Rasmussen F Installation Instructions Manual page 3

GENERAL INSTALLATION INSTRUCTIONS
ATTENTION
REQUIRED TOOLS AND MATERIALS:
Sealing Compound, Matches.
PREPARATION:
1. This Gas Log set must be INSTALLED IN A FULLY VENTED
METAL OR MASONRY FIREPLACE WITH A WORKING
FLUE THAT IS SAFE FOR BURNING A WOOD FIRE. The
Flue MUST BE FREE OF ANY OBSTRUCTIONS.
2. Turn off gas supply to fireplace.
3. Clean fireplace floor of any ashes.
4. Attach damper clamp over edge of fireplace damper blade as
shown. When installed properly, damper clamp prevents accidental full
closure of damper. If unable to install provided damper clamp,
consult IMPORTANT INFORMATION on front page of these
directions.
STEP ONE: Burner Pan and Grate Positioning.
REAR WALL
TOP VIEW
FIGURE 2
STEP TWO: Burner Pan Assembly.
Standard Match Lighted
• (For use only with Natural Gas Models F, FH, FX, FXH)
WARNING: A SAFETY PILOT MUST BE INSTALLED ON ALL UNITS
DESIGNED OR CONVERTED TO BURN PROPANE/LP GAS
1. Apply pipe compound to threaded end of 3/8" BURNER PLUG (A). Opposite from gas supply, thread BURNER PLUG (A)
into BURNER P I P E (B)
2. Wrench tighten LOCKING
ORIFICE HOLDER (D).
3. Thread ORIFICE SPUD
Wrench tighten.
4. Apply pipe compound to
ORIFICE HOLDER ( D ) .
and wrench tighten with the
5. Insert the RATING PLATE
NUT (C) and the BURNER
TUBE (B). Wrench tighten
the LOCKING PAL NUT.
and wrench tighten.
PAL NUT (C) onto non-tapered end 3/8" BRASS
( E ) into 3/8" ORIFICE HOLDER (D).
the outside threads of the 3/8"
Thread into BURNER TUBE(B)
flared connection facing towards rear.
/HEAT SHIELD (F) between the LOCKING PAL
A
B
READ THESE INSTRUCTIONS
CAREFULLY BEFORE ASSEMBLY
Screw Driver, Adjustable Wrench, Pipe Wrench, Pipe
Damper Stop
Clamp
1. Place GRATE inside
firebox as far to the rear as
possible. Center GRATE left
to right.
2. With open edge facing out,
place BURNER PAN beneath
grate with leading
approximately one inch forward
of GRATE front legs.
3. Mark positions of GRATE
and BURNER PANon fire
place floor with pencil. Remove
from firebox.
3
Damper
FIGURE 1
SIDE VIEW
edge
FIGURE 3
E
C
FIGURE 4
Chimney
Flue
F
D