Table of Contents
Advertisement
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Bayliner 2302 DXILX
Summary of Contents for Bayliner 2302 DXILX
-
Page 2: Hull Identification Number
The material in this document is for information only and is subject to change without notice. While reasonable efforts have been made in the preparation of this document to assure its ac- curacy, Bayliner assumes no liability resulting from errors or omissions in this document, or from the use of information contained herein. -
Page 4: Table Of Contents
Contents Chapter 1: Welcome Aboard! 29 Fuel System 29 Fuel Fills and Vents Dealer Service 29 Fuel Filters 29 Oil Injection System (2302 FP) Boating Experience 30 Trim Tabs Qualified Maintenance 30 Power Trim and Tilt Special Care For Moored Boats 31 Navigation and Communication Equipment Engine &... - Page 5 Chapter 4: Electrical Routings 39 2302 FP Electrical Routings 39 Deck Harness Routing 40 Hull Harness Routing 40 2352 FN Electrical Routings 40 Hull Harness Routing 41 Deck Harness Routing 42 2359 FB Electrical Routings 42 Hull Harness Routing 43 Battery Cable Routings 44 Forward Deck Harness Routing 44 Mid Deck Harness Routing 45 Aft Deck...
-
Page 7: Chapter 1: Welcome Aboard
Chapter 1: Welcome Aboard! Welcome aboard! This owner’s manual supplement provides specific information about your boat that is not covered in the owner’s manual. Please study the owner’s manual and this supplement carefully, paying particular attention to Appendix A: Limited Warranty in this supplement. Keep the owner’s manual and this supple- ment on your boat in a secure, yet readily available place. -
Page 8: Special Care For Moored Boats
N O T I C E To help seal the hull bottom and reduce the possibility of gelcoat blistering on moored boats, Bayliner recommends the application of an epoxy barrier coat- ing, such as Interlux, Interprotect 2000E/2001E. The barrier coating should be covered with several coats of anti-fouling paint. -
Page 9: Safety Standards
Chapter 1: Welcome Aboard! Safety Standards Your boat’s mechanical and electrical systems were designed to meet safety stan- dards in effect at the time it was built. Some of these standards were mandated by law; all of them were designed to insure your safety, and the safety of other people, vessels and property. -
Page 10: Chapter 2: Specifications & Features
Chapter 2: Specifications & Features 2302FP Dimensions and Tank Capacities Overall Bridge Draft Water Fuel Tank Beam Length Clearance (Drive Up) Capacity Capacity 23’5" 7’11" 8’5" 1’7" 8 gal. 101 gal. Layout View coaming caps coaming caps storage storage galley galley step step... - Page 11 Chapter 2: Specifications & Features Transom Hardware TRANSOM STERN EYE GARBOARD DECK DRAIN TRIM TAB (TYPICAL) DRAIN (TYPICAL) (TYPICAL) Foredeck Hardware HORN ANCHOR ANCHOR NAV. LIGHT STORAGE ROLLER CLEAT (TYPICAL) FWD. STBD. 23’ Trophy • Owner’s Manual Supplement...
-
Page 12: Cockpit Features
Chapter 2: Specifications & Features Helm Dash TACHOMETER VOLTMETER FUEL SPEEDOMETER ACCESSORY ACCESSORY SWITCHES SWITCHES STEERING CIRCUIT WHEEL BREAKERS Cockpit Features TRIM TAB FUEL FILL BATTERY PUMP ACCESS LOCATION HOLDERS ENGINE ACCESS HAWSE PIPE (TYPICAL) HOLDER (TYPICAL) FISHWELL (TYPICAL) 23’ Trophy • Owner’s Manual Supplement... -
Page 13: Warning Labels
Chapter 2: Specifications & Features Warning Labels FUEL FILL & FUELING WARNING LABELS STBD. FWD. EMERGENCY SHUTDOWN WARNING LABEL TRIM TAB WARNING LABEL CAPACITY WARNING LABEL Bilge Pump Routing FWD. BILGE PUMP ROUTING AFT BILGE PUMP ROUTING BILGE PUMP & BILGE PUMP &... - Page 14 Chapter 2: Specifications & Features Head & Waste Tank System (LX Only) HEAD SYSTEM ROUTING VENTED LOOP PORT FWD. SEA WATER TOILET PICK-UP (OPTIONAL) MACERATOR ROUTING PORT DECK TO PUMP- OUT MACERATOR FITTING IN DECK WASTE PUMP- OUT FITTING HOLDING TANK FWD.
-
Page 15: Fuel System
Chapter 2: Specifications & Features Fuel System VIEW OF AFT DECK STBD. AFT FUEL FILL DECK FUEL TANK STBD. TO VENT FUEL MOTOR HOSE FILL Freshwater System FRESHWATER ROUTING WATER FILL LOCATION WATER WATER FILL TO GALLEY WATER TANK PORT SIDE TANK ON DECK SINK... -
Page 16: 2352 Fn Features And Systems
Chapter 2: Specifications & Features 2352 FN Features and Systems Dimensions and Tank Capacities Overall Bridge Draft Water Fuel Tank Beam Length Clearance (Drive Up) Capacity Capacity 23’5" 7’11" 8’5" 1’7" 8 gal. 101 gal. Layout View coaming caps coaming caps galley galley storage... - Page 17 Chapter 2: Specifications & Features Transom Hardware TRANSOM DECK DRAIN GARBOARD STERN EYE TRIM TAB (TYPICAL) DRAIN (TYPICAL) (TYPICAL) Foredeck Hardware HORN ANCHOR ANCHOR NAV. LIGHT STORAGE ROLLER CLEAT (TYPICAL) FWD. STBD. 23’ Trophy • Owner’s Manual Supplement...
- Page 18 Chapter 2: Specifications & Features Helm Dash TACHOMETER VOLTMETER FUEL SPEEDOMETER ACCESSORY ACCESSORY SWITCHES SWITCHES STEERING WHEEL CIRCUIT BREAKERS Cockpit Features ENGINE FISHWELL ROD HOLDER BAITWELL ACCESS (TYPICAL) (TYPICAL) HAWSE PIPE PORT 23’ Trophy • Owner’s Manual Supplement...
- Page 19 Chapter 2: Specifications & Features Warning Labels FUEL FILL & FUELING WARNING LABELS FOREDECK WARNING LABEL FWD. TRIM TAB WARNING LABEL CAPACITY WARNING LABEL EMERGENCY SHUTDOWN WARNING LABEL STBD. Bilge Pump Routing AFT BILGE PUMP ROUTING FWD. BILGE PUMP ROUTING BILGE PUMP &...
- Page 20 Chapter 2: Specifications & Features Fuel System FUEL FILL ON TO FUEL TO FUEL FUEL LINE STBD. DECK FITTING ON VENT IN TO ENGINE STBD. DECK HULL FWD. ENGINE COMPARTMENT STBD. FUEL TANK Freshwater System FRESHWATER ROUTING WATER FILL LOCATION WATER WATER FILL TO GALLEY...
- Page 21 Chapter 2: Specifications & Features Head & Waste Tank System (LX Only) VENTED LOOP PORT FWD. TOILET SEA WATER PICK-UP (OPTIONAL) MACERATOR ROUTING TO PUMP- OUT FITTING IN DECK MACERATOR HOLDING TANK PORT TOILET WATER PICK-UP TO WASTE PUMP- WASTE OUT FITTING TANK PORT DECK...
-
Page 22: 2359 Fb Features And Systems
Chapter 2: Specifications & Features 2359 FB Features and Systems Dimensions and Tank Capacities Overall Bridge Draft Water Fuel Tank Beam Length Clearance (Drive Up) Capacity Capacity 23’5" 7’4" 8’5" 1’7" 20 gal. 87 gal. Layout View coaming cap removable fishwell jumpseat dinette area... - Page 23 Chapter 2: Specifications & Features Transom Hardware MIDSHIP STORAGE DRAIN TRANSOM STERN EYE GARBOARD TRIM TAB (TYPICAL) DRAIN (TYPICAL) Foredeck Hardware DECK CLEAT (TYPICAL) HATCH FWD. PORT ANCHOR NAV. LIGHT DECK CLEAT ROLLER (TYPICAL) PIPE 23’ Trophy • Owner’s Manual Supplement...
- Page 24 Chapter 2: Specifications & Features Helm ACCESSORY SWITCHES TROPHY PUMPS LIGHTS ANCHOR STBD. PORT HORN PORT STBD. NAV. ACCY COCKPIT BAIT FWD. FISH FISH WIPER WIPER BILGE WELL BILGE WELL WELL COMPASS HELM TACHOMETER TEMPERATURE DASH PANEL SPEEDOMETER BLOWER IGNITION FUEL VOLTMETER SWITCH...
- Page 25 Chapter 2: Specifications & Features Warning Labels “DO NOT BOARD POTABLE WATER FUEL FILL & FOREDECK” WARNING LABEL FUELING WARNINGS LABEL STBD. Fuel System FUEL TANK TO FUEL FITTING AFT CABIN VENT ON DECK ENTRY DOOR FUEL TANK STBD. DECK FUEL FILL FITTING ENGINE...
- Page 26 Chapter 2: Specifications & Features Bilge Pumps FWD. BILGE PUMP ROUTING AFT BILGE PUMP ROUTING FWD. BILGE PUMP THRU-HULL FWD. BILGE PUMP THRU-HULL & FLOAT SWITCH & FLOAT SWITCH Baitwell System A. TANK B. OVERFLOW DRAIN C. AERATOR WAND D. AERATOR E.
- Page 27 Chapter 2: Specifications & Features Freshwater System BREAKAWAY VIEW OF PORT HULLSIDE PORT SIDE OF DECK FWD. WATER TANK HOSE TO VENT HOSE FITTING ON DECK WATER WATER PUMP (LX ONLY) TANK WATER SYSTEM ROUTING WATER TANK FITTING GALLEY SINK WATER TANK WATER PUMP...
- Page 28 Chapter 2: Specifications & Features Head & Waste System (LX Only) TOILET RAW WATER VENTED WASTE PUMP- PICK UP LOOP DECK OUT FITTING FWD. TRANSOM WASTE TANK SYSTEM (MACERATOR OPTION SHOWN) WASTE TANK HOSE FROM UNDERWATER LOCATION HEAD DISCHARGE HOSE TO MACERATOR STBD.
-
Page 29: Chapter 3: General Systems
Chapter 3: General Systems Electrical System Read this section and the electrical sections of the owner’s manual and all acces- sory manuals included in your boat owner’s packet. Electrical system drawings are provided in Chapter 4 and Chapter 5 of this supplement. D A N G E R ! DANGER EXTREME FIRE, SHOCK &... -
Page 30: 12-Volt Dc Electrical System
Chapter 3: General Systems 12-Volt DC Electrical System Your boat is equipped with a 12-volt DC (direct current) system. Fuses and Circuit Breakers • Fuses and circuit breakers for engines and main accessory power may be on the DC main distribution panel and on the battery switch panel (if installed). •... -
Page 31: Battery Charger (2359 Fb Lx)
Chapter 3: General Systems C A U T I O N ! SYSTEM DAMAGE HAZARD! NEVER disconnect battery cables or turn off the battery switch while your engine is running as this can cause damage to your boat’s electrical components. Battery Charger (2359 FB LX) Your boat may be equipped with a battery charger located in the aft port cabin. -
Page 32: Ac Electrical System (2359 Fb)
Chapter 3: General Systems AC Electrical System (2359 FB) Your boat may come equipped with an optional AC (alternating current) system which is energized from shore power. Shore power is supplied to your boat using a 120v/30 amp shore power receptacle. D A N G E R ! DANGER FIRE, EXPLOSION &... - Page 33 Chapter 3: General Systems C A U T I O N ! SHOCK & ELECTRICAL SYSTEM DAMAGE HAZARD! • DO NOT pinch shore power cords in doors or hatches, or coil the shore power cord too tightly. These situations can create enough heat to start a fire. •...
-
Page 34: Propulsion
Chapter 3: General Systems Propulsion Engine The owner’s packet contains detailed engine operation and maintenance manuals. Read these manuals before operating or performing maintenance to the engine. Bilge Blower Your boat may feature a bilge (TYPCAL) BLOWER HOSE ROUTING blower system. The bilge blower CROSS SECTION VIEW OF TRANSOM removes fumes from the engine compartment and draws fresh air... -
Page 35: Fuel System
Chapter 3: General Systems Fuel System Read the fuel section of the owner’s manual and the engine operation manual, pay- ing special attention to the subject of fuel recommendations. WA R N I N G ! FIRE, EXPLOSION AND OPEN FLAME HAZARD! •... -
Page 36: Trim Tabs
Chapter 3: General Systems Trim Tabs TYPICAL TRIM TAB ROCKER SWITCHES The trim tabs may be used to help keep your (LOCATED AT HELM) boat level at cruising speeds. Trim tabs are controlled by two rocker switches located at the helm station. Before using the trim tabs, read the trim tab operation manual included in your yacht’s owner’s packet and observe the following:... -
Page 37: Navigation And Communication Equipment
Chapter 3: General Systems Navigation and Communication Equipment The owner’s packet contains operation manuals for all navigation & communica- tion equipment installed on your boat. Read and understand these manuals before using these systems. Additionally, read the warnings below carefully and follow all safety instructions. -
Page 38: Am/Fm Cassette Stereo
Chapter 3: General Systems AM/FM Cassette Stereo N O T I C E AM radio reception may be impaired in areas where reception is limited or any- time the engines are running. Alcohol Stove NOTICE Always keep an approved ABC-type fire extinguisher in your boat. WA R N I N G ! SEVERE BURN AND FIRE HAZARD! •... -
Page 39: Bilge Pump Testing
Chapter 3: General Systems Bilge Pump Testing Bilge pumps must be tested often to verify they are working properly. To test a bilge pump, activate the dash-mounted switch and verify that the bilge water is being pumped overboard. If bilge water is present and the pump motor is running but not pumping, inspect the discharge hose for a kink or collapsed area. -
Page 40: Fresh Water System
Chapter 3: General Systems Fresh Water System Your boat is equipped with a pressure-demand freshwater (potable) system. Refer to the Systems and Diagrams section of this supplement, and read the following; • Open your taps and depressurize the system when not in frequent use to increase the life of your freshwater system. -
Page 41: Head System
Chapter 3: General Systems Head System Portable Head Your boat may feature a portable head (toilet). Read the manufacturer’s operating instructions supplied in your owner’s packet before using your portable head. Marine Head with Holding Tank (LX Only) Your boat may come equipped with a marine head (toilet) and 15 gallon waste holding tank system. -
Page 42: Fishwells
Chapter 3: General Systems Fishwells UNDERSIDE OF FISHWELL FISHWELL Your boat features two fishwells DRAIN PUMP in the aft cockpit. The fishwells can be drained by activating the ACCESS HATCH switches at the helm. If the fish- IN AFT COCKPIT wells do not draining properly, check for clogging or kinks in the drain hoses. -
Page 43: Recirculation System (2352 Fn, 2302 Fp)
Chapter 3: General Systems Recirculation System (2352 FN, 2302 FP) RECIRCULATION SYTEM A. TANK B. OVERFLOW DRAIN C. AERATOR WAND D. AERATOR E. BAITWELL PUMP F. SEACOCK G. Y - VALVE H. TO HULLSIDE DRAIN LED LIGHT J. RECIRCULATION DRAIN Your baitwell may feature a recirculation system. -
Page 44: Canvas Top Installation (2302 Fp, 2352 Fn)
Chapter 3: General Systems Canvas Top Installation (2302 FP, 2352 FN) 1. Slide the eye ends of the forward legs (A) into the forward deck hinges and insert the pins. 2. Unfold the canvas top and slide the eye ends of the middle legs (B) into the mid- dle deck hinges and insert the pins. -
Page 45: Chapter 4: Electrical Routings
Chapter 4: Electrical Routings 2302 FP Electrical Routings Deck Harness Routing WINDSHIELD WIPER (OPTION) SPEAKER SHIFTER COMPASS LIGHTS TO AFT SECTION HORN BAITWELL NAV. LIGHTS PORT. FWD. SPEAKER WINDSHIELD DASH STEREO WIPER (OPTION) FISHWELL COURTESY TO FORWARD PUMP LIGHT SECTION TRIM TAB PUMP FUEL FILL... -
Page 46: Hull Harness Routing
Chapter 4: Electrical Routings Hull Harness Routing BILGE PUMP & FUEL TANK MACERATOR BILGE PUMP & FLOAT SWITCH SENDER UNIT (OPTION) FLOAT SWITCH STBD. STARTING POINT 2352 FN Electrical Routings Hull Harness Routing MACERATOR FUEL TANK BILGE PUMP & BILGE PUMP & (OPTION) FLOAT SWITCH SENDER UNIT... -
Page 47: Deck Harness Routing
Chapter 4: Electrical Routings Deck Harness Routing SHIFTER DASH WINDSHIELD HORN WIPER (OPTION) NAV. LIGHTS PORT FWD. LIGHTS STEREO COMPASS WINDSHIELD WIPER (OPTION) STBD. FUEL FILL COURTESY GROUND LIGHT PORT FISHWELL TRIM TAB PUMP TO ENGINE PORT ACCESSORY STBD. FISHWELL GROUNDING PORT SPEAKER... -
Page 48: 2359 Fb Electrical Routings
Chapter 4: Electrical Routings 2359 FB Electrical Routings Hull Harness Routing FWD. BILGE PUMP DASH PORT FUEL TANK SENDING UNIT FWD. HARDTOP BAITWELL PUMP AFT BILGE PUMP GROUND BLOCK BLOWER BATTERY MACERATOR TRIM TAB BONDING (OPTION) PUMP WIRES 23’ Trophy • Owner’s Manual Supplement... -
Page 49: Battery Cable Routings
Chapter 4: Electrical Routings Battery Cable Routings POSITIVE BATTERY CABLE ROUTINGS MOTOR TRIM PORT BATTERIES ENGINE BATTERY STARTER SWITCH NEGATIVE BATTERY CABLE ROUTING PORT MOTOR TRIM BATTERIES ENGINE STARTER 23’ Trophy • Owner’s Manual Supplement... -
Page 50: Forward Deck Harness Routing
Chapter 4: Electrical Routings Forward Deck Harness Routing SHIFTER DASH QUARTER BERTH LIGHT COMPASS SPEAKER HORN FWD. NAV. LIGHTS V-BERTH LIGHT NOTE; VIEW IS OF UNDER- SIDE OF DECK Mid Deck Harness Routing BATTERY SWITCH STBD. BREAKOUT TO HARDTOP WATER PUMP REFRIGERATOR TO DASH... -
Page 51: Aft Deck
Chapter 4: Electrical Routings Aft Deck FUEL FILL GROUND COCKPIT LIGHT COCKPIT LIGHT FISHWELL FISHWELL PUMP PUMP ENGINE ENGINE TRIM PLUG GROUND PUMP NOTE; VIEW IS OF UNDER- SIDE OF DECK AC Panel Routings AC PANEL FROM SHORE TO OUTLET POWER REFRIGERATOR TO BATTERY... -
Page 52: Chapter 5: Wiring Diagrams
Chapter 5: Wiring Diagrams 2302 FP Electrical System 23’ Trophy • Owner’s Manual Supplement... -
Page 53: 2352 Fn Electrical System
Chapter 5: Wiring Diagrams 2352 FN Electrical System 23’ Trophy • Owner’s Manual Supplement... -
Page 54: 2359 Fb Ac Electrical System
Chapter 5: Wiring Diagrams 2359 FB AC Electrical System 23’ Trophy • Owner’s Manual Supplement... -
Page 55: 2359 Fb Dc Electrical System
Chapter 5: Wiring Diagrams 2359 FB DC Electrical System 23’ Trophy • Owner’s Manual Supplement... -
Page 56: Appendix A: Limited Warranty
ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED TO THE DURATION OF ONE YEAR. Neither Bayliner nor the selling dealer shall have any responsibility for loss of use of the boat, loss of time, inconvenience, commercial loss or consequential damages. - Page 57 Owner’s Notes...
- Page 58 Owner’s Notes...
- Page 60 Part Number 1693938 Bayliner • P.O. Box 9029 • Everett, WA 98206 • (360) 435-5571...
Need help?
Do you have a question about the 2302 DXILX and is the answer not in the manual?
Questions and answers