Download  Print this page

Advertisement

P900238-01
INstAllER: lEAVE thIs mANUAl WIth thE
APPlIANcE.
coNsUmER: REtAIN thIs mANUAl FoR FUtURE
REFERENcE.
In the commonwealth of massachusetts:
Installation must be performed by a licensed plumber or
gas fitter;
• See Table of Contents for location of additional Common-
wealth of massachusetts requirements.
WARNINg: If the information in this manual is
not followed exactly, a fire or explosion may
result causing property damage, personal injury
or loss of life.
FoR yoUR sAFEty: Do not store or use gasoline
or other flammables or liquids in the vicinity of
this or any other appliance.
FoR yoUR sAFEty: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow your gas suppliers
instructions.
• If your gas supplier cannot be reached, call
the fire department.
Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
C
VRt3542Ws shown
Report No. F14-168
US
INstAllAtIoN AND

oPERAtIoN INstRUctIoNs

UNIVERSAL VENT-FREE FIREBOX
36" x 24", 36" x 28" & 42" x 28" Universal Vent-Free Fireboxes
P/N 900238-01 REV. A 02/2015
MODELS
VRT2536WS
VRT3536WS
VRT3536WH
FoR UsE oNly WIth A lIstED gAs-FIRED
UNVENtED DEcoRAtIVE Room hEAtER Not to
EXcEED 40,000 btU/h.
Do Not bUIlD A WooD FIRE.
WARNINg: ImPRoPER INstAllAtIoN, ADjUstmENt,
AltERAtIoN, sERVIcE oR mAINtENANcE cAN cAUsE
INjURy oR PRoPERty DAmAgE. REFER to thIs mANUAl.
FoR AssIstANcE oR ADDItIoNAl INFoRmAtIoN coNsUlt
A qUAlIFIED INstAllER, sERVIcE AgENcy oR thE gAs
sUPPlIER.
cAREFUlly REVIEW thE INstRUctIoNs sUP-
PlIED WIth thE DEcoRAtIVE tyPE
Room hEAtER FoR thE mINImUm FIREPlAcE
sIzE REqUIREmENt.
Do Not INstAll AN APPlIANcE IN thIs FIREboX,
UNlEss thIs FIREboX mEEts thE mINImUm
DImENsIoNs REqUIRED FoR thE INstAllAtIoNs.
thIs Is A VENt-FREE gAs-FIRED hEAtER ENclosURE. It
UsEs AIR (oXygEN) FRom thE Room IN WhIch It Is IN-
stAllED. PRoVIsIoNs FoR ADEqUAtE combUstIoN AND
VENtIlAtIoN AIR mUst bE PRoVIDED. REFER to combUs-
tIoN AND VENtIlAtIoN AIR sEctIoN, PAgEs 3 & 4.
Due to high temperatures, the appliance should be located out
of traffic and away from furniture or draperies.
Do not place clothing or other materials on or near this appli-
ance.
ImPoRtANt: READ AND UNDERstAND thEsE INstRUctIoNs
comPlEtEly bEFoRE INstAllINg yoUR VENt-FREE Room
hEAtERs.
VRT3542WS
VRT3542WH
UNVENtED

Advertisement

Table of Contents

   Also See for Superior VRT2536WS

   Related Manuals for Superior VRT2536WS

   Summary of Contents for Superior VRT2536WS

  • Page 1: Operation Instructions

    INstAllAtIoN AND oPERAtIoN INstRUctIoNs UNIVERSAL VENT-FREE FIREBOX 36" x 24", 36" x 28" & 42" x 28" Universal Vent-Free Fireboxes P/N 900238-01 REV. A 02/2015 MODELS VRT2536WS VRT3542WS VRT3536WS VRT3542WH VRt3542Ws shown VRT3536WH P900238-01 FoR UsE oNly WIth A lIstED gAs-FIRED...
  • Page 2: Important Safety Information

    ImPoRtANt sAFEty WARNINg WARNINg INFoRmAtIoN carbon monoxide Poisoning: Early • The heater must be isolated from INstAllER: PlEAsE lEAVE thEsE INstRUc- signs of carbon monoxide poisoning the gas supply piping system by tIoNs WIth thE oWNER. closing its individual manual are similar to the flu with head- oWNER: PlEAsE REtAIN thEsE INstRUc- shut-off valve during any pres-...
  • Page 3: Table Of Contents

    A beautiful, prestigious, alternative to a wood National Fuel Gas Code, ANSI Z223.1/NFPA burning fireplace. Welcome to a family of tens of thousands of satisfied SUPERIOR 54 - latest edition. Fireplace Owners.
  • Page 4: Cold Climate Insulation

    The National Fuel Gas Code defines a confined 3. Add the BTU/Hr of all the fuel burning appli- Your options are: space as a space whose volume is less than ances in the space. 50 ft per 1,000 BTU/Hr (4.8 m per kw) of the a.
  • Page 5: Requirements For The Commonwealth Of Massachusetts

    NOTE: The following requirements reference various Massachusetts • The flexible gas line connector used shall not exceed 36 inches (92 and national codes not contained in this document. centimeters) in length. • The individual manual shut-off must be a T-handle type valve. Requirements for the commonwealth of massachusetts •...
  • Page 6: Location Of Firebox

    Installed (required on Installed (required sidewall clearances: The sides of the firebox UVF-36 only) on VRt2536Ws) opening must be at least 16" from any com- Fireplace bustible wall (Figure 2). Opening Figure 3...
  • Page 7 Model VRT2536WS WITH Hood Installed Models VRT3536WS and VRT3542WS WITHOUT Hood Installed Hood is required on all installations for this model only. Hood is optional on these models Safe Zone...
  • Page 8: Assembly Steps

    AssEmbly stEPs consult all local codes. ImPoRtANt Notes: Properly size and route the gas supply line • Illustrations shown in this manual reflect hold heater regulator with a wrench from the supply regulator to the area where the “typical” installations with nominal dimen- appliance is to be installed per requirements to prevent movement when connect- sions and are for design and framing refer-...
  • Page 9: Firebox Framing

    Figure 8 on Page 10 for firebox dimensions. cal building code to determine if you need sideration of the mantel clearances the hood must be installed (Model VRT2536WS Only). additional support. The firebox may be installed directly on a combustible floor or raised on a platform of...
  • Page 10: Specifications

    (303) (33) (140) (872) (854) Product Reference Information * A hood comes standard and is required for model VRT2536WS. The cat. No. model ship. Weight (lbs) shipping Volume factory-supplied hood must be installed on the firebox for safe opera- 20 cu. Ft.
  • Page 11: Framing Specifications

    FRAmINg sPEcIFIcAtIoNs corner Installation Framing Dimensions back Wall of chase/Enclosure This Figure corresponds to Table 1 VRt3536Ws & VRt3542Ws & Including Finishing materials If Any opening VRt2536Ws VRt3536Wh VRt3542Wh 42-1/4" (1073) 42-1/4" (1073) 48-1/4" (1226) 40-1/4" (1022) 44-1/4" (1124) 44-1/4" (1124) 23-9/16"...
  • Page 12: Optional Equipment / Blower Kit Installation

    ImPoRtANt top View * junction box * Electrical outlet the Ground Lead must be connected to the green screw (located on the hood junction box). Failure to do this blower could result in an electrical short or Bend blower mounting shock injury.
  • Page 13 - see Step 8 on Page 14). step 1. Follow the instructions below for the model you are installing: model VRt2536Ws: screw Using a screwdriver remove the screw from the blower access panel as shown in Figure 18. Slide the panel to the right until the flange clears the opening.
  • Page 14 10. Follow the instructions below for the model you are installing: step 6. Route a 3-wire, 120 VAC, 60 Hz, 1 ph power supply to the right model VRt2536Ws: side of appliance. Reinstall the blower access panel that was removed on Step 1 (see Figure 18).
  • Page 15: Firebox Finishes

    This attractive screen door is easy to install and enhances the appearance of the appliance. Decorative Screen Door Panel Kit cat. No. model Where Used h1959 AsD3624-tI VRt2536Ws combustible Wall h1960 AsD3628-tI VRt3536Ws & VRt3536Wh h1961 AsD4228-tI VRt3542Ws & VRt3542Wh (ref.
  • Page 16 Only one (ref. Form # 504216m) kit, located on the right side of the fireplace, is required. For more information on available log sets for this and other Superior products, visit SuperiorFireplaces.US.com. NOTE: DIAGRAMS & ILLUSTRATION ARE NOT TO SCALE.
  • Page 17: Replacement Parts List

    4. The description of the part. diagrams or failure to use only parts specifically 5. The quantity required. approved with this appliance may result in property 6. The installation date of the firebox. damage or personal injury. VRt2536Ws VRt3536Ws VRt3536Wh VRt3542Ws VRt3542Wh Description Part No.
  • Page 18 NotEs...
  • Page 19: Warranty

    THE WARRANTY Innovative Hearth Products ("IHP") 20 Year Limited Warranty warrants your Superior™ Brand gas fireplace, Stove or Insert ("Product") to be free from defects in materials and workmanship at the time of manufacture. The Product body and firebox carry the 20 Year Limited Warranty. Ceramic glass carries the 20 Year Limited Warranty against thermal breakage only.
  • Page 20 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. IHP reserves the right to make changes at any time, without notice, in design, materials, specifica- tions, prices and the discontinuance of colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A.

This manual is also suitable for:

Vrt3542wsVrt3536whVrt3536wsVrt3542wh

Comments to this Manuals

Symbols: 0
Latest comments: