Battery Maintenance - Ferris CCW36 Series Operator's Manual

Regular Maintenance
Handle Placement Adjustment
There should be approximately 1" (2.54 cm) of clearance
in between the handle bars and the reverse speed control
levers when the forward speed control lever is in the neutral
position.
To adjust:
1. Loosen the jam nuts (B, Figure 39) that are located on
the top and bottom of the reversing linkage rod (A).
2. Adjust the linkage rod:
• To increase the amount of clearance between the
handle bars and the reverse speed control levers, turn
the linkage rod adjuster (C) clockwise.
• To decrease the amount of clearance between the
handle bars and the reverse speed control levers turn
the linkage rod adjuster counter-clockwise.
3. Once the measurement of 1" (2.54 cm) is achieved,
tighten the jam nuts against the linkage rod adjuster.
4. Repeat the process for the other side of the unit. Both
reverse speed control levers should be adjusted
equally.

Battery Maintenance

This unit is equipped with a maintenance-free BCIU1 battery.
Cleaning the Battery and Cables
1. Disconnect the cables from the battery, negative [-] cable
first (A, Figure 40).
2. Clean the battery terminals and cable ends with a wire
brush until shiny.
3. Reinstall the battery and reattach the battery cables,
positive [+] cable first (B).
4. Coat the cable ends and the battery terminals with
petroleum jelly or non-conducting grease.
WARNING
Keep open flames and sparks away from
the battery.
• Be careful when handling the battery.
• Avoid spilling electrolyte.
• Keep flames and sparks away from the battery.
• When removing or installing the battery cables,
disconnect the negative [-] cable FIRST and reconnect it
LAST. If not done in this order, the positive terminal can
be shorted to the frame by a tool.
38
Figure 39. Handle Placement Adjustment
A. Reversing Linkage Rod
B. Jam Nuts
C. Linkage Rod Adjuster
Figure 40. Battery Compartment
A. Negative [-] Cable & Terminal
B. Positive [+] Cable & Terminal
1"
(2.54 cm)
A
A
B
C
B
A
B
www.ferrisindustries.com