the PCB upper side out. 5.Loosen the earth screw in evaporator.
Page 12
DISASSEMBLY AND REASSEMBLY Parts Procedure Remark Ass’y tray 1.Push the left and right hooks drain to make the ass’y pulled out. 2.Separete the ass’y tray drain from the body. 1.Push the left hook and separate the left part out of evaporator.
Page 13
DISASSEMBLY AND REASSEMBLY Model :DSC-097L DSC-127L Outdoor unit Parts Procedure Remark Cabinet 1.Turn off the unit and remove the power cable. 2.Remove the upper cabinet, the front cabinet and back cabinet. 1.Remove the nut flange. Fan motor & (Turn to the right to remove...
Troubleshooting If problems can not be corrected after doing below items, please stop the air conditioner, contact our air conditioner specially eng- aged service centre nearest to you to get help. Fault analysis Is there a fault ? Does power fail ? Air conditioner does Is plug out ? not operate at all.
Page 15
Troubleshooting Is there a fault ? Fault analysis Indoor unit fan stops It is defrosting of the outdoor unit coil.It should for about 10 complete this process in about 10 minutes at minutes during most.( It freezes when outdoor temperature is heating.
Exploded Views and Parts List Indoor unit Model :DSC-127L Model :DSC-097L N O . P a r t N a m e Q u a n t it y Item C ode A ir filter K F R 3 3 G . 1 . 1 .2 - 8 F r o n t p a n e l K F R 3 3 G .
Page 18
Exploded Views and Parts List Outdoor unit Model :DSC-097L Model :DSC-127L...
Page 19
Exploded Views and Parts List Outdoor unit Model :DSC-097L Model :DSC-127L Part Name Quantity Item Code Air outlet grille KFR20W.1.1-2 Front panel KFR20W.1.1-1 Left handle SL05-01 Top panel KFR20W.1.2-1 Fan screw nut M6 (left revolve) GB41-86 Outdoor fan KFR20W.1.5.1 Outdoor fan motor...
Exploded Views and Parts List Remote controller Name Quantity Number Inlay LCD case up LCD screen Conduct rubber Ass’y PCB remocon Back body Spring battery Conduct rubber Spring battery Screw Back cover...