Sharp AL-2020 Operation Manual page 78

8.EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering Measures
Ventilation
Exposure Limit Values
OSHA-PEL(USA)
ACGIH-TLV(USA)
Personal Protective Equipment
Respiratory Protection
Hand Protection
Eye Protection
Skin Protection
Other Protective Equipment
9.PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State : Solid
Ph
Boiling / Melting Point
Softening Point(°C)
Flash Point(°C)
Ignition Point(°C )
Explosion Properties
Density(g/cm³)
Solubility in Water
10.STABILITY AND REACTIVITY
Stability
Hazardous Reactions
Conditions to Avoid
Materials to Avoid
Hazardous Decomposition Products : CO, CO
Further Information
11.TOXICOLOGICAL INFORMATION
Acute Toxicity
Ingestion(oral)
Inhalation
Eye irritation
Skin irritation
Skin sensitizer
Mutagenicity
Carcinogenicity
76
MATERIAL SAFETY DATA SHEET
: Not required under intended use.
3
: 15mg/m
3
: 10mg/m
: Not required under intended use.
: Not required under intended use.
: Not required under intended use.
: Not required under intended use.
: Use of a dust mask and goggles are recommended when handling a large
quantity of toner or during long term exposure, as with any non-toxic dust.
Form : Powder
: Not applicable
: Not applicable
: 130
: Not applicable
: No data
: No data
: 1.1
: Negligible
: Stable
: Dust explosion, like most finely divided organic powders.
: Electric discharge, throwing into fire.
: Oxidizing Materials
: None
: LD > 2000mg/kg (Rats)
50
: LC >5.14mg/L Rats
50
: Not an irritant (Rabbits)
: Not an irritant (Rabbits)
: No sensitization
: Negative(Ames Test).
: In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible human
carcinogen). This classification is given to chemicals for which there is inadequate human
evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The
classification is based upon the development of lung tumors in rats receiving chronic inhalation
exposures to free carbon black at levels that induce particle overload of the lung. Studies
performed in animal models other than rats did not show any association between carbon black
3
(Total Dust), 5mg/m (Respirable Dust)
3
(Total Dust), 3mg/m (Respirable Dust)
Color : Black
and NO
2 X
Page : 3/4
Date Revised : Mar . 1. 2007
Date Issued : Sep . 1. 2003
MSDS No. F-01231
Odor : faint odor