HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING PARTS DEPARTMENT 800-427-1244 or 310-537-3700 FAX: 800-672-7877 or 310-637-3284 SERVICE DEPARTMENT/TECHNICAL ASSISTANCE 800-478-1244 or 310-537-3700 FAX: 310- 537-4259 WARRANTY DEPARTMENT 888-661-4279, or 310-661-4279 FAX: 310- 537-1173 MAIN 800-421-1244 or 310-537-3700 FAX: 310-537-3927...
FCG1 CONCRETE SAW— SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS Safety precautions should be followed at all times when operating Lethal Exhaust Gases this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to Engine exhaust gases contain poisonous yourself and others.
Page 7
FCG1 CONCRETE SAW— SAFETY MESSAGE ALERT SYMBOLS Accidental Starting Respiratory Hazard ALWAYS place the engine ON/OFF switch in the OFF position, when the saw ALWAYS wear approved respiratory protection. is not in use. Over Speed Conditions Sight and Hearing hazard NEVER tamper with the factory settings of the engine governor or settings.
Fire or explosion could result from ■ NEVER use accessories or attachments, which are not fuel vapors , or if fuel is spilled on a hot! recommended by Multiquip for this equipment. Damage to engine. the equipment and/or injury to user may result.
Page 9
FCG1 CONCRETE SAW— RULES FOR SAFE OPERATION GENERAL SAFETY DIAMOND BLADE SAFETY ■ ALWAYS read, understand, and follow procedures in ■ Use appropriate steel centered diamond blades Operator's Manual before attempting to operate equipment. manufactured for use on concrete saws. ■...
Page 10
FCG1 CONCRETE SAW— RULES FOR SAFE OPERATION EMERGENCIES ■ ALWAYS know the location of the nearest fire extinguisher . ■ ALWAYS know the location of the nearest and first aid kit . ■ In emergencies always know the location of the nearest phone or keep a phone on the job site .
FCG1 CONCRETE SAW— OPERATION AND SAFETY DECALS Machine Operation And Safety Decals The FCG1 Concrete Saw is equipped with a number of safety decals. These decals are provided for operator safety and maintenance information. Should any of these decals become unreadable, replacements can be obtained from your dealer. Figure 1.
FCG1 CONCRETE SAW— SPECIFICATIONS (SAW) Side View Front View Figure 2. FCG1 Concrete Saw Dimensions i f i o i t y l l e s i . n I y l l y l l s i a & r e t .
FCG1 CONCRETE SAW—FAMILIARIZATION/ CONTROLS & COMPONENTS CONTROLS & COMPONENTS FAMILIARIZATION This FCG1-6H SlabSaver Saw is designed for wet or dry sawing Figures 3 shows the location of the basic controls or components, of concrete slabs utilizing diamond blades. The saw has been for the FCG1 Concrete Saw.
FCG1 CONCRETE SAW— BASIC ENGINE (HONDA ENGINE SHOWN) Figure 4. Engine Controls and Components Choke Lever – Used in the starting of a cold engine, or in INITIAL SERVICING cold weather conditions. The choke enriches the fuel The engine (Figure 4) must be checked for proper lubrication and mixture.
Page 17
FCG1 CONCRETE SAW — GUARDS, COVERS AND V-BELTS V-belt Alignment and Tensioning WARNING This concrete saw is equipped with a premium V-belt that has been aligned and tensioned by factory personnel. The V-belt NEVER operate the saw without blade guards must be aligned and tensioned for proper operation of the saw.
Page 18
FCG1 CONCRETE SAW — GUARDS, COVERS AND V-BELTS 3. Tighten the adjusting hex screw (4) while holding the engine in place to maintain pulley alignment. (a screwdriver can be used as a lever at the rear belt guard mounting boss to hold the back of the engine while adjusting V-belt tension.) 4.
Page 19
FCG1 CONCRETE SAW — BLADES SAW BLADES 2. Edge of the Steel Core - Check the diameter edge for discoloration (blue oxidation) indicating an overheating For maximum performance and return on investment use: condition caused by insufficient cooling water/air. Overheating of blades may lead to loss of core tension and/ or increase the possibility for blade failure.
FCG1 CONCRETE SAW — BLADE PLACEMENT 5. Inner Flange (Collar) - This flange is fixed upon the blade WARNING shaft. The inside surface of the flange must be free of debris and permit a tight closure on the surface of the blade. Failure to thoroughly inspect the diamond Blade Selection blade for operational safety could result in...
Page 21
FCG1 CONCRETE SAW — BLADE PLACEMENT 6. Use the provided blade nut and blade shaft locking wrenches (Figure 12) to install the diamond blade. Reference items 1 - 5 and Figure 12 on page 20. ■ While holding the blade shaft with the locking wrench, remove the blade hex nut (clockwise direction) and outer blade flange.
FCG1 CONCRETE SAW — INSPECTION — PRE-INSPECTION Before Starting 1. Read safety instructions at the beginning of manual. 2. Clean the saw, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required.
FCG1 CONCRETE SAW — INITIAL START-UP CAUTION CAUTION CAUTION CAUTION CAUTION 3. Place the Engine ON/OFF switch (Figure 18) in the "ON" DO NOT attempt to operate the saw until position. the Safety, General Information and Inspection sections of this manual have been read and thoroughly understood.
Page 24
FCG1 CONCRETE SAW — OPERATION 5. Rotate the throttle lever (Figure 20) halfway between fast 8. Before the saw is placed into operation, run the engine for and slow for starting. All sawing is done at full throttle . The several minutes.
FCG1 CONCRETE SAW — MAINTENANCE 3. Adjust the front pointer so it just touches the side of the See the engine manual supplied straight-edge or level. NOTE with your machine for appropriate 4. Remove the straight-edge or level. engine maintenance schedule and troubleshooting guide for problems.
Page 26
FCG1 CONCRETE SAW — MAINTENANCE Dispose of used oil properly. DO Drive Belt NOT pour used oil on the ground, Refer to pages 17 to 18 of this manual for Drive Belt adjustment down a drain, or throw in the trash. NOTE procedures and Removal and Replacement procedures.
EXPLANATION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusive) where a particular part is used. Model Number-Where indicated, this shows that the corresponding part is utilized only with this specific model number or model number variant.
P/N 36099 (ISO Blue) P/N 25482 P/N 13118 P/N 25485 (large) MODEL “BELT DRIVE” SERIAL NO. CONTACT MULTIQUIP WARNING SERVICE DEPARTMENT California - Proposition 65 Warning WARNING Engine exhaust and some of its byproducts are known to the State of California to cause...
Page 33
FCG1 CONCRETE SAW — DECAL LOCATOR DECAL LOCATOR PART NO. PART NAME QTY. REMARKS 25485 DECAL, SLAB SAVER LARGE 25482 DECAL, MQ LOGO 3.0 X 3-3/4 11247 DECAL, SAFETY CLOTHING ISO BLACK 36099 DECAL, SAFETY CLOTHING ISO BLUE 13118 DECAL, POWDER COATED SERIAL NUMBER PLATE ........
Page 39
FCG1 CONCRETE SAW — UNDERCARRIAGE ASSY. UNDER CARRIAGE ASSY. PART NO. PART NAME QTY. REMARKS 25368 BAR, PIVOT SHAFT 25407 WHEEL, 5 X .625 X 1.5 BALL BRG 15028 COLLAR, SET 5/8 DIA 25379 BEARING, 5/8 FLANGE UHMW 9154 SCREW, HHC 3/8 - 16 X 1-3/4 2064 ROD END, 3/8 -24 FEM RH 2199...
Page 43
WRENCH, SERVICE 15/16 OPEN END 25488 WRENCH, 5/8 COMBO 9SWG BLADE, DIAMOND BACK ......... 1 ..ORDER FROM UNIT SALES DEPT. Multiquip Diamond Back Blades ORDER p/n 9SWG FCG1 CONCRETE SAW — OPERATION & PARTS MANUAL — REV. #1 (10/08/02) — PAGE 43...
Page 44
HONDA GX200QXC9 — AIR CLEANER (CYCLONE) ASSY. AIR CLEANER (CYCLONE) ASSY. PAGE 44 — FCG1 CONCRETE SAW— OPERATION & PARTS MANUAL — REV. #1 (10/08/02)
Page 45
HONDA GX200QXC9 — AIR CLEANER (CYCLONE) ASSY. AIR CLEANER (CYCLONE) ASSY. PART NO. PART NAME QTY. REMARKS 16271ZE1000 GASKET, ELBOW 17210ZE1505 ELEMENT, AIR CLEANER (DUAL) ......1 ..... INCLUDES ITEMS W/ 17218ZE1821 FILTER (OUTER) 17219733010 GASKET, AIR CLEANER COVER 17230ZE1841 COVER, AIR CLEANER (DUAL) 17232891000 GROMMET, AIR CLEANER 17238ZE7010...
HONDA GX200QXC9 — CARBURETOR ASSY. CARBURETOR ASSY. PART NO. PART NAME QTY. REMARKS 16010ZE1812 GASKET SET 16011ZE0005 VALVE SET, FLOAT 16013ZE0005 FLOAT SET 16015ZE0831 CHAMBER SET, FLOAT 16016ZH7W01 SCREW SET 16024ZE1811 SCREW SET, DRAIN 16028ZE0005 SCREW SET B 16044ZE0005 CHOKE SET 16100ZL0V21 CARBURETOR ASSEMBLY (BE64F B) ....1 .....
Page 50
HONDA GX200QXC9 — CONTROL ASSY. CONTROL ASSY. PAGE 50 — FCG1 CONCRETE SAW— OPERATION & PARTS MANUAL — REV. #1 (10/08/02)
HONDA GX200QXC9 — CONTROL ASSY. CONTROL ASSY. PART NO. PART NAME QTY. REMARKS 16500ZH8853 CONTROL ASSEMBLY (CYCLONE) ......1 ..... INCLUDES ITEMS W/ 16551ZL0000 ARM, GOVERNOR 16555ZE1000 ROD, GOVERNOR 16561ZL0000 SPRING, GOVERNOR 16562ZE1020 SPRING, THROTTLE RETURN 16571ZH8020 LEVER, CONTROL 16574ZE1000 SPRING, LEVER 16575ZH8000 WASHER, CONTROL LEVER 16576891000...
Page 57
HONDA GX200QXC9 — CYLINDER BARREL ASSY. CYLINDER BARREL ASSY. PART NO. PART NAME QTY. REMARKS 12000ZL0810 CYLINDER ASSEMBLY (OIL ALERT) ....1 ..... INCLUDES ITEMS W/ 15510ZE1033 SWITCH ASSEMBLY, OIL LEVEL 16506ZL0000 GOVERNOR ASSEMBLY 16531ZE1000 SLIDER, GOVERNOR 16541ZE1000 SHAFT, GOVERNOR ARM 90131ZE1000 BOLT, DRAIN PLUG 90451ZE1000...
Page 58
HONDA GX200QXC9 — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. PAGE 58 — FCG1 CONCRETE SAW— OPERATION & PARTS MANUAL — REV. #1 (10/08/02)
Page 59
HONDA GX200QXC9 — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. PART NO. PART NAME QTY. REMARKS 12204ZE1306 GUIDE, VALVE OS (OPTIONAL) 12205ZE1315 GUIDE, EXHAUST VALVE OS (OPTIONAL) 12210ZL0000 CYLINDER HEAD ...........1 ..... INCLUDES ITEMS W/ 12216ZE5300 CLIP, VALVE GUIDE 12251ZL0003 GASKET, CYLINDER HEAD 12310ZE1841 COVER, HEAD (BREATHER TUBE) 12391ZE1000...
Page 60
HONDA GX200QXC9 — FAN COVER ASSY. FAN COVER ASSY. PAGE 60 — FCG1 CONCRETE SAW— OPERATION & PARTS MANUAL — REV. #1 (10/08/02)
Page 61
HONDA GX200QXC9 — FAN COVER ASSY. FAN COVER ASSY. PART NO. PART NAME QTY. REMARKS 19610ZL0000ZB COVER, FAN *R8* BRIGHT RED 19611ZH8810 PLATE, SIDE (OIL ALERT) 19613ZE1010 CLAMP, CORD 19630ZH8000 SHROUD 32197ZH8003 SUB- HARNESS 36100ZH7003 SWITCH ASSEMBLY, ENGINE STOP 36101ZE1010 WIRE, STOP SWITCH 370MM 90013883000 BOLT, FLANGE 6 X12 (CT200)
Page 77
HONDA GX200QXC9 — LABELS ASSY. LABELS ASSY. PART NO. PART NAME QTY. REMARKS 87521ZL0010 EMBLEM 87522ZH9000 LABEL, CAUTION 87528ZE1810 MARK, CHOKE 87532ZH8810 MARK, OIL ALERT (E) 87534ZE1841 LABEL, AIR CLEANER CAUTION 87535ZE1840 MARK, AIR CLEANER SALES POINT 89218ZE1000 WRENCH, SPARK PLUG FCG1 CONCRETE SAW —...
Page 78
Items purchased in kits. respect to which damages are claimed, and in must be approved by Multiquip prior to no event shall Multiquip be liable for loss of shipment. The sender will be notified of any material profit or good will or for any other special, received that is not acceptable.
Need help?
Do you have a question about the FCG1 SERIES and is the answer not in the manual?
Questions and answers