Table of Contents
Advertisement
520
Upright
OWNER'S MANUAL
QUESTIONS?
Call Our Toll Free
Keys Fitness Helpline
1-888-340-0482
1-888-340-0482
Monday-Friday
8:30-5:30 Central Time
CAUTION!
Keys Fitness Products, L.P.
Please read the precautions and
Keys Fitness Products, L.P.
P.O. Box 551239
instructions in this manual before
4009 Distribution Dr.
using this equipment. Please save
Dallas, Texas 75355-1239
Suite 250
this manual for future reference.
Garland, Texas 75041
Advertisement
Table of Contents
Related Manuals for Keys Fitness 520U
Summary of Contents for Keys Fitness 520U
- Page 1 Call Our Toll Free Keys Fitness Helpline 1-888-340-0482 1-888-340-0482 Monday-Friday 8:30-5:30 Central Time CAUTION! Keys Fitness Products, L.P. Please read the precautions and Keys Fitness Products, L.P. P.O. Box 551239 instructions in this manual before 4009 Distribution Dr. using this equipment. Please save...
-
Page 2: Limited Warranty
Product. To obtain warranty service, you must contact a Keys authorized retailer, service technician or Keys Fitness at our phone numbers located in this manual. Any parts determined to be defective must be returned to Keys to obtain warran- ty service. -
Page 3: Before You Start
This is especially important for persons over the age of 35 and/or persons with pre-existing health problems. Keys Fitness Products LP assumes no responsibility for personal injury or property damage sustained by or through the use of this product. -
Page 4: Assembly Parts
Assembly Parts Assembly Accessories No.18, 4 ea. No.17, 4 ea. M8 Cap Nut M8x70 Carriage Bolt No.1 No.21 No.15 MAIN FRAME FRONT STABILIZER REAR STABILIZER . No.19, 10 ea. 8 x 19 Arc Washer Hexa -- fube Wrench PEDALS, No.49 No.52 SEAT POST (L) N0.13, (R) N0.14,... -
Page 5: Before Beginning
Assembly of CM520 Exercise Bike REMOVE ALL SECURITY TAPE AND WRAPPING BEFORE BEGINNING. 1. Attach Front Stabilizer (21) and Rear Stabilizer (15) to the Main Frame (1) using carriage Bolts (17), Washers (19) and Nuts (18). 2. Attach Right and Left Pedals (13, 14) to the Pedal Crank (9). Axles of the pedals are branded “L”... - Page 6 4. Slide the Plastic Bellow (70) (optional) onto the Seat Post (49). 3. Attach the Seat (52) to the Seat Post (49) with the Nuts (50) Then insert the Seat Post (49) into the Main Frame (1). Use the and Washers (51) provided. Seat Adjustment Knob (47) to adjust to the desired seat height.
- Page 7 5. Connect the Extension Wire (54) in the Upright Post (56) to the Sensor Wire (45) in the Main Frame (1). Slide the Tension Cable (59) from the Main Frame (1) up through the Upright Post (56). Connect the Upright Post (56) to the Main Frame (1) using Hex Bolts (55) and Arc Washers (19).
- Page 8 7. Connect the computer cable at the top of the Upright Tube 8. Connect the Handlebar (62) to the Upright Post (56) with the (54) to the Computer (61). Attach the Computer (61) to the Hex Bolts (55) and Arc Washers (19). Upright Post (56) with the screws attached.
- Page 9 CM520 Exercise Bike Parts List PART PART MAIN FRAME 36 HEX BOLT 3/8"*26 BEARING HOUSING 37 WASHER BALL BEARINGS 38 IDLER ARM INSIDE BEARING COLLAR 39 NYLOCK NUT 3/8" WASHER 40 IDLER WHEEL SPACER HEX NUT 41 IDLER WHEEL OUTSIDE BEARING COLLAR 42 TENSION SPRING WASHER 43 WASHER...
-
Page 10: Console Functions
Console Functions Please see insert for LCD console display instructions. Troubleshooting: Should at any point your computer display partial values or numbers, it may require you to remove the batteries for approx 15 second, then replace them. Batteries: On the rear side of the computer you will find a door leading to the batteries. -
Page 11: Target Heart Rate Zone
Check your pulse recovery rate – If your pulse is over 100 bpm five minutes after you stop exercising, or if it’s higher than normal the morning after exercising, your exertion may have been too strenuous for your current fitness level. Rest and reduce the intensity next time.
Need help?
Do you have a question about the 520U and is the answer not in the manual?
Questions and answers