Heartway Medical Products QUEST User Manual page 16

Lithium Battery (11.5A)
Nominal Voltage
Nominal Capacity
Charging Current
Charging Time
Ambient
Temperature Storage
Weight
IMPORTANT NOTICE
In order to maximize the lifespan of lithium batteries, they need to be given a full charge before use and
make sure they are fully charged and disconnected from the scooter prior to storage.
BATTERY CHARGER
The battery charger takes the standard wall outlet voltage (alternating current) and converts it into DC voltage
(direct current).The batteries use direct current to run your power scooter. When the batteries are fully
charged, the amperage from the charger is almost at zero. This is how the charger maintains a charge but does
not overcharge the battery.
Note 1: The batteries cannot be charged if they were discharged to nearly zero voltage.
Note 2: The powered scooter meet the requirement of ISO 7176-14:2008 and ISO 7176-21:2003.
Note 3: Only use the battery charger type 4C24050A which was provided by the scooter supplier. The use of
any different type of charger can be hazardous and need the approval of the manufacturer.
CHARGING INSTRUCTIONS
To recharge the batteries, follow the steps below:
 Place your power scooter close to a standard electrical wall outlet.
 Remove your key to turn the power OFF
 Slide the charger port door open.
 Plug the XLR connector of the charger to the charger port.
 Plug the other end of power cord into a standard wall outlet.
 When charging is completed, battery capacity indicator is shown.
 Disconnect the charger power cord from the wall outlet when the batteries are fully charged.
Recharge battery only when the key is in off position. When indicator is in low status, this confirms the battery
needs recharging.
Note:
 Always charge your batteries in well ventilated areas.
 The charger is intended for indoor use only. Protect from moisture.
 For maximum performance, it is recommended that you replace both batteries at the same time if the
batteries are weak.
 If the vehicle will not be used for a long period of time, arrange to have the batteries recharged at least
once every month to avoid deterioration of the batteries.
24V
11500 mAh
2,000 mA
5-6 Hours
Charge 0 C to +45 C (+32 F to 113 F)
Discharge -20 C to + 65 C (-4F to 140 F)
< 30 C (86 F)
Max 2 Kg
16