1. Manuals
  2. Brands
  3. Napoleon Manuals
  4. Indoor Fireplace
  5. GVF36N
  6. Installation and operation instructions manual

Napoleon GVF36N Installation And Operation Instructions Manual

Unvented millivolt system gas fireplace
Hide thumbs Also See for GVF36N:
Table of Contents

Advertisement

Quick Links

Download this manual
INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER.
CERTIFIED UNDER AMERICAN NATIONAL STANDARDS, ANSI Z21.11.2, VOLUME II FOR UNVENTED ROOM HEATERS.
UNVENTED MILLIVOLT SYSTEM
INSTALLATION AND OPERATION INSTRUCTIONS FOR
WARNING: If the information in these instructions is not followed exactly, a fi re or
explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other fl ammable vapours and liquids in the vicinity of
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
• Immediately call your gas supplier from
by a qualifi ed installer, service agency or the gas supplier.
This is an unvented gas-fi red heater that uses air (oxygen) from the room in which it is
installed. Provisions for adequate combustion and ventilation air must be provided.
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031
$10.00
UNVENTED GAS FIREPLACE
NATURAL GAS MODEL
PROPANE GAS MODEL
CERTIFIED FOR UNITED STATES USING ANSI METHODS
FOR YOUR SAFETY
this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
www.napoleonfireplaces.com • ask@napoleon.on.ca
GVF36N
GVF36P
a neighbour's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier,
call the fi re department.
Installation and service must be performed
1
W415-0297 / K / 11.20.07

Advertisement

Table of Contents
loading

Related Manuals for Napoleon GVF36N

Summary of Contents for Napoleon GVF36N

  • Page 1 INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER. CERTIFIED UNDER AMERICAN NATIONAL STANDARDS, ANSI Z21.11.2, VOLUME II FOR UNVENTED ROOM HEATERS. UNVENTED MILLIVOLT SYSTEM INSTALLATION AND OPERATION INSTRUCTIONS FOR UNVENTED GAS FIREPLACE GVF36N NATURAL GAS MODEL GVF36P PROPANE GAS MODEL CERTIFIED FOR UNITED STATES USING ANSI METHODS WARNING: If the information in these instructions is not followed exactly, a fi...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS PG 3-4 INTRODUCTION 9-10 OPTIONAL BLOWER Warranty INSTALLATION General Instructions GD65 Fan Installation General Information GD36 Termostatic Sensor Control Care of Glass Door, Catalytic Tiles & Plated Parts 11-12 OPERATION / MAINTENANCE Operating Instructions INSTALLATION Maintenance Combustion and Ventilation Air Provisions Oxygen Depletion Sensor Pilot Cleaning Determining Confi...
  • Page 3 ® ® ® ® The following materials and workmanship in your new NAPOLEON® gas fireplace are warranted against defects for as long as you own the fireplace. This covers: combustion chamber, heat exchanger, stainless steel burner, phazer™ logs and embers, gold plated parts against tarnishing, porcelainized enameled components and aluminum extrusion trims.

  • Page 4: General Instructions

    Suitable for mobile home installation where the mobile GENERAL INSTRUCTIONS home has been permanently placed on its site. This heat- THIS GAS FIREPLACE SHOULD BE INSTALLED AND er must not be installed in a bedroom or bathroom. SERVICED BY A QUALIFIED INSTALLER to conform with *This fireplace may be installed in an aftermarket per- local codes.

  • Page 5: Installation

    INSTALLATION COMBUSTION & VENTILATION DETERMINING CONFINED OR UNCON- AIR PROVISIONS FINED SPACE This heater shall not be installed in a confined space To determine the volume of the room where the heater is to or unusually tight construction unless provisions are be installed, multiply the width x the length x the ceiling height provided for adequate combustion and ventilation air.

  • Page 6: Gas Installation

    Unusually tight construction is defined as con- GAS INSTALLATION struction where: Proceed once the vent installation is complete. a) Walls and ceilings exposed to the outside atmosphere have a continuous water vapour retarder with a rating of 1 perm (6 x 10 kg per pa-sec-m ) or less with openings NOTE: All gas connections must be contained within...

  • Page 7: Minimum Framing Clearances

    Combustible materials may be installed fl ush with the front of MINIMUM FRAMING CLEARANCES the fi replace but must not cover any of the black face-areas of the fi replace. Non-combustible material (brick, stone or ceramic It is best to frame your fi replace after it is positioned. Use 2x4’s tile) may protrude in these areas.

  • Page 8: Finishing

    fi rebox. MESH NOTE: PHAZER logs and glowing embers exclusive to Napoleon Fireplaces, provide a unique and realistic glow- ing effect that is different in every installation. Take the time to carefully position the glowing embers for a maximum glowing effect.

  • Page 9: Optional Blower Installation

    L36 LOUVRE INSTALLATION CLIPS HOOD FIGURE14 Attach the hood by pressing the top fl ange into the clips along the top of the louvre opening. FLANGE Secure using a screw through the centre slot. CENTRE SLOT UPPER LOUVRES Insert the louvre tabs into the slots located at the top left and SLOT right corners of the unit.

  • Page 10: Gd65 Fan Installation

    Slide the fan assembly FIGURE 19 past the controls and into FIGURE 22 the clip. Secure using the lock washer and nut provided. Plug the harness cord into the recep- tacle. Attach the connectors from the black and red wires to the blower.

  • Page 11: Operation / Maintenance

    OPERATION / MAINTENANCE If heater shuts off, do not relight until you provide fresh internal paints and lubricants used in the manufacturing air. If heater keeps shutting off, have it serviced. Keep process and will not occur again. burner and control compartment clean. After extended periods of non-operation such as follow- When lit for the first time, the fireplace will emit a slight ing a vacation or a warm weather season, the fireplace...

  • Page 12: Maintenance

    OXYGEN DEPLETION SENSOR PILOT MAINTENANCE CLEANING TURN OFF THE GAS AND ELECTRICAL POWER BEFORE SERVICING THE FIREPLACE. CAUTION: Label all wires prior to disconnection when servic- This procedure must be performed by a qualified ing controls. Wiring errors can cause improper and dangerous service person! operation.

  • Page 13: Replacements

    REPLACEMENTS Contact your dealer for questions concerning prices and information: availability of replacement parts. Normally all parts can be 1. M & S ODEL ERIAL UMBER OF FIREPLACE ordered through your Napoleon dealer or distributor. 2. I NSTALLATION DATE OF FIREPLACE When ordering replacement parts always give the following 3.
  • Page 14 W415-0297 / K / 11.20.07...

  • Page 15: Trouble Shooting Guide

    TROUBLE SHOOTING GUIDE EFORE ATTEMPTING TO TROUBLESHOOT PURGE YOUR UNIT AND INITIALLY LIGHT THE PILOT AND THE MAIN BURNER WITH THE GLASS DOOR REMOVED SYMPTOM PROBLEM TEST SOLUTION Main burner goes Pilot fl ame is not large enough - service or replace Oxygen Depletion Sensor System out;...
  • Page 16 SYMPTOM PROBLEM TEST SOLUTION Pilot goes out while Gas piping is undersized. - turn on all gas appliances and see if pilot fl ame fl utters, diminishes or s t a n d i n g ; M a i n extinguishes, especially when main burner ignites.
  • Page 17 W415-0297 / K / 11.20.07...
  • Page 18 NOTES W415-0297 / K / 11.20.07...

This manual is also suitable for:

Gvf36p

Table of Contents