Annual Start-Up - Inspection - Weil-McLain Gold GV Manual

• Installation • Start-Up • Parts • Maintenance
Xc
Service & maintenance — annual start-up
Annual start-up only
by qualified service
technician
Annual start-up —
inspect
Part number 550-141-856/0703
The boiler should be
at the beginning of the heating season, only by a qualified
service technician. In addition, the maintenance and care
of the boiler designated in Table 4 and explained on the
following pages must be performed to assure maximum
boiler efficiency and reliability. Failure to service and maintain
the boiler and system could result in equipment failure.
Reported problems
Inspect any problems reported by owner and correct before proceeding.
Boiler area
1. Verify that boiler area is free of any
and other flammable vapors and liquids.
2. Verify that boiler area (and air intake) is free of any of the
listed on page 13 of this manual. If any of these are present in the boiler
intake air vicinity, they must be removed. If they cannot be removed,
install combustion air piping to the boiler in accordance with the
appropriate venting supplement.
Air openings
1. Verify that combustion and ventilation air openings to the boiler room
and/or building are open and
wiring of automatic combustion air dampers, if used.
2. Verify that boiler vent discharge and air intake are
.
obstructions
Flue gas vent system (and air inlet piping)
1. Visually inspect entire flue gas venting system
installed) for blockage, deterioration or leakage. Repair any joints that
show signs of leakage in accordance with vent manufacturer's instructions.
When air is ducted to boiler, verify that air inlet hose is connected and
properly sealed.
Failure to inspect
them repaired can result in severe personal injury or
death.
inspected and started annually
combustible materials
contaminants
. Check operation and
unobstructed
clean and free of
(and air piping, if
for the above conditions and have
,
, gasoline
57