5-2-4. When the RS485 is Not Connecting ....................................5-2-5. When the Ethernet is Not Connecting ..................................5-2-6. When the SD Card is Not Doing Backup Data ..............................5-2-7. When the Button is Not Working ...................................... Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 1 2010-05-17 10:34:39...
– Be sure to ground the product if there is any danger of electric leakage due to water or moisture. ● Be sure to turn off the auxiliary power switch or pull out the power plug during replacement or repair of electric parts. – There is a danger of electric shock. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 1 2010-05-17...
- You can control up to 80 Interface Modules and 256 indoor units by using BACnet Gateway. ※ You can connect 16 Interface Modules in each communication channel. - When connected Interface Modules is more, Tracking time can be long. BMS system BMS Engineering Internet SAMSUNG Engineering BACnet Gateway ⓐ ⓑ Centralized controller...
DI(Dry Contact) Digital signal input(10CH) RS-232 Debugging port Communication Port RS485 Connection port for external devices Ethernet RJ45 connector (10/100Mbps) for Ethernet Etc. Data Backup SD CARD slot (SD card is needed additional purchase) Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 2 2010-05-17 10:34:40...
(Unit condition monitoring, Function control, list of malfunction, schedule setting etc.) ● BACnet Support ※ Samsung is not responsible for BMS Engineering which create each device and objects. For futher directions regarding on BMS engineering, consult with specialized BMS related render.
(Use +Screw Driver) 2) Detach the lower cover. 3) Press lower part of cable tie and detach the cable tie. 4) Pull the bead-core part of adapter. 5) Turn connector of adapter Counterclockwise. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 2 2010-05-17 10:34:43...
Page 12
8) Unscrew at red circle part. (Use +Screw Driver) Ref.) The case of using additional Hole for install, detach from wall after detaching upper cover. 9) Push up BACnet Gateway. and pull the BACnet Gateway.0 front direction. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 3 2010-05-17 10:34:44...
Page 13
10) Unscrew 2 fixing screws at red circle. 11) Pick up the upper cover. Be careful not to damage LED on sub board. 12) As the shown picture, detach the cable between main and LCD board. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 4 2010-05-17 10:34:45...
Parts Procedure Remark Common 1) As shown picture, detach the connector pulling upper direction. 2) Unscrew 4 fixing screw on sub board. (Use +Screw Driver) 3) Detach the sub board from BACnet Gateway. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 5 2010-05-17 10:34:46...
2) Detach connector on main board, as a same way. 3) Detach connector for connecting display board. 4) Unscrew 4 fixing screw on main board. (Use +Screw Driver) 5) Push up the main board and detach it from BACnet Gateway. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 6 2010-05-17 10:34:47...
3-4. Display board Disassembly and Reassembly Parts Procedure Remark Common 1) Unscrew 4 fixing screw on display board. (Use +Screw Driver) 2) Push up the display board and detach it from upper cover. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 7 2010-05-17 10:34:48...
O/S” is showed. 5) Push [Set] button after seeing “1.Update O/S” referring the right picture. (If you can’t see “1.Update O/S” after completing 1)~4) with inserting SD card, Confirm whether your SD-Card has a problem.) Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 2 2010-05-17 10:34:49...
Page 19
8) Push [Set] button after seeing “Update RootFS”. 9) “Updating RootFS” is showed, the program writing step is progressed. 10) After showing “OK” under “Updating RootFS” like the right picture, updating of Root File System is completed. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 3 2010-05-17 10:34:49...
4) “remove SD card” is showed like the right picture, detach SD card pushing it one more time. 5) There is nothing on the display for a while after removing SD card, and system is reset. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 4 2010-05-17 10:34:50...
Page 21
Program Update Parts Procedure Remark 6) After completing application update, confirm IP, time and regular operation . Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 5 2010-05-17 10:34:50...
4) Format completed, Copy the provided OS files of BACnet Gateway to the top in SD card. - Provided OS files : rootfs.bin, vmlinux, xbl.bin, xbl- elf32, zImage 5) Remove SD card from PC after completing copy. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 6 2010-05-17 10:34:50...
3) Set IP to 192.168.0.250. - You can connect all BACnet Gateway with 192.168.0.254. 4) Type ‘telnet 192.168.0.254’ in the window of ‘Run’ after ‘Start’ button. 5) Log on the telnet. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 7 2010-05-17 10:34:51...
Page 24
BACnet Gateway with FTP. You must close FTP window after completing copy. - ftp://192.168.0.254/../../../mnt/mmc0 - Provided OS files : rootfs.bin, vmlinux, xbl.bin, xbl-elf32, zImage 9) Type the below. cd / umount /mnt/mmc0 10) Remove SD card. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 8 2010-05-17 10:34:52...
4) Format completed, Copy the application files of BACnet Gateway to the top in SD card. - Provided OS files : BACnet Gateway.tar.gz, r, star- tapp, svcapp 5) Remove SD card from PC after completing copy. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 9 2010-05-17 10:34:52...
3) Set IP to 192.168.0.250. - You can connect all BACnet Gateway with 192.168.0.254. 4) Type ‘telnet 192.168.0.254’ in the window of ‘Run’ after ‘Start’ button. 5) Log on the telnet. Samsung Electronics 4-10 BACnet Gateway_E_32400A(1)_1.indd 10 2010-05-17 10:34:53...
Page 27
- Provided OS files : BACnet Gateway.tar.gz, r, star- tapp, svcapp 8) Type the below on the telnet window. cd /mnt/mmc0 chmod 755 svcapp cd / umount /mnt/mmc0 9) Remove SD card. 4-11 Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 11 2010-05-17 10:34:53...
3) Connect to BACnet Gateway with FTP. - ftp://192.168.0.254/../../../dms 4) Copy the provided application folder to PC and Rewrite it to the application folder in BACnet Gateway connected by FTP. 5) Push [Reset] button once. Samsung Electronics 4-12 BACnet Gateway_E_32400A(1)_1.indd 12 2010-05-17 10:34:54...
Set the pattern which fits to the control pattern you want. Gateway set to 1? Tracking Fail Isn't there any indoor units? BACnet Gateway is unsuccessful in tracking. Try it again. ※ Ref. Switch for using digital input and digital output Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 1 2010-05-17 10:34:54...
Between adapter and power cable Is the output of adapter 12V? Change adapter Is the connection between Main Board Check the condition of adapter and adapter cable proper? Continue Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 2 2010-05-17 10:34:55...
Page 31
Troubleshooting When BACnet Gateway is not working(cont.) Continue Change Main Board Is BACnet Gateway working? Change Display Board Is BACnet Gateway working? Change Sub Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 3 2010-05-17 10:34:56...
5-2-2. When the LCD Display is Not Working or the Backlight is Turing OFF Start Is the connection between Main Board Check the condition of cable connection and Display Board proper? Change Display Board Is LCD working properly? Change Main Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 4 2010-05-17 10:34:56...
5-2-3. When the Static LED is Not Turning ON/OFF Start Is the connection between Main Board Check the condition of cable connection and Sub Board proper? Change Sub Board Is static LED working properly? Change Main Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 5 2010-05-17 10:34:57...
Check the condition of cable connection Is the polarity of RS485 cable correct? Check the polarity of RS485 cable [Left : +(or “A”), Right : – (or “B”)] ⓐ ⓑ Change Main Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 6 2010-05-17 10:34:57...
(Ehternet Linked, Ehernet Active) Linked : Constant Active : Flickering Check IP, Sub net mask and gateway address Are the addresses for ethernet correct? (Refer to install and service manual) Change Main Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 7 2010-05-17 10:34:59...
Is the SD card inserted in the slot? Check the SD card slot Check the SD card. Is the SD card locked? (If SD card was locked, BACnet Gateway is not doing Backup data) Change SD card Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 8 2010-05-17 10:34:59...
5-2-7. When the Button is Not Working Start Is the connection between Main Board Check the condition of cable connection and Display Board proper? Change Display Board Are buttons working properly? Change Main Board Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 9 2010-05-17 10:35:00...
Sub Board proper? Check setting value of SW2 Is the setting of dip switch for DI/Do correct? (Refer to User manual) Change Main Board Is the DI(/DO working properly? Change Sub Board Samsung Electronics 5-10 BACnet Gateway_E_32400A(1)_1.indd 10 2010-05-17 10:35:01...
Are the devices connected to BACnet Gateway less than 7 SIMs), Less than 8 DDCs. Satisfied with install limitation? Connect using less than 128 DDC connection points or install additional BACnet Gateway. 5-11 Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 11 2010-05-17 10:35:01...
1234. 5-2-11. How to know MAC address Start From local PC, access to BACnet Gateway.0 using telnet program. Log in Press Enter, after input data“ifconfigeth0” . String beside HWaddr is MAC address. Samsung Electronics 5-12 BACnet Gateway_E_32400A(1)_1.indd 12 2010-05-17 10:35:01...
5-2-12.If the connection to BACnet Gateway from the outside using internet is not working Start Is official IP address Set official IP address set in the BACnet Gateway? Is the firewall of 80.1100 port Request firewall opening open to BACnet Gateway? to network manager. 5-13 Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 13 2010-05-17 10:35:01...
Is the polarity correct? Check the polarity Less than 8 DDCs. Connect using less than 128 Are the DDCa connected to BACnet Gateway DDC connection points or install additional BACnet Satisfied with install limitation? Gateway. Samsung Electronics 5-14 BACnet Gateway_E_32400A(1)_1.indd 14 2010-05-17 10:35:02...
Are the addresses for Check IP, Subnet mask and gateway address Ethernet correct? (Refer to install and service manual) Is the device instance Check Device Instance number number for BACnet correct? Change Main Board 5-15 Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 15 2010-05-17 10:35:02...
Executed tracking proper? Check the tracking execute From local PC, access BACnet Gateway using telnet program Login Press Enter, after input data "ps -e". Reboot BACnet Gateway Find a "BACipDMS2app" Change Main Board Samsung Electronics 5-16 BACnet Gateway_E_32400A(1)_1.indd 16 2010-05-17 10:35:02...
#28 : ETH_ALIVE LED signal #29 : ETH_LINK LED signal #30 : CHECK LED signal #31~#40 : 485 TXD, RXD signal ⑤ J3 : Digital Output Connector #1,#3,#5,#7,#8 : DC12V #2,#4,#6,#7,#10 : CH6~10 DO signal Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 3 2010-05-17 10:35:05...
8. Wiring Diagram Display Board 20 PIN cable Ass'y Connector Wire-Display 40 PIN Cable (DB93-08182A) Ass'y Connector Wire-Sub (DB93-08183A) Main Board Sub Board This Document can not be used without Samsung’s authorization. Samsung Electronics BACnet Gateway_E_32400A(1)_1.indd 1 2010-05-17 10:35:06...
9. Schematic Diagram 9-1. Main Board This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 1-1 2010-05-12 6:39:25...
Page 52
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 2-3 2010-05-12 6:39:26...
Page 53
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 4-5 2010-05-12 6:39:27...
Page 54
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 6-7 2010-05-12 6:39:27...
Page 55
Schematic Diagram Schematic Diagram Main Board(cont.) & This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 8-9 2010-05-12 6:39:28...
Page 56
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 10-11 2010-05-12 6:39:29...
Page 57
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 12-13 2010-05-12 6:39:29...
Page 58
Schematic Diagram Schematic Diagram Main Board(cont.) ) - ( ) - ( ) - ( ) - ( ) - ( This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 14-15 2010-05-12 6:39:30...
Page 59
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics DMS2_E_32236A(1)_1.indd 16-17 2010-05-12 6:39:31...
Page 60
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics 9-10 DMS2_E_32236A(1)_1.indd 18-19 2010-05-12 6:39:31...
Page 61
Schematic Diagram Schematic Diagram Main Board(cont.) & This Document can not be used without Samsung’s authorization. Samsung Electronics 9-11 DMS2_E_32236A(1)_1.indd 20-21 2010-05-12 6:39:32...
Page 62
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics 9-12 DMS2_E_32236A(1)_1.indd 22-23 2010-05-12 6:39:33...
Page 63
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics 9-13 DMS2_E_32236A(1)_1.indd 24-25 2010-05-12 6:39:34...
Page 64
Schematic Diagram Schematic Diagram Main Board(cont.) This Document can not be used without Samsung’s authorization. Samsung Electronics 9-14 DMS2_E_32236A(1)_1.indd 26-27 2010-05-12 6:39:34...
Schematic Diagram Schematic Diagram 9-2. Display Board MAIN INTERFACE BUTTON CHARACTER LCD INTERFACE This Document can not be used without Samsung’s authorization. Samsung Electronics 9-15 DMS2_E_32236A(1)_1.indd 28-29 2010-05-12 6:39:35...
Schematic Diagram Schematic Diagram 9-3. Sub Board This Document can not be used without Samsung’s authorization. Samsung Electronics 9-16 DMS2_E_32236A(1)_1.indd 30-31 2010-05-12 6:39:35...