Table of Contents
Advertisement
Quick Links
WELLS BLOOMFIELD, LLC
2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439
telephone: 775-689-5707
www.wellsbloomfield.com
Model 1223EX Dispenser
77729
p/n
Rev. G ECN-13496
fax: 775-689-5976
PRINTED IN UNITED STATES OF AMERICA
OWNERS MANUAL
for
HOT WATER
DISPENSER
FOR EXPORT
2 GALLON MODELS:
1223EX
5 GALLON MODELS:
1226EX
Includes:
Installation
Operation
Use & Care
Servicing Instructions
M713
713
08
0805 cps
Advertisement
Table of Contents
Related Manuals for Bloomfield 1223EX
Summary of Contents for Bloomfield 1223EX
- Page 1 OWNERS MANUAL HOT WATER DISPENSER FOR EXPORT 2 GALLON MODELS: 1223EX 5 GALLON MODELS: 1226EX Includes: Installation Operation Use & Care Servicing Instructions Model 1223EX Dispenser PRINTED IN UNITED STATES OF AMERICA 77729 Rev. G ECN-13496 M713 0805 cps...
-
Page 2: Warranty Statement
Wells Bloomfield cannot assume liability for damage or loss is signed by the delivery person. incurred in transit. We will, however, at your request, supply FILE CLAIM FOR DAMAGE IMMEDIATELY: you with the necessary documents to support your claim. -
Page 3: Table Of Contents
AMPS POWER SUPPLY MODEL WATTS 1ø 50/60Hz 1ø CORD Supplied 1223EX 1800 IEC 1800W Minimum 1226EX 4000 16.5 Not Provided APPLICABILITY This manual applies to the following Wells Bloomfield products: 1223EX 2-Gallon Hot Water Dispenser 1226EX 5-Gallon Hot Water Dispenser... -
Page 4: Features & Operating Controls
FEATURES AND OPERATING CONTROLS REAR COVER REAR VIEW FRONT VIEW THERMOSTAT ACCESS READY LITE POWER LITE FLEXIBLE DRAIN LINE WATER SUPPLY CONNECTION TANK HEATER SWITCH DISPENSE FAUCET DRAIN LINE TUBING CLAMP POWER CORD (WHEN SUPPLIED) RUBBER GRIP FEET... -
Page 5: Precautions & General Information
PRECAUTIONS AND GENERAL INFORMATION WARNING: ELECTRIC SHOCK HAZARD All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock. WARNING: INJURY HAZARD All installation procedures must be performed by qualified personnel with full knowledge of all... -
Page 6: Installation Instructions
1/4-turn ball valve, to avoid loss of water flow thru the valve. criteria to insure successful operation of the dispenser. Bloomfield recommends 1/4" copper tubing for installation of less than 12 feet and 3/8" for more than 12 feet from a 1/2"... - Page 7 IMPORTANT: The ground pin Model 1223EX is equipped with a cord and plug. It requires a of the plug is part of a system 240 Volt IEC 1800 Watt 1 Phase circuit (50/60 Hz, 2 wire plus designed to protect you from ground).
-
Page 8: Operation
OPERATION WATER HEATER Water temperature is sensed by thermobulb inserted into the water tank. Temperature is controlled by a mechanical thermostat. The setpoint temperature is adjustable by turning the thermostat shaft. Excessive temperature will trip the hi-limit safety switch, disabling the heating element. The hi-limit will automatically reset when the dispenser cools. -
Page 9: Cleaning Instructions
CLEANING INSTRUCTIONS PROCEDURE: Clean Hot Water Dispenser CAUTION: BURN HAZARD PRECAUTIONS: Disconnect dispenser from electric power. Allow dispenser to cool. Dispensed water is extremely hot. Hot water will cause FREQUENCY: Daily serious skin burns. TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush CAUTION: SHOCK HAZARD... -
Page 10: Troubleshooting Suggestions
TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Water won’t heat Dispenser unplugged or circuit Check power supply cord breaker tripped Check / reset circuit breaker Tank heater switch "OFF" Press switch to "ON" Temperature setpoint too low Adjust thermostat for desired temperature Hi-Limit safety switch tripped Allow to cool hi-limit will self-... -
Page 11: Servicing Instructions
SERVICING INSTRUCTIONS ACCESS PANELS CAUTION: SHOCK HAZARD REAR PANEL: Remove rear panel to access hot water tank, thermostat, Opening access panels on heating elements, tubing, water level control and plumbing this dispenser may expose connections. uninsulated electrical components. Rear panel is held by four screws at the back. The flanged top Disconnect dispenser from portion fits over the body of the dispenser. - Page 12 SERVICING INSTRUCTIONS (continued) TEMPERATURE ADJUSTMENT IMPORTANT: The thermostat will maintain Check temperature at discharge of faucet. temperature within ±1.5ºC. Remove thermostat access button plug to access thermostat. For high altitude locations, Turn thermostat shaft clockwise to increase temperature. thermostat should be adjusted to a maximum temperature equal to the local boiling BOILING...
- Page 13 SERVICING INSTRUCTIONS (continued) IMPORTANT: REPLACE HEATING ELEMENT When replacing heating Remove tank lid assembly as detailed on page 10. element, also replace seal gaskets. Remove two hex nuts holding element to cover. Pull element from mounting holes. Reassemble in reverse order. REPLACE SOLENOID Unplug power cord.
-
Page 14: Deliming Instructions
Reinstall wiring to heating hoses become necessary, element and thermostat. Reinstall fill and vent tubes. Bloomfield recommends replacing the hoses 8. Reconnect water supply. Plug in power cord. 9. Allow dispenser to fill, then drain. Repeat three times. - Page 15 EXPLODED VIEWS AND PARTS LISTS SERVICE KITS FAUCET REPAIR KITS 84686 Faucet & Shank Complete 8700-25 L Seat Cup (only) SOLENOID REPAIR KITS 83612 Solenoid Complete, Single 120V (1222, 1222CA) 83760 Solenoid Complete, Single 240V (1225, 1226) 85218 Inlet Fitting Kit (includes cap, fitting, washer & screen) 85219 Inlet Strainer (only)
-
Page 16: Exploded View & Parts List
EXPLODED VIEW & PARTS LIST 2 REQD 2 REQD 1223EX ONLY NOTE: Model 1223EX shown. Model 1226EX is similar. - Page 17 EXPLODED VIEW & PARTS LIST (continued) ITEM DESCRIPTION 1223EX P/N 1226EX P/N WRAP, BODY TANK ASSY PANEL, TOP BACK PLUG, BUTTON 7/8" 8705-36 8705-36 SUPPORT, TANK LIGHT, PILOT GREEN 8718-31 8718-31 LABEL, HW DISPENSER LIGHT, PILOT AMBER 61178 61178 CONTROL, LOW WATER, 240V...
-
Page 18: Wiring Diagrams
WIRING DIAGRAM 2-GALLON MODEL 1223EX POWER HOT WATER LIGHT READY LIGHT (GREEN) (AMBER) HI-LIMIT WHITE BLACK THERMOSTAT BLACK BLACK HEATING ELEMENT 1800 WATTS 1223EX WHITE COMM WATER LEVEL CONTROL N.O. BOARD WATER N.C. LEVEL PROBE INPUT COMM GREEN TANK HEATER... - Page 19 WIRING DIAGRAM (continued) 5-GALLON MODEL 1226EX POWER HOT WATER LIGHT READY LIGHT (GREEN) (AMBER) HI-LIMIT BLACK BLACK 12 ga. THERMOSTAT MODULE A1(+) A2(-) BLACK HEATING ELEMENT 4000 WATTS WHITE COMM WATER LEVEL CONTROL N.O. TANK BOARD HEATER WATER N.C. SWITCH LEVEL PROBE BLACK...
- Page 20 Commercial Food Equipment Service Association Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association SERVICE TRAINING - QUALITY SERVICE SERVICE TRAINING - QUALITY SERVICE Genuine Parts Protect - YOU - All - Ways CUSTOMER SATISFACTION CUSTOMER SATISFACTION WELLS BLOOMFIELD, LLC 2 ERIK CIRCLE, P.