Installing And Removing The Door - Montigo L38DF-ST Indoor Installation & Maintenance Manual

Section 7: Installing & Removing the Door
Removing the door:
The L38DF-ST* doors are removed in a few simple steps. Follow
these instructions below to remove the Horizontal access panel,
unlatch the door buckles and, remove the door. Replace in reverse
order.
Step 1:
Remove the Horizontal cover
by placing fingers in both finger
holes, then pushing away from
you and lifting out. Place it
aside during maintenance or
cleaning.
Install in reverse order.
Figure 22. Removing and installing the Horizontal Access Panel
Step 2: Locate the Door Buckles.
Figure 22a. Locate the door buckles. Both sides typical.
Step 3:
Locate Door Buckle Tool.
Hand-hold
Figure 22b. Door buckle Tool
Step 4:
Firmly grasp hand-hold
end of Door buckle tool
and place the machined
end in the slot under door
frame. (as shown)
Figure 22c.
XG0810 - 070714
Installation
Finger Holes
Installed Gas
Valve Cove r
Door Latch Slot
Door Latch Hook
1
Step 5:
Ensure the tool is firmly
in the lower end of the
slot, (as shown), Then pull
toward you (Caution: hold
the tool securely).
Figure 22d.
Step 6:
Pull hard if necessary to
release the spring ten-
sion. (Caution: The latch
springs back with force,
hold the tool securely).
Figure 22e.
Step 7:
Remove the tool from
the latch slot. Ensure the
latches are hanging freely,
the hook end is released
from the bottom of the door.
(Repeat all 4-steps for the
remaining latches).
Figure 22f.
Step 8:
Removing the Door:
Grasp the Door on either side, usually midway and lift upward,
lift the door carefully up and away from the front of the fireplace.
See Figures 22g. Place the Door aside in a safe place while
maintenance and / or cleaning is being performed.
Figure 22g. Removing and installing the glass doors. Both sides
typical.
Installing the Door:
To install the door, hook the top edge of the door frame into place.
Lower the door into position and follow the previous steps shown in
reverse order.
L38DF-ST* Indoor Gas Fireplace
2
3
4
Page 21