Trouble Shooting - Honda Minimoto Maxii Instruction Manual

TROUBLE SHOOTING:

Problem Probable Cause
1) The key is not in the lock.
The Maxii Bike does
not run..
2) The battery is low.
3) The circuit breaker is shut down.
4) The charger is not working
5) The battery is dead.
6) The wires are loose.
7) The brake lever is too tight
1) Low battery voltage.
The Maxii Bike was
running but it
suddenly stopped.
2) Circuit breaker is shut down
3) Loose connectors.
4) The brake is not properly adjusted.
The Maxii Bike is in "ON" 1) The charger is still connected.
mode but when I move the 2) The brake is too tight.
throttle handle, but the
back wheel won't turn.
Motor will run but the The chain has come off.
bike does not move.
The brake is too tight or
The brake cable is out of adjustment.
loose.
The Maxii Bike is noisy or The drive chain is too loose.
making a "popping" sound
when moving.
The charger gets warm
This is normal.
when I recharge the
battery.
The battery only lasts This is normal.
about 40 minutes when I ride
the bike.
The battery makes a slight This is normal.
sizzling or gurgling sound
when it recharges.
When I try to recharge the Electricity is not going to the charger.
battery, the LED does not
light up.
MINIMOTO MAXII BIKE
™
Solution
1) Make sure the key is in the lock and in the
"ON" position.
2) Charge the battery
3) Wait 10 minutes for circuit breaker cool down
and reset the switch.
4) Check to see if the wall socket is in the "on"
position and the led is turned on.
5) If the battery is old or has been abused, it
will need to replaced
6) Check all connectors
7) Adjust the lever to see that the power cut off
switch is not closed. Spray some lubricant into
the handle to loosen it up if it becomes sticky.
1) The electronic circuit will automatically
detect when the voltage is too low for the
bike to run. Recharge the battery.
2) Wait 10 minutes for circuit breaker to cool
down and reset the breaker.
3) Check all electrical connections
4) Adjust the brake as described in this manual
1) Disconnect the charger.
2) Adjust the brake to loosen the tire.
Replace chain to the gears.
Adjust the brake cable to proper tension.
Adjust the drive chain at the back wheel.
No action required.
no action required. recharge the battery
normally. note: heavy use of the battery will
result in even less operating time.
No action required.
There is no problem with the battery. Check
to see that the switch that controls the socket
that the charger is plugged into is in the on
position.
23