Table of Contents
Advertisement
OWNER'S
MANUAL
Osmosis
MODEL NO. 625.381560
UltraFilter 450
Caution:
Read and follow all safety rules and operating
instructions before first use of this product.
Questions ?
Visit www.KenmoreWater.com
or call toll free 1-800-426-9345 (M - F, 7AM - 8 PM CST)
Repair or Paris ? Call toll free 1=800469=4663
See back cover for other Sears service numbers.
SAVE THiS MANUAL
• Warranty
• Installation
• How It Works
• Care Of
• Specifications
• Repair Parts
Sears,
System Tested and Certified by NSF International
against NSF/ANSI
Standard 42 and 58. See performance
data sheet for details.
Roebuck
and Co.,
3333
Beverly
Road,
Hoffman
Estates,
IL
60179
U.S.A.
PRINTED IN U.S.A.
www.KerlmoreWater.com
Part No.7288057
(Rev. K 9/26/08)
Advertisement
Table of Contents
Related Manuals for Kenmore 625.38156
Summary of Contents for Kenmore 625.38156
- Page 1 OWNER'S MANUAL Osmosis MODEL NO. 625.381560 UltraFilter 450 Caution: Read and follow all safety rules and operating instructions before first use of this product. Questions ? Visit www.KenmoreWater.com or call toll free 1-800-426-9345 (M - F, 7AM - 8 PM CST) Repair or Paris ? Call toll free 1=800469=4663 See back cover for other Sears service numbers.
- Page 2 This warranty gives you specific legal rights, and you may have other rights which vary from state to state. Sears, Roebuck and Co., Hoffman Estates, IL 60179 14" -,_-- 13-1/2" 4" Questions? Call The Kenmore Water Line 1-800-426-9345 or visit KenmoreWater.com...
- Page 3 Water sys- tems using an inline chlorinator should provide minute chlorine contact time before the RO system. Questions? Call The Kenmore V This system is acceptable concentrations mg/L nitrite in combination from the tified for nitrate/nitrite plies with a pressure...
- Page 4 Reverse Osmosis Assembly Bag Assembly Hanger Brackets Dropper _12_nk Saddle Valve Connector Questions? Call The Kenmore list below. Note any Note any damage view and for the part names items. If problems listed require review plumb- Bag Assembly Water Storage...
- Page 5 Questions? Call The Kenmore Water System is a The postfilter water pressure remain in the water, after passing through brane, and just before going to the RO faucet. To prevent...
- Page 6 Cold Water Supply Outside (Hard Water) Soft, Cold Water Soft, ttot Water Additional Parts required. Questions? Call The Kenmore Typical Under Sink Installation :_ _:-"_ i'__', ... , ! ! Sink Drain P-_lrap Typical Remote Installation Faucet Outside...
- Page 7 3. Remove tank and filter from cabinet and set aside. NOTE: You must check and comply with all local plumbing codes. Questions? Call The Kenmore your Drinking Assembly Faucet Test, Purge System the entire manual System can...
- Page 8 5. Turn the valve handle all the way in. (clockwise) will pierce the wall of the pipe. See Fig. 5. Questions? Call The Kenmore 6. Do not connect the tubing to the fitting at this time. This will occur later in the installation.
- Page 9 Do not cut too short or the adapter will not make a leak-tight necting fitting. 7. Tighten all connections, but do not over tighten plastic connections. Questions? Call The Kenmore Under Single trap with your unit the sink onto See Figure 6. type installa-...
- Page 10 Always be sure to provide an air gap between the hose and the drain point. This will prevent from backing up into the system. Airgaps code in most areas. Questions? Call The Kenmore Faucet Water) Water Heater Airgap 1-1/2" Floor...
- Page 11 3. Do not connect the tube at this time. This will occur later in the assembly. 4. Place the storage tank next to the Reverse Osmosis Assembly. The tank can be placed upright side. Questions? Call The Kenmore FILTER Hanger Washe_ is mounted Screw (2) allow you to lift the...
- Page 12 Do not bend or kink the tubes in the process. See Figures 15 and 21. Questions? Call The Kenmore OSMOSIS of the Reverse to choose from: next to the sink faucet will surface.
- Page 13 5. Re-install the timer housing and firmly tighten the mounting screw. See Figure 14. Questions? Call The Kenmore to the to faucet. for servicing, on the hanger step 3 and screw holding housing...
- Page 14 See Figure 20. 2. Continue holding collet inward ing out. See Figure 20. O-Ring Seal Collet Collet and O-Ring Questions? Call The Kenmore THE TUBES push-in Foam Plug Review the follow- the tubes in the next washers for servicing, for heater appearance, on the hanger foam plugs.
- Page 15 CONNECT RED TUBE TO REVERSE OSMOSIS FAUCET The red tube cormection was completed in the faucet assembly steps. Questions? Call The Kenmore NOTE: Tubing lengths of the assembly ing. If tubing lengths appearance, bly on the hanger washers NOTE: Codes in the state of Massachusetts...
- Page 16 NOTE: The bleach must be removed before drinking the water. See purging the next page. Questions? Call The Kenmore after installation that the person sys- if the tank is not in package to bleach manufacturer's during page.
- Page 17 24 hour purging period is complete. 3. When the purging is finished, your Reverse Osmosis system is ready for use. Questions? Call The Kenmore on the pre- kitchen faucet the following storage tank exist, refer to the...
- Page 18 Any remaining tastes and odors are reduced uct water. Clean, high quality drinking at the faucet. Questions? Call The Kenmore SYSTEM Reverse (RO) Drinking has a hand operated water pressure Figure 24. An air-gap is built into the faucet drain water...
- Page 19 6. Faucet is activated. 7. Processed water leaves the storage tank and flows to the post filter filtered to ensure fresh taste. 8. Water flows to the Reverse Osmosis Questions? Call The Kenmore PRODUCT WATER FAUCET PRODUCT WATER drain flow...
- Page 20 7. Remove and replace the timer battery. See Figure 14. 8. Turn on the water supply to the RO system. 9. Purge the Reverse Osmosis membrane page 17 for instructions. Questions? Call The Kenmore of prod- sediment car- replace the prefilter the RO membrane...
- Page 21 5. Re-install the battery housing and firmly tighten the mounting screw. See Figure 29. Questions? Call The Kenmore operation of the See Figure 26. The at the to be sure service, review and disassemble Push o-ring seal into bottom port then follow with collet.
- Page 22 Replacement specifications, as defined by the manufacturer, Questions? Call The Kenmore sulfide water _ ... (new membraney 58 for the specific performance claims as verified and substantiated water production,...
- Page 23 Questions? Call The Kenrnore Water Line 1=800=426=9345 or visit KenrnoreWater.corn...
- Page 24 Cause: Missing flow control insert in red drain tube [Correction: or its corresponding port. Questions? Call The Kenmore Correction: If the water supply contains more than 2.0 ppm of chlorine, addi- tional filtering of the water supply to the Reverse Osmosis is needed.
- Page 25 Cause: Tubing not pushed in all the way. Cause: Tubing nicked. Cause: Outer tubing surface finish not smooth. Questions? Call The Kenmore i!!!i!!!iiiii!!!i!iii!i i!i!! i i !! Inspect and eliminate restriction or plug. Refer to installation instructions for proper drain connection. See page 9.
- Page 26 ® collet //17 ---. ' _110 1/4" red tubing Questions? Call The Kenmore Water Line 1-800-426-9345 or visit KenmoreWater.com...
- Page 27 These o-rings and collets are for replacement in the manifold housing only. They do not fit the other push-in fitting on Key No. 16. Not included. Tubing lengths for remote installations, direct replacement for colored lengths of tubing. Not illustrated. Questions? Call The Kenmore Description Screw (2 req'd) Hanger Washer (2 req'd) O-ring (2 req'd) Check Valve...
- Page 28 iiiiiiiiiiiiiiiiiiiiiiiiiiiiii!_ iiiiiiiiiiiiiiiiiiii For expert troubleshooting iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii For repair - in your home - of all major brand appliances, iiiiiiiiiiiiiiiiiiii lawn and garden equipment, iiiiiiiiiiiiiiiiiiii no matter iiiiiiiiiiiiiiiiiiii For the replacement iiiiiiiiiiiiiiiiiiii owner's manuals that you need to do-it-yourself. iiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiii For Sears professional...