Troubleshooting Guide; Parts List; Parts And Service - Overhead door 55 Assembly, Installation And Operating Instructions

TROUBLE SHOOTING GUIDE
PARTS LIST
. .
This trouble shooting guide is for you to compare the problem with the possible cause.
l. 102152 - l Cover Assembly
SYMPTOM
POSSIBLE CAUSE
Light cycles on and off every 3-4
Short in wall pushbutton or push-
seconds. button circuit.
2.
102147- l Motor Support
3.
102142-l Motor
4.
102137- ·l
Motor Mounting Angle
()
5.
102105- l Motor Bracket
6.
102101-l Safety Trigger
7. 104047-l Circuit Board Mounting
Door starts down, runs l second * Open safety switch or safety
and reverses. switch circuit.
Bracket
8.
104036- l
Circuit Board Mounting
Bracket
9. 104103-2 Circuit Board
Door starts up, runs l second and
* Open safety switch or safety
10. 77543 Lim it Switch
stops.
switch circuit.
l
l. 77156 -l
Capacitor
12 . 77452 Capacitor Clip
Door runs down, hits floor and re - Improper adjustment of down limit
verses within l/2 second. switch dog.
13. 102149- l Limit Switch Arm
14. 102156-l Tension Spring
15. 104089-l Lim it Switch Bracket
Door limit switch dog slipping.
* Defective limit switch.
Assembll
16. 604058-l Termina Strip
17. 104040-l Sensitivity Switch
* Defective circuit board.
18. 80628 -l Adapter
19. 76877-12 Strain Relief Bushing
Door starts down, runs longer than Obstruction in doorway or roller
l second, then reverses. pathway.
20.
77085 Power Cord
21.
102145-l Main Frame
22. 104050-l Eyelet
* Hard operating or defective door.
Sensitivity control set too light.
23.
102102-l Safety Trigger Retainer
24.
102087-l
Sensitivity Spring
25. 104086-l Main Drive Gear
Assembly
Door raises, carriage hits power-
Improper adjustment of up limit
head.
switch dog.
26.
102103 - l Chain Idler
27.
102106-l
Support Bracket
28.
102104-l
Motor Guard
Up limit switch dog slipping.
29.
102151 - l Boom Bracket (3 piece)
* Limit switch defective.
102151-2 Boom Bracket (l piece)
30. 604067-l Lampholder
* Defective circuit board.
31. 86168 -3 Nylon Snap Bushing
32.
102144-l
Cable Dog
Door starts up, runs longer than l Obstruction in doorway or roller
second, then stops. pathway.
33. 104059- l Light Lens
34. 104039-l Lampholder Bracket
35. 80813 - l Wire, Bel I Cord
* Hard operating or defective door.
36. 86147 Push Button
Improper adjustment of sensitivity
control.
PARTS AND
SERVICE
Door runs up, won't run down. * Down limit switch or down limit
switch circuitry open .
For parts and service, contact the
* Defective circuit board.
nearest Overhead Door Distributor.
Door runs down, won't run up. * Up limit switch or up limit switch
When ordering parts, specify:
circuitry open.
* Defective circuit board.
MODEL NUMBER
Door runs down, hits obstruction,
* Defective safety switch, safety
does not reverse immediately,
switch circuit, or safety switch
PART NUMBER
but reverses in 30 seconds.
mechanism .
PART DESCRIPTION
Door will not open from radio or Operator unplugged .
pushbutton.
* Defective radio receiver.
Repairs to transmitter and receiver
should be performed by a qualified
* Defective circuit board.
repairman. See Radio Control
Instructions.
Motor overheated.
Motor runs, door wi 11 not open. * Broken chain, chain - cable, drive
sprocket, or drive gear .
* Requires the assistance of a qual ified re pairman .
Page 22